IllustrationTRACTION CONTROL CAME ON DURING NORMAL DRIVING
2004 Toyota Highlander
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2004 Toyota Highlander do not stand out strongly from the model-year median of 186.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Highlander years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
690–25K
4325–50K
3750–75K
3075–100K
41100–150K
15150K+
235 reports with mileage · 51 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Power Train. Review the 58 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Vehicle Speed Control. Review the 40 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Steering. Review the 35 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
32 crash reports3 fire reports16 injury reports
What owners actually said
286 reportsWE HAVE A VEHICLE WITH A 2.4LITER/4 CYLINGER ENGINE THAT IS LOOSING OIL AT A RATE OF 1QRT PER 1000 MILES AND NOW THERE IS A COOLANT LEAK COMING FROM THE GASKET SEAL BETWEEN THE ENGINE BLOCK AND HEAD. THERE IS NO GUAGE THAT TELLS YOU HOW MUCH OIL IS MISSING UNTIL IT'S TOO LATE AND THE ENGINE STARTS TO OVER HEAT. BOTH THE OIL AND…
Read full complaint
WE HAVE A VEHICLE WITH A 2.4LITER/4 CYLINGER ENGINE THAT IS LOOSING OIL AT A RATE OF 1QRT PER 1000 MILES AND NOW THERE IS A COOLANT LEAK COMING FROM THE GASKET SEAL BETWEEN THE ENGINE BLOCK AND HEAD. THERE IS NO GUAGE THAT TELLS YOU HOW MUCH OIL IS MISSING UNTIL IT'S TOO LATE AND THE ENGINE STARTS TO OVER HEAT. BOTH THE OIL AND COOLANT IS LEAKING ON ROADS, PARKING LOTS AND DRIVEWAYS, WHAT WE HAVE FOUND IS THAT THE BOLTS THAT ARE NEAREST THE LEAK ARE STRIPPED, THEY EITHER STRIPPED IN ASSEMBLY OR FLAILED DO TO OVERHEATING OF THE BLOCK DO TO THE ENGINE BLOCK NOT HAVING SUFFICIENT COOLING BECAUSE OF A HEAVY FOAM PAD THAT RESTRICTS AIR FLOE AROUND THE ENGINE CAUSING THE HEAD TO FLEX AND LEAK AT THE GASKET SEAL BASED ON ONLINE COMPLAINTS THERE ARE HUNDREDS, IF NOT THOUSANDS OF OWNERS WITH THIS SAME PROBLEM. SEEMS THAT SOME OF THESE ENGINES ARE HAVING SUCCESS BY DRILLING, TAPPING AND INSERTING NEW COILS INTO THE ALUMINUM BLOCK, WHICH MAY OR MAY NOT BE A PERMANENT SOLUTION. IT SEEMS THAT TOYOTA IS AWARE OF THE PROBLEM AND REFUSES TO REPAIR THE DAMAGE. THE MOST COMMON SUGGESTED REPAIR IS TO REPLACE THE MOTOR AND WE ASSUME THAT THEY PROBLEM WILL HAPPEN AGAIN SINCE THEY HAVE REDESIGNED THE PROBLEM.. REPLACEMENT IS AT THE OWNERS COST FOR MATERIALS AND LABOR AT APPROX $6,000-$8,000.
TL* THE CONTACT OWNS A 2004 TOYOTA HIGHLANDER EQUIPPED WITH MICHELIN LTX M/S2 TIRES, SIZE: P225/75/R16 (NA). WHILE DRIVING 55 MPH, THE CONTACT HEARD AN ABNORMAL NOISE COMING FROM THE REAR OF THE VEHICLE. IN ADDITION, THE REAR OF THE VEHICLE BEGAN TO SHAKE. UPON INSPECTION, THE CONTACT NOTICED THAT THE REAR PASSENGER SIDE TIRE BL…
Read full complaint
TL* THE CONTACT OWNS A 2004 TOYOTA HIGHLANDER EQUIPPED WITH MICHELIN LTX M/S2 TIRES, SIZE: P225/75/R16 (NA). WHILE DRIVING 55 MPH, THE CONTACT HEARD AN ABNORMAL NOISE COMING FROM THE REAR OF THE VEHICLE. IN ADDITION, THE REAR OF THE VEHICLE BEGAN TO SHAKE. UPON INSPECTION, THE CONTACT NOTICED THAT THE REAR PASSENGER SIDE TIRE BLEW OUT AND THE THREAD SEPARATED FROM THE BELT. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE TIRE WAS NOT REPLACED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE FAILURE MILEAGE WAS 98,000 AND THE TIRE FAILURE MILEAGE WAS 20,000.
