Power Train. Review the 58 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Vehicle Speed Control. Review the 40 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Steering. Review the 35 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

32 crash reports3 fire reports16 injury reports

Tires complaints

9 reports

Clear category filter

98,000 miles · Sep 15, 2015

Tires

Read full complaint

TL* THE CONTACT OWNS A 2004 TOYOTA HIGHLANDER EQUIPPED WITH MICHELIN LTX M/S2 TIRES, SIZE: P225/75/R16 (NA). WHILE DRIVING 55 MPH, THE CONTACT HEARD AN ABNORMAL NOISE COMING FROM THE REAR OF THE VEHICLE. IN ADDITION, THE REAR OF THE VEHICLE BEGAN TO SHAKE. UPON INSPECTION, THE CONTACT NOTICED THAT THE REAR PASSENGER SIDE TIRE BLEW OUT AND THE THREAD SEPARATED FROM THE BELT. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE TIRE WAS NOT REPLACED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE FAILURE MILEAGE WAS 98,000 AND THE TIRE FAILURE MILEAGE WAS 20,000.

NHTSA ODI #10763812

95,995 miles · Apr 14, 2014

Tires

TL* THE CONTACT OWNS A 2004 TOYOTA HIGHLANDER EQUIPPED WITH HANKOOK DYNAPRO HT TIRE, SIZE: P225-70-16T, AND DOT NUMBER: 7ADHUH. THE CONTACT STATED THAT WHILE DRIVING 65 MPH, THE FRONT DRIVER'S SIDE TIRE DEFLATED. THE CONTACT ADDED AIR TO THE TIRE AND DISCOVERED THAT THE TIRE BELT WAS SEPARATED AND BUBBLING. THE TIRE WAS REPLACED…

Read full complaint

NHTSA ODI #10579640

Mileage unknown · Oct 21, 2007

Tires

OUR SUV STARTED SERIOUSLY SKIDDING ON THE ROAD SURFACE WHILE DRIVING, CHECK THE TREAD AND FOUND INSIDE AND OUTSIDE OF TIRES EDGES BALD, AND CENTER OF TIRE ALSO POOR TREAD. SO FOR THE SAFETY OF MYSELF AND FAMILY I HAD ALL 4 TIRES REPLACED. *TR

NHTSA ODI #10206425

29,750 miles · Dec 9, 2006

Tires

Read full complaint

I HAD A TIRE GO VERY NEARLY FLAT AND THE LOW TIRE INDICATOR ON MY 04 TOYOTA HIGHLANDER NEVER ILLUMINATED. A PASSING MOTORIST MADE ME AWARE OF THE TIRE CONDITION. I BARELY WAS ABLE TO MAKE IT TO A STATION WITHOUT RUINING THE ALMOST NEW TIRE. I HAD JUST CAME INTO TOWN, AND WAS PREVIOUSLY AT HIGHWAY SPEED WITH 2 ELDERLY PASSENGERS BESIDES MYSELF. MY LOCAL TOYOTA DEALER HERE IN MCKINNEY TX SAID THAT TOYOTA TECH SUPPORT SAYS THERE IS NOTHING THEY CAN DO. EVEN THOUGH I HAD JUST DRIVEN ABOUT 5 MILES TO THE DEALERSHIP WITH ONE TIRE PURPOSELY UNDER INFLATED BY 10 POUNDS TO PROVE TO THEM THAT IT WAS NOT WORKING, THEY ARE TELLING ME THAT TOYOTA WILL DO NOTHING ABOUT IT, EXCEPT TO VERIFY THAT THERE IS NO CODES SET IN THE COMPUTER! *JB

NHTSA ODI #10175675

16,000 miles · Aug 22, 2006

Tires

DURING REGULAR MAINTENANCE IN MY TOYOTA HIGHLANDER 4X4 2004 WITH A 20000 MILES, THE DEALERSHIP INFORM ME THAT THE TIRES NEED TO BE REPLACE AND TOLD ME THAT WARRANTY DOES NOT INCLUDE TIRES. I STRONGLY BELIEVE THAT TIRES SHOULD HOLD MORE THEN 15000 MILES. THE TIRES ARE BRIDGESTONE DUELER H/T 687. *NM

NHTSA ODI #10166227

22,115 miles · Jul 27, 2006

Tires

DT*: THE CONTACT STATED THAT ALL 4 TIRES DRY ROTTED ON THE SIDEWALLS. THE VEHICLE WAS TAKEN TO A PRIVATE REPAIR SHOP. THERE WERE NO REPAIRS OR REPLACEMENTS MADE.

