Power Train. Review the 58 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Vehicle Speed Control. Review the 40 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Steering. Review the 35 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

32 crash reports3 fire reports16 injury reports

Fuel System, Gasoline complaints

6 reports

Clear category filter

141,000 miles · Jul 15, 2013

Fuel System, GasolineVehicle Speed ControlCrash

Read full complaint

AS I EXITED THE FREEWAY I TOOK MY FOOT OFF THE ACCELERATOR AND APPLIED THE BRAKE. THE CAR ACCELERATED AND DID NOT SLOW DOWN. I CROSSED BOTH LANES OF THE STREET AND I TURNED THE CAR TO THE RIGHT. THE WHEELS OF THE LEFT SIDE OF THE CAR HIT THE CURB AND THE FRONT AND REAR WHEELS ON THE LEFT SIDE OF THE CAR BROKE OFF. THEN, THE CAR WENT OVER THE CURB AND HIT THE STATE SIGN WITH THE LEFT FRONT OF THE CAR. THE CAR GOT STUCK IN DEEP MULCH FROM RECENT LANDSCAPING AND CAME TO A STOP.

NHTSA ODI #10525448

Mileage unknown · Jan 18, 2008

Fuel System, Gasoline

SINCE THE VEHICLE WAS FIRST PURCHASED, THE ENGINE, VSC, AND TRACKING LIGHT BEGAN GOING ON AND OFF INTERMITTENTLY. MARIETTA TOYOTA PERSONNEL TOLD ME THAT THE GAS CAP WAS NOT ON TIGHT ENOUGH AND I SHOULD TIGHTEN IT. CALLS WERE MADE NUMEROUS TIMES TO THEM. SINCE MAY, 2007 THE LIGHTS ARE ON CONSTANTLY AND WILL NOT GO OFF. I KEEP GET…

Read full complaint

NHTSA ODI #10215399

Mileage unknown · Jul 31, 2006

Fuel System, GasolineVehicle Speed Control

2004 TOYOTA HIGHLANDER ENGINE DIES, WOULD NOT ACCELERATE PAST 20 MPH, ENGINE LIGHT AND VSC AND TRAC OFF LIGHTS WERE ON, WOULD SLOW DOWN TO 10 MPH WITHOUT WARNING. *KB THE THROTTLE BODY CONTROL UNIT WAS REPAIRED SEVERAL TIMES. JB

NHTSA ODI #10164775

6,000 miles · Jan 2, 2006

Electrical SystemFuel System, GasolineSteering

Read full complaint

IDENTICAL TO COMPLAINT #10114548 MY EVENT HAPPENED JANUARY 6, 2005 WITH LESS THAN 10,000 MILES ON VEHICLE. NOW, AT 35,750 MILES, I HAVE O2 SENSOR PROBLEMS ON A ROUTINE BASIS(3RD SENSOR ON ORDER FROM DEALER RIGHT NOW). I AM VERY CONCERNED THAT THESE PROBLEMS WILL CONTINUE PAST WARRANTY, I HAVE LITTLE FAITH IN THIS VEHICLES SAFETY AND PERFORMANCE -EVERY DAY I CROSS MY FINGERS THAT NOTHING ELSE GOES "BRAKES" WHILE DRIVING WITH MY 2 SMALL CHILDREN. THIS NEEDS TO BE INVESTIGATED. *NM

NHTSA ODI #10146704

Mileage unknown · Dec 6, 2005

Fuel System, GasolinePower Train

Read full complaint

THE AUTOMATIC TRANSMISSION ELECTRONICS GET CONFUSED AT STREET SPEEDS, NOT ALLOWING ME TO ACCELERATE, ESPECIALLY WHEN MAKING A LEFT ACROSS TRAFFIC. I HAVE BEEN NEARLY T-BONED ON NUMEROUS OCCASIONS. I TALKED TO THE TOYOTA DEALERSHIP ABOUT A YEAR AGO, AND THE TECHNICIAN SAID THAT HE WAS AWARE OF THE PROBLEM AND EXPECTS TOYOTA TO COME UP WITH A SOFTWARE UPDATE TO FIX THE PROBLEM. RECENTLY, I LEFT A MESSAGE WITH THE SAME TECHNICIAN ASKING WHAT PROGRESS HAS BEEN MADE, AND I RECEIVED NO REPLY. IT IS EXTREMELY SCARY TO FIND THIS 'DEAD SPOT' IN ACCELERATION. THIS IS OUR FOURTH TOYOTA, AND MIGHT BE THE LAST IF TOYOTA DOES NOT ADDRESS THIS ACCIDENT WAITING TO HAPPEN. *JB