BEGAN DRIVING VEHICLE A WEEK AGO, USED TO BE MY WIFE'S VEHICLE. I NOTICED A SQUEAK IN THE DRIVER'S SEAT, AND NOTICED IT WIGGLED. I EXAMINED THE MOUNTING BOLTS, AND ALL 4 SEAT BOLTS WERE LOOSE, NOT EVEN FINGER TIGHT. THE ONLY SERVICE PERFORMED ANYWHERE NEAR THE SEAT WAS RECALL WORK ON THE FLOOR MAT RETAINING CLIP AND A SEAL IN TH…
Read full complaint
BEGAN DRIVING VEHICLE A WEEK AGO, USED TO BE MY WIFE'S VEHICLE. I NOTICED A SQUEAK IN THE DRIVER'S SEAT, AND NOTICED IT WIGGLED. I EXAMINED THE MOUNTING BOLTS, AND ALL 4 SEAT BOLTS WERE LOOSE, NOT EVEN FINGER TIGHT. THE ONLY SERVICE PERFORMED ANYWHERE NEAR THE SEAT WAS RECALL WORK ON THE FLOOR MAT RETAINING CLIP AND A SEAL IN THE BRAKE MASTER CYLINDER, BOTH RECALLS WERE DONE SIMULTANEOUSLY AT RUDY LUTHER TOYOTA, 8805 WAYZATA BLVD, GOLDEN VALLEY, MN 55426. RECALL WORK WAS DONE A COUPLE YEARS AGO. I TIGHTENED THE BOLTS WITH MY OWN TOOLS. PASSENGER SEAT BOLTS WERE TIGHT.
GAS STATION DID NOT CLOSE HOOD COMPLETELY AND IT BLEW OPEN WHILE TRYING TO ENTER THE HIGHWAY AT JUST OVER 40 MILES PER HOUR.THE SECONDARY SAFETY CATCH DID NOT HOLD OR WORK ! THE HOOD BLEW OPEN AND SHATTERED THE WINDSHIELD AND BENT THE HOOD UP INTO THE ROOF.THE TOPS OF THE FENDERS NEAR THE HINGES WERE ALSO RIPPED UP.
WAS DRIVING ON THE HIGHWAY ABOUT 60-65 MPH WHEN ENGINE BEGAN OVER HEATING. PULL OVER RADIATOR WAS LOW. PUT ANTIFREEZE IN DROVE HOME CHECK WAS ALLOW AGAIN. THE NEXT CALLED TOYOTA DEALER, WITH OUT EVEN LOOKING THEY SAID YOU PROBABLY HAVE A BLOWN HEAD GASKET. BUT WHEN WE TEAR IT DOWN AND IF THE HEAD BOLTS ARE STRIPPED OUT IT WILL …
Read full complaint
WAS DRIVING ON THE HIGHWAY ABOUT 60-65 MPH WHEN ENGINE BEGAN OVER HEATING. PULL OVER RADIATOR WAS LOW. PUT ANTIFREEZE IN DROVE HOME CHECK WAS ALLOW AGAIN. THE NEXT CALLED TOYOTA DEALER, WITH OUT EVEN LOOKING THEY SAID YOU PROBABLY HAVE A BLOWN HEAD GASKET. BUT WHEN WE TEAR IT DOWN AND IF THE HEAD BOLTS ARE STRIPPED OUT IT WILL COST UPWARDS OF 2000.00. SO NOW I HAVE THE CAR IN AN INDEPENDENT SHOP. I'M OUT ALMOST 800.00 NOW, AND THE CARS STILL NOT FIXED. I BELIEVE TOYOTA KNEW ABOUT THIS PROBLEM LONG BEFORE I BOUGHT THIS CAR. I WENT ON THE INTERNET AND FOUND THE HAS BEEN HAPPENING IN 2001-2006 MODELS.I THINK THEY SHOULD BE HELD RESPONSIBLE. *TR
WHEN DRIVING THE HEATER OR THE AIR WILL JUST COME ON, USUALLY WHEN YOU WOULD DRIVE OVER A ROUGH SPOT IN THE STREET.USUALLY THE AIR WILL COME ON IN THE WINTER AND THE HEATER WILL COME ON IN SUMMER.CALL TOYOTA THEY SAID COST ABOUT 800.00. I HAD IT FIX BY AN INDEPENDENT GARAGE.IT STILL COST ME 370.00. THEN I GO ON LINE AND OUT THER…