NHTSA ODI #10163632

8,000 miles · Jan 27, 2006

Tires

IT IS NOT POSSIBLE TO SAFELY DRIVE THE TOYOTA HIGHLANDER 2004 WITH THE MICHELIN 225/65/R17 TIRES SOLD AS ORIGINAL EQUIPMENT IN ANY KIND OF SNOW CONDITIONS. EVEN WITH AS LITTLE AS 1-2 INCHES OF SNOW THESE TIRES ON THE HIGHLANDER TRAP AND BUILD UP SNOW IN THE WHEEL WELL LEAVING THE DRIVER WITH NO STOPPING ABILITY.*AK

NHTSA ODI #10148854

Mileage unknown · Jul 13, 2005

Engine And Engine CoolingTires

INDICATOR LIGHTS ON DASH SAY CONTACT YOUR DEALER. ONE IS THE TIRE PRESSURE AND THE OTHER IS THE ENGINE. HAVE CARRIED TO DEALER 3 TIMES AND STILL OCCURS. THEY ARE SUPPOSED TO PICKUP TOMORROW AND CORRECT TIRE PRESSURE LIGHT. ONLY LISTED LAST DATE

NHTSA ODI #10128624

16,287 miles · Jun 4, 2005

Tires

Read full complaint

MY VEHICLE IS A 2004 TOYOTA HIGHLANDER. DURING THE 15,000 MILE SERVICE AT THE DEALERSHIP, IT WAS BROUGHT TO MY ATTENTION THAT ALL 4 TIRES WERE WORN TO THE POINT OF NEEDING REPLACEMENT. THE SERVICE TECHNICIAN TOLD ME THAT THE TIRES WERE WEARING EVENLY AND THE TIRE PRESSURE WAS AT THE RECCOMMENDED PRESSURE. DURING MY INSPECTION I COULD FEEL SOME SLIGHT CUPPING ON THE OUTSIDE EDGE OF THE TIRES. THE TIRES ARE TOYO TRANPATH A11 SIZE P225/70R16. THE DEALERSHIP IS SUPPOSED TO CONTACT MANUFACTURER TO SEE WHAT KIND OF ASSISTANCE THEY CAN PROVIDE. THIS IS VERY SIMILAR TO ODI NUMBER 10067341

NHTSA ODI #10124188

Official recalls

11V539000 · Engine And Engine Cooling

Nov 9, 2011

TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004 AVALON VEHICLES; 2004 AND 2005 CAMRY, CAMRY SOLARA, HIGHLANDER, AND SIENNA VEHICLES, 2006 HIGHLANDER HYBRID; 2004 AND 2005 LEXUS ES330 AND RX330; AND 2006 LEXUS RX400H VEHICLES MANUFACTURED FROM JUNE 1, 2004 THROUGH MARCH 31, 2005, EQUIPPED WITH THE 1MZ-FE OR 3MZ-FE ENGINE. THE AMOUNT OF ADHESIVE AGENT APPLIED BETWEEN THE OUTER RING AND THE TORSIONAL RUBBER DAMPER (INNER RING) IN THE CRANKSHAFT PULLEY MAY BE INADEQUATE. IF THE ADHESIVE IS INSUFFICIENT, THERE IS A POSSIBILITY THAT THE OUTER RING MAY BECOME MISALIGNED AND IT MAY NOT PROPERLY ROTATE WITH THE INNER RING, CAUSING NOISE AND/OR ILLUMINATION OF THE BATTERY DISCHARGE INDICATOR LIGHT.

Consequence & remedy

Consequence: IN SOME CASES, THE BELT FOR THE POWER STEERING PUMP MAY BECOME DETACHED FROM THE PULLEY WHICH COULD RESULT IN A LOSS OF POWER STEERING AND A SUDDEN INCREASE IN STEERING EFFORT, INCREASING THE RISK OF A CRASH.

Remedy: TOYOTA WILL NOTIFY OWNERS, AND DEALERS WILL CHECK THE CRANKSHAFT PULLEY TO IDENTIFY WHETHER IT WAS PRODUCED BY THE U.S. SUPPLIER. IF SO, THE DEALER WILL REPLACE THE PULLEY WITH A NEW ONE AT NO CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING EARLY JANUARY 2012. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.

11V112000 · Vehicle Speed Control:accelerator Pedal

Feb 24, 2011

TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004-2006 HIGHLANDER, HIGHLANDER HYBRID, AND MODEL YEAR 2004-2007 LEXUS RX330, RX350, AND RX400H VEHICLES. IF THE FORWARD RETENTION CLIP USED TO SECURE THE FLOOR CARPET COVER, WHICH IS LOCATED IN FRONT OF THE CENTER CONSOLE, IS NOT INSTALLED PROPERLY THE COVER MAY LEAN TOWARD THE ACCELERATOR PEDAL AND INTERFERE WITH THE ACCELERATOR PEDAL ARM.