NHTSA ODI #10144572

1 miles · Nov 22, 2004

Fuel System, Gasoline

Read full complaint

HAVE EXPERIENCED ACCELERATION HESITATION PROBLEM ON 2004 TOYOTA HIGHLANDER. HAVE TAKEN THE CAR TO TOYOTA WHO INSIST THAT THE CAR IF FINE AND PERFORMING TO THEIR SPECS. ALSO CONTACTED THEIR REGIONAL OFFICE AND WAS TOLD TO PERIODICALLY CHECK WITH THE DEALERSHIP TO SEE IF A TECHNICAL SERVICE BULLETIN MAY HAVE BEEN ISSUES, BUT AS OF NOW NOTHING WAS BEING WORKED ON. TOYOTA DID ISSUES A TSB ON A DIFFERENT 2004 MODEL. AS MY WIFE DRIVES THIS CAR USUALLY WITH CHILDREN I AM VERY CONCERNED ABOUT THIS HESITATION. *JB

NHTSA ODI #10100327

Official recalls

11V539000 · Engine And Engine Cooling

Nov 9, 2011

TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004 AVALON VEHICLES; 2004 AND 2005 CAMRY, CAMRY SOLARA, HIGHLANDER, AND SIENNA VEHICLES, 2006 HIGHLANDER HYBRID; 2004 AND 2005 LEXUS ES330 AND RX330; AND 2006 LEXUS RX400H VEHICLES MANUFACTURED FROM JUNE 1, 2004 THROUGH MARCH 31, 2005, EQUIPPED WITH THE 1MZ-FE OR 3MZ-FE ENGINE. THE AMOUNT OF ADHESIVE AGENT APPLIED BETWEEN THE OUTER RING AND THE TORSIONAL RUBBER DAMPER (INNER RING) IN THE CRANKSHAFT PULLEY MAY BE INADEQUATE. IF THE ADHESIVE IS INSUFFICIENT, THERE IS A POSSIBILITY THAT THE OUTER RING MAY BECOME MISALIGNED AND IT MAY NOT PROPERLY ROTATE WITH THE INNER RING, CAUSING NOISE AND/OR ILLUMINATION OF THE BATTERY DISCHARGE INDICATOR LIGHT.

Consequence & remedy

Consequence: IN SOME CASES, THE BELT FOR THE POWER STEERING PUMP MAY BECOME DETACHED FROM THE PULLEY WHICH COULD RESULT IN A LOSS OF POWER STEERING AND A SUDDEN INCREASE IN STEERING EFFORT, INCREASING THE RISK OF A CRASH.

Remedy: TOYOTA WILL NOTIFY OWNERS, AND DEALERS WILL CHECK THE CRANKSHAFT PULLEY TO IDENTIFY WHETHER IT WAS PRODUCED BY THE U.S. SUPPLIER. IF SO, THE DEALER WILL REPLACE THE PULLEY WITH A NEW ONE AT NO CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING EARLY JANUARY 2012. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.

11V112000 · Vehicle Speed Control:accelerator Pedal

Feb 24, 2011

TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004-2006 HIGHLANDER, HIGHLANDER HYBRID, AND MODEL YEAR 2004-2007 LEXUS RX330, RX350, AND RX400H VEHICLES. IF THE FORWARD RETENTION CLIP USED TO SECURE THE FLOOR CARPET COVER, WHICH IS LOCATED IN FRONT OF THE CENTER CONSOLE, IS NOT INSTALLED PROPERLY THE COVER MAY LEAN TOWARD THE ACCELERATOR PEDAL AND INTERFERE WITH THE ACCELERATOR PEDAL ARM.

Consequence & remedy

Consequence: IF THIS OCCURS, THE ACCELERATOR PEDAL MAY TEMPORARILY BECOME STUCK IN A PARTIALLY DEPRESSED POSITION RATHER THAN RETURN TO THE IDLE POSITION. A STUCK ACCELERATOR PEDAL MAY RESULT IN UNINTENDED AND SUSTAINED VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP, INCREASING THE RISK OF A VEHICLE CRASH.