Read full complaint
WHEN DRIVING THE HEATER OR THE AIR WILL JUST COME ON, USUALLY WHEN YOU WOULD DRIVE OVER A ROUGH SPOT IN THE STREET.USUALLY THE AIR WILL COME ON IN THE WINTER AND THE HEATER WILL COME ON IN SUMMER.CALL TOYOTA THEY SAID COST ABOUT 800.00. I HAD IT FIX BY AN INDEPENDENT GARAGE.IT STILL COST ME 370.00. THEN I GO ON LINE AND OUT THERE'S HUNDREDS IF NOT LOTS MORE PEOPLE THAT HAVE THE SAME PROBLEM.I THINK SINCE THERE IS SO MANY PEOPLE THAT THIS SAME PROBLEM THAT TOYOTA SHOULD REIMBURSE US AT LEAST PARTLY. *TR
MY CAR BEGAN OVERHEATING AT 140K MILES. TOOK IT TO A MECHANIC AND HAD THE WATER PUMP AND THERMOSTAT REPLACED. THE CAR OVERHEATED AGAIN A WEEK LATER. TOOK IT BACK TO THE MECHANIC AND HE TOLD ME THE HEAD GASKET WAS BLOWN AND HAD TO BE REPLACED. WHEN HE WENT TO REPLACE THE GASKET HE FOUND THAT THREE HEAD BOLTS WERE STRIPPED ON THE …
Read full complaint
MY CAR BEGAN OVERHEATING AT 140K MILES. TOOK IT TO A MECHANIC AND HAD THE WATER PUMP AND THERMOSTAT REPLACED. THE CAR OVERHEATED AGAIN A WEEK LATER. TOOK IT BACK TO THE MECHANIC AND HE TOLD ME THE HEAD GASKET WAS BLOWN AND HAD TO BE REPLACED. WHEN HE WENT TO REPLACE THE GASKET HE FOUND THAT THREE HEAD BOLTS WERE STRIPPED ON THE BLOCK. THE CYLINDER HEAD BOLTS SEPARATING FROM LOWER PART OF ENGINE BLOCK CAUSED A COOLANT LEAK. THIS IS OBVIOUSLY A MANUFACTURING ERROR. THIS CAR WAS BOUGHT BRAND NEW AND HAS BEEN DRIVEN BY THE SOLE OWNER. HAD OIL CHANGES EVERY 3,000 MILES AND NEVER HAD AN ISSUE BEFORE NOW. PLEASE PLACE A RECALL FOR THIS DEFECT. THIS IS NOT THE OWNERS FAULT, NOR SHOULD IT BE THEIR RESPONSIBILITY. *TR
TL* THE CONTACT OWNS A 2004 TOYOTA HIGHLANDER. WHILE DRIVING APPROXIMATELY 45 MPH, THE BATTERY INDICATOR LIGHT ILLUMINATED AND THE POWER STEERING FAILED SUDDENLY. THE CONTACT HAD TO MANEUVER THE VEHICLE TO THE SIDE OF THE ROAD. THE VEHICLE FAILED TO RESTART AND WAS TOWED TO THE CONTACT'S RESIDENCE. THE MANUFACTURER WAS NOTIFIED …
Read full complaint
TL* THE CONTACT OWNS A 2004 TOYOTA HIGHLANDER. WHILE DRIVING APPROXIMATELY 45 MPH, THE BATTERY INDICATOR LIGHT ILLUMINATED AND THE POWER STEERING FAILED SUDDENLY. THE CONTACT HAD TO MANEUVER THE VEHICLE TO THE SIDE OF THE ROAD. THE VEHICLE FAILED TO RESTART AND WAS TOWED TO THE CONTACT'S RESIDENCE. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE. THE VEHICLE WAS NOT REPAIRED. THE VIN PROVIDED WAS INVALID. THE APPROXIMATE FAILURE MILEAGE WAS 90,000.