Consequence & remedy

Consequence: IF THIS OCCURS, THE ACCELERATOR PEDAL MAY TEMPORARILY BECOME STUCK IN A PARTIALLY DEPRESSED POSITION RATHER THAN RETURN TO THE IDLE POSITION. A STUCK ACCELERATOR PEDAL MAY RESULT IN UNINTENDED AND SUSTAINED VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP, INCREASING THE RISK OF A VEHICLE CRASH.

Remedy: DEALERS WILL REPLACE THE FLOOR CARPET COVER WITH A NEWLY DESIGNED ONE FREE OR CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING MARCH 2011. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.

10V499000 · Service Brakes, Hydraulic:foundation Components:master Cylinder

Oct 21, 2010

TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2006 AVALON, MODEL YEAR 2004-2006 HIGHLANDER, MODEL YEAR 2004-2006 LEXUS RX, AND MODEL YEAR 2006 LEXUS GS AND IS VEHICLES. BRAKE FLUID CONTAINING POLYMERS IS USED THAT ACTS AS LUBRICANTS FOR CERTAIN BRAKE SYSTEM COMPONENTS. IF REPLACEMENT BRAKE FLUID IS USED THAT DOES NOT CONTAIN SUCH POLYMERS, OR THAT CONTAINS ONLY SMALL AMOUNTS, A PART OF THE RUBBER SEAL LOCATED AT THE REAR OF THE BRAKE MASTER CYLINDER MAY BECOME DRY, AND THE SEAL MAY CURL DURING MOVEMENT OF THE PISTON. IF THIS OCCURS, A SMALL AMOUNT OF BRAKE FLUID COULD SLOWLY LEAK FROM THE SEAL INTO THE BRAKE BOOSTER.

Consequence & remedy

Consequence: A LEAK OF BRAKE FLUID COULD LEAD TO A CHANGE IN BRAKE PEDAL FEEL AND OVERTIME A DEGRADATION IN BRAKING PERFORMANCE INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL REPLACE THE SEAL WITH A NEWLY DESIGNED ONE. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 15, 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331 AND LEXUS AT 1-800-255-3987.

06V253000 · Vehicle Speed Control:accelerator Pedal

Jul 13, 2006

ON CERTAIN SPORT UTILITY AND HYBRID VEHICLES, THE TWO RETAINING CLIPS FOR THE DRIVER'S SIDE FORWARD CENTER CONSOLE CAN BECOME LOOSE. IF BOTH CLIPS SEPARATE FROM THE FLOOR CARPET COVER, THE COVER MAY LEAN TOWARD THE ACCELERATOR PEDAL, CAUSING INTERFERENCE WITH THE ACCELERATOR PEDAL ROD.

Consequence & remedy

Consequence: THIS CONDITION MAY INTERFERE WITH THE ACCELERATOR PEDAL RETURNING TO THE IDLE POSITION INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL REPLACE THE TWO FLOOR CARPET COVER RETAINING CLIPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 24, 2006, AND SHOULD BE COMPLETED BY EARLY SEPTEMBER 2006. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331 OR LEXUS AT 1-800-255-3987.

04V181000 · Latches/locks/linkages:doors:latch

Apr 15, 2004

CERTAIN SPORT UTILITY VEHICLES HAVE A CHILD PROTECTION LOCK (CPL) SYSTEM ON BOTH OF THE REAR SIDE DOORS. WHEN AN OPERATOR OF THE VEHICLE CLOSES THE DOOR VERY HARD WITH THE CPL LEVER SET TO THE LOCK POSITION, THERE IS A POSSIBILITY THAT THE LEVER MAY CONTACT THE BODY PANEL, CAUSING THE CPL LEVER TO MOVE INTO THE UNLOCK POSITION.

Consequence & remedy

Consequence: THIS CONDITION COULD ALLOW THE DOOR TO BE OPENED WITH THE INSIDE WHILE THE OPERATOR BELIEVES THAT THE CPL WAS ACTIVATED. IF THE DOOR WERE OPENED FROM THE INSIDE WHILE THE VEHICLE WAS IN MOTION, AN OCCUPANT COULD FALL OUT AND BE INJURED.

Remedy: DEALERS WILL SHORTEN THE CPL LEVER. OWNER NOTIFICATION BEGAN MAY 7, 2004. OWNERS SHOULD CONTACT TOYOTA AT 1-800-331-4331.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

RQ10003 · Unintended And Uncontrolled Acceleration

Opened Feb 16, 2010 · Closed Mar 1, 2011

Status: closed (inferred from source dates) · Electrical System:software; Vehicle Speed Control:accelerator Pedal

On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.

Additional source detail variants (6)

Electrical System:software

Vehicle Speed Control:accelerator Pedal