Remedy: DEALERS WILL REPLACE THE FLOOR CARPET COVER WITH A NEWLY DESIGNED ONE FREE OR CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING MARCH 2011. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.

10V499000 · Service Brakes, Hydraulic:foundation Components:master Cylinder

Oct 21, 2010

TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2006 AVALON, MODEL YEAR 2004-2006 HIGHLANDER, MODEL YEAR 2004-2006 LEXUS RX, AND MODEL YEAR 2006 LEXUS GS AND IS VEHICLES. BRAKE FLUID CONTAINING POLYMERS IS USED THAT ACTS AS LUBRICANTS FOR CERTAIN BRAKE SYSTEM COMPONENTS. IF REPLACEMENT BRAKE FLUID IS USED THAT DOES NOT CONTAIN SUCH POLYMERS, OR THAT CONTAINS ONLY SMALL AMOUNTS, A PART OF THE RUBBER SEAL LOCATED AT THE REAR OF THE BRAKE MASTER CYLINDER MAY BECOME DRY, AND THE SEAL MAY CURL DURING MOVEMENT OF THE PISTON. IF THIS OCCURS, A SMALL AMOUNT OF BRAKE FLUID COULD SLOWLY LEAK FROM THE SEAL INTO THE BRAKE BOOSTER.

Consequence & remedy

Consequence: A LEAK OF BRAKE FLUID COULD LEAD TO A CHANGE IN BRAKE PEDAL FEEL AND OVERTIME A DEGRADATION IN BRAKING PERFORMANCE INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL REPLACE THE SEAL WITH A NEWLY DESIGNED ONE. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 15, 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331 AND LEXUS AT 1-800-255-3987.

06V253000 · Vehicle Speed Control:accelerator Pedal

Jul 13, 2006

ON CERTAIN SPORT UTILITY AND HYBRID VEHICLES, THE TWO RETAINING CLIPS FOR THE DRIVER'S SIDE FORWARD CENTER CONSOLE CAN BECOME LOOSE. IF BOTH CLIPS SEPARATE FROM THE FLOOR CARPET COVER, THE COVER MAY LEAN TOWARD THE ACCELERATOR PEDAL, CAUSING INTERFERENCE WITH THE ACCELERATOR PEDAL ROD.

Consequence & remedy

Consequence: THIS CONDITION MAY INTERFERE WITH THE ACCELERATOR PEDAL RETURNING TO THE IDLE POSITION INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL REPLACE THE TWO FLOOR CARPET COVER RETAINING CLIPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 24, 2006, AND SHOULD BE COMPLETED BY EARLY SEPTEMBER 2006. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331 OR LEXUS AT 1-800-255-3987.

04V181000 · Latches/locks/linkages:doors:latch

Apr 15, 2004

CERTAIN SPORT UTILITY VEHICLES HAVE A CHILD PROTECTION LOCK (CPL) SYSTEM ON BOTH OF THE REAR SIDE DOORS. WHEN AN OPERATOR OF THE VEHICLE CLOSES THE DOOR VERY HARD WITH THE CPL LEVER SET TO THE LOCK POSITION, THERE IS A POSSIBILITY THAT THE LEVER MAY CONTACT THE BODY PANEL, CAUSING THE CPL LEVER TO MOVE INTO THE UNLOCK POSITION.

Consequence & remedy

Consequence: THIS CONDITION COULD ALLOW THE DOOR TO BE OPENED WITH THE INSIDE WHILE THE OPERATOR BELIEVES THAT THE CPL WAS ACTIVATED. IF THE DOOR WERE OPENED FROM THE INSIDE WHILE THE VEHICLE WAS IN MOTION, AN OCCUPANT COULD FALL OUT AND BE INJURED.

Remedy: DEALERS WILL SHORTEN THE CPL LEVER. OWNER NOTIFICATION BEGAN MAY 7, 2004. OWNERS SHOULD CONTACT TOYOTA AT 1-800-331-4331.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

RQ10003 · Unintended And Uncontrolled Acceleration

Opened Feb 16, 2010 · Closed Mar 1, 2011

Status: closed (inferred from source dates) · Electrical System:software; Vehicle Speed Control:accelerator Pedal

On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.

Additional source detail variants (6)

Electrical System:software

Vehicle Speed Control:accelerator Pedal