AS SHOWN ON YOUR COMPLAINT SECTION I AMONG MANY MANY OTHERS HAVE BEEN SOLD A DEFECTIVE 2.4 LITER ENGINE 4 CYLINDER. THE HEAD BOLTS BECOME STRIPPED AND MIGRATE LOOSE OVER TIME AND THERE IS NO REPAIR SOLUTION. YOU HAVE TO SCRAP THE ENGINE AND MAYBE THE WHOLE VEHICLE NO MATTER HOW GOOD OF CONDITION ITS IN. THIS PROBLEM CAUSES A …
Read full complaint
AS SHOWN ON YOUR COMPLAINT SECTION I AMONG MANY MANY OTHERS HAVE BEEN SOLD A DEFECTIVE 2.4 LITER ENGINE 4 CYLINDER. THE HEAD BOLTS BECOME STRIPPED AND MIGRATE LOOSE OVER TIME AND THERE IS NO REPAIR SOLUTION. YOU HAVE TO SCRAP THE ENGINE AND MAYBE THE WHOLE VEHICLE NO MATTER HOW GOOD OF CONDITION ITS IN. THIS PROBLEM CAUSES A BLOWN HEAD GASKET AND RESULTING MAJOR LEAKAGE OF ANTIFREEZE WHICH IS A LIFE THREATENING CHEMICAL BABIES AND PETS DRINK AND DIE FROM. I FIRST FOUND THIS POOL OF ANTIFREEZE ON MY GARAGE FLOOR AND I HAVE 2 DOGS! NOT TO MENTION GETTING STRANDED OUT IN TRAFFIC OR A DESOLATE AREA WHEN ENGINE OVERHEATING OCCURS PUTTING YOUR OWN LIFE IN DANGER FROM BECOMING A STRANDED MOTORIST. *TR
Official recalls
511V539000 · Engine And Engine Cooling
Nov 9, 2011
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004 AVALON VEHICLES; 2004 AND 2005 CAMRY, CAMRY SOLARA, HIGHLANDER, AND SIENNA VEHICLES, 2006 HIGHLANDER HYBRID; 2004 AND 2005 LEXUS ES330 AND RX330; AND 2006 LEXUS RX400H VEHICLES MANUFACTURED FROM JUNE 1, 2004 THROUGH MARCH 31, 2005, EQUIPPED WITH THE 1MZ-FE OR 3MZ-FE ENGINE. THE AMOUNT OF ADHESIVE AGENT APPLIED BETWEEN THE OUTER RING AND THE TORSIONAL RUBBER DAMPER (INNER RING) IN THE CRANKSHAFT PULLEY MAY BE INADEQUATE. IF THE ADHESIVE IS INSUFFICIENT, THERE IS A POSSIBILITY THAT THE OUTER RING MAY BECOME MISALIGNED AND IT MAY NOT PROPERLY ROTATE WITH THE INNER RING, CAUSING NOISE AND/OR ILLUMINATION OF THE BATTERY DISCHARGE INDICATOR LIGHT.
Consequence & remedy
Consequence: IN SOME CASES, THE BELT FOR THE POWER STEERING PUMP MAY BECOME DETACHED FROM THE PULLEY WHICH COULD RESULT IN A LOSS OF POWER STEERING AND A SUDDEN INCREASE IN STEERING EFFORT, INCREASING THE RISK OF A CRASH.
Remedy: TOYOTA WILL NOTIFY OWNERS, AND DEALERS WILL CHECK THE CRANKSHAFT PULLEY TO IDENTIFY WHETHER IT WAS PRODUCED BY THE U.S. SUPPLIER. IF SO, THE DEALER WILL REPLACE THE PULLEY WITH A NEW ONE AT NO CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING EARLY JANUARY 2012. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
11V112000 · Vehicle Speed Control:accelerator Pedal
Feb 24, 2011
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004-2006 HIGHLANDER, HIGHLANDER HYBRID, AND MODEL YEAR 2004-2007 LEXUS RX330, RX350, AND RX400H VEHICLES. IF THE FORWARD RETENTION CLIP USED TO SECURE THE FLOOR CARPET COVER, WHICH IS LOCATED IN FRONT OF THE CENTER CONSOLE, IS NOT INSTALLED PROPERLY THE COVER MAY LEAN TOWARD THE ACCELERATOR PEDAL AND INTERFERE WITH THE ACCELERATOR PEDAL ARM.
Consequence & remedy
Consequence: IF THIS OCCURS, THE ACCELERATOR PEDAL MAY TEMPORARILY BECOME STUCK IN A PARTIALLY DEPRESSED POSITION RATHER THAN RETURN TO THE IDLE POSITION. A STUCK ACCELERATOR PEDAL MAY RESULT IN UNINTENDED AND SUSTAINED VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP, INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE FLOOR CARPET COVER WITH A NEWLY DESIGNED ONE FREE OR CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING MARCH 2011. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
10V499000 · Service Brakes, Hydraulic:foundation Components:master Cylinder
Oct 21, 2010
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2006 AVALON, MODEL YEAR 2004-2006 HIGHLANDER, MODEL YEAR 2004-2006 LEXUS RX, AND MODEL YEAR 2006 LEXUS GS AND IS VEHICLES. BRAKE FLUID CONTAINING POLYMERS IS USED THAT ACTS AS LUBRICANTS FOR CERTAIN BRAKE SYSTEM COMPONENTS. IF REPLACEMENT BRAKE FLUID IS USED THAT DOES NOT CONTAIN SUCH POLYMERS, OR THAT CONTAINS ONLY SMALL AMOUNTS, A PART OF THE RUBBER SEAL LOCATED AT THE REAR OF THE BRAKE MASTER CYLINDER MAY BECOME DRY, AND THE SEAL MAY CURL DURING MOVEMENT OF THE PISTON. IF THIS OCCURS, A SMALL AMOUNT OF BRAKE FLUID COULD SLOWLY LEAK FROM THE SEAL INTO THE BRAKE BOOSTER.
Consequence & remedy
Consequence: A LEAK OF BRAKE FLUID COULD LEAD TO A CHANGE IN BRAKE PEDAL FEEL AND OVERTIME A DEGRADATION IN BRAKING PERFORMANCE INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE SEAL WITH A NEWLY DESIGNED ONE. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 15, 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331 AND LEXUS AT 1-800-255-3987.
06V253000 · Vehicle Speed Control:accelerator Pedal
Jul 13, 2006
ON CERTAIN SPORT UTILITY AND HYBRID VEHICLES, THE TWO RETAINING CLIPS FOR THE DRIVER'S SIDE FORWARD CENTER CONSOLE CAN BECOME LOOSE. IF BOTH CLIPS SEPARATE FROM THE FLOOR CARPET COVER, THE COVER MAY LEAN TOWARD THE ACCELERATOR PEDAL, CAUSING INTERFERENCE WITH THE ACCELERATOR PEDAL ROD.
Consequence & remedy
Consequence: THIS CONDITION MAY INTERFERE WITH THE ACCELERATOR PEDAL RETURNING TO THE IDLE POSITION INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE TWO FLOOR CARPET COVER RETAINING CLIPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 24, 2006, AND SHOULD BE COMPLETED BY EARLY SEPTEMBER 2006. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331 OR LEXUS AT 1-800-255-3987.
04V181000 · Latches/locks/linkages:doors:latch
Apr 15, 2004
CERTAIN SPORT UTILITY VEHICLES HAVE A CHILD PROTECTION LOCK (CPL) SYSTEM ON BOTH OF THE REAR SIDE DOORS. WHEN AN OPERATOR OF THE VEHICLE CLOSES THE DOOR VERY HARD WITH THE CPL LEVER SET TO THE LOCK POSITION, THERE IS A POSSIBILITY THAT THE LEVER MAY CONTACT THE BODY PANEL, CAUSING THE CPL LEVER TO MOVE INTO THE UNLOCK POSITION.
Consequence & remedy
Consequence: THIS CONDITION COULD ALLOW THE DOOR TO BE OPENED WITH THE INSIDE WHILE THE OPERATOR BELIEVES THAT THE CPL WAS ACTIVATED. IF THE DOOR WERE OPENED FROM THE INSIDE WHILE THE VEHICLE WAS IN MOTION, AN OCCUPANT COULD FALL OUT AND BE INJURED.
Remedy: DEALERS WILL SHORTEN THE CPL LEVER. OWNER NOTIFICATION BEGAN MAY 7, 2004. OWNERS SHOULD CONTACT TOYOTA AT 1-800-331-4331.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1RQ10003 · Unintended And Uncontrolled Acceleration
Opened Feb 16, 2010 · Closed Mar 1, 2011
Status: closed (inferred from source dates) · Electrical System:software; Vehicle Speed Control:accelerator Pedal
On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.
Additional source detail variants (6)
Electrical System:software
On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.
Electrical System:software
On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.
Electrical System:software
On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.
Vehicle Speed Control:accelerator Pedal
On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.
Vehicle Speed Control:accelerator Pedal
On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.
Vehicle Speed Control:accelerator Pedal
On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.