MY FRONT TIRES, (FROM A SET OF FOUR), HAVE PARTS OF THE TREAD SEPARATING FROM THE TIRE BODY. THE RUBBER UNDER THE MISSING PIECES OF TREAD HAS A TEXTURE LIKE POPCORN. THE INNER SURFACE OF THE RUBBER IS SHINY AND SMOOTH. *DT IT IS NOT FROM GOUGING, FORCE, OR ABUSE TO THE TIRES. IT IS AS IF THE MANUFACTURING PROCESS USED TWO DIF…
Read full complaint
MY FRONT TIRES, (FROM A SET OF FOUR), HAVE PARTS OF THE TREAD SEPARATING FROM THE TIRE BODY. THE RUBBER UNDER THE MISSING PIECES OF TREAD HAS A TEXTURE LIKE POPCORN. THE INNER SURFACE OF THE RUBBER IS SHINY AND SMOOTH. *DT IT IS NOT FROM GOUGING, FORCE, OR ABUSE TO THE TIRES. IT IS AS IF THE MANUFACTURING PROCESS USED TWO DIFFERENT BATCHES OF RUBBER THAT WAS NOT INCORPORATED TOGETHER CORRECTLY, AND IS NOW SEPARATING FROM ITSELF. THIS IS CLEARLY A MANUFACTURING DEFECT AND SHOULD BE RECALLED IMMEDIATELY! IF A TIRE FAILURE OCCURS FROM THIS DEFECT AT SPEED, IT COULD CAUSE A SERIOUS ACCIDENT, ROLLOVER, HEAD-ON, SERIOUS INJURY/DEATH. PLEASE REVIEW HIS MATTER AS SOON AS POSSIBLE. PLEASE CONTACT ME FOR PICTURES OF THE DEFECT, SINCE THE WEBSITE HAS NO WAY TO UPLOAD THE PICS.*DT*JB *TR
NHTSA ODI #11324339
108,300 miles · Sep 4, 2005
Tires
ON SEPTEMBER 3RD 2005 AT 11:30 PM WHILE TRAVELING AT APPROXIMATELY 75 MPH ON INTERSTATE 5 -15 MILES SOUTH OF SACRAMENTO CALIFORNIA I EXPERIENCED A CATASTROPHIC FAILURE (SIDEWALL BLOWOUT SEPARATION OF SIDEWALL FROM TREAD) ON ONE OF MY REAR BRIDGESTONE P22570S16 BSDLRAPT30 DUELER AT TIRES. THIS TIRE HAD LESS THAN 13,000 MILES ON …
Read full complaint
ON SEPTEMBER 3RD 2005 AT 11:30 PM WHILE TRAVELING AT APPROXIMATELY 75 MPH ON INTERSTATE 5 -15 MILES SOUTH OF SACRAMENTO CALIFORNIA I EXPERIENCED A CATASTROPHIC FAILURE (SIDEWALL BLOWOUT SEPARATION OF SIDEWALL FROM TREAD) ON ONE OF MY REAR BRIDGESTONE P22570S16 BSDLRAPT30 DUELER AT TIRES. THIS TIRE HAD LESS THAN 13,000 MILES ON IT AND WAS INFLATED TO 32 PSI. THE RODE-WAY SURFACE WAS IN GOOD CONDITION. ON SUNDAY SEPTEMBER 4TH 2005 I WENT TO SEARS WHERE I PURCHASED THE SET OF FOUR TIRES TO HAVE THE DAMAGED ONE REPLACED. UPON EXAMINATION OF THE REMAINING THREE TIRES FOR SIDEWALL DAMAGE AND IN DISCUSSIONS WITH THE INSTALLATION TECHNICIAN I DECIDED THAT BECAUSE OF THIS INCIDENT AND A STATEMENT BY THE TECH THAT THIS IS A COMMON OCCURRENCE WITH THIS TIRE, I REPLACED ALL FOUR WITH ANOTHER BRAND. SEARS OFFERED TO GIVE ME FULL CREDIT FOR TWO FOR THE FOUR TIRES TOWARDS THE PURCHASE OF ANOTHER BRAND OF TIRE. *JB
NHTSA ODI #10135304
4,500 miles · Apr 25, 2003
Tires
VEHICLE TIRE PUNCTURED. MR THE CONSUMER EXPERIENCED 5 TIRE FAILURES ON 5 SEPARATE OCCASIONS. *JB
NHTSA ODI #10017575
4,500 miles · Mar 17, 2003
Tires
FAILURE OF DEULER TIRES. VEHICLE EXPERIENCED FIVE TIRE FAILURES AT DIFFERENT MILEAGES ( 4500, 12816, 15480, 20000, 29160). *TT *NLM
NHTSA ODI #10009723
18,000 miles · Mar 11, 2003
Tires
UNEXPECTED TIRE FAILURE OF A BRIDGESTONE H/T P225/70R16.*JB
NHTSA ODI #10010285
10,000 miles · Jan 27, 2003
Tires
THE CONSUMER WAS TRAVELING ON THE HIGHWAY WHEN THE FRONT TIRE BLEW OUT. REGAINING CONTROL, THE CONSUMER STATED THAT WHEN HE/SHE PULLED OVER, THEY SAW TWO HOLES, ONE WITH A 3" AND THE OTHER 1" IN SIZE (THE SIDEWALL). THE TWO RIGHT SIDE LIGHT METAL WHEELS WERE DAMAGED AS WELL. SCC
NHTSA ODI #10003739
Mileage unknown · Jun 26, 2002
Tires
FRONT TIRES CAUSE CAR TO VIBRATE ABOVE 60 MPH; SOMETIMES ENOUGH TO CAUSE ME TO DECCELERATE; VIBRATION PROBLEM STARTED LAST YEAR; TIRES CONTINUALLY GO OUT OF BALANCE; FIRESTONE DEALER SAYS THEY CAN'T SEE ANYTHING WRONG WITH THEM; GOODYEAR DEALER SAID THE TIRES WOBBLE ON THEIR BALANCING MACHINE AND SHOULD BE REPLACED; FIRESTONE SA…
Read full complaint
FRONT TIRES CAUSE CAR TO VIBRATE ABOVE 60 MPH; SOMETIMES ENOUGH TO CAUSE ME TO DECCELERATE; VIBRATION PROBLEM STARTED LAST YEAR; TIRES CONTINUALLY GO OUT OF BALANCE; FIRESTONE DEALER SAYS THEY CAN'T SEE ANYTHING WRONG WITH THEM; GOODYEAR DEALER SAID THE TIRES WOBBLE ON THEIR BALANCING MACHINE AND SHOULD BE REPLACED; FIRESTONE SAYS THEY CAN'T DO ANYTHING FOR ME AND SAY THERE MUST BE SOMETHING WRONG WITH THE VEHICLE.*AK
NHTSA ODI #763510
Mileage unknown · Oct 23, 2001
Tires
FRONT TIRES ARE WEARING OUT. VEHICLE IS ALL WHEEL DRIVE, NOT 4 WHEEL, AS ADVERTISED. ALIGNMENT MAY BE COMPUTER CONTROLLED. COMPUTER MAY BE DEFECTIVE, AS THIS IS THE SECOND ONE SINCE PURCHASED IN 02/01.*AK
NHTSA ODI #753585
Mileage unknown · Aug 7, 2001
Tires
WHILE ATTEMPTING TO MAKE A U-TURN ON DRY HOT ROAD CONDITIONS ORGINAL EQUIPMENT BRIDGESTONE, DUELER HT TIRE WITH ONE THOUSAND MILES ON IT, SIZE P225/70R16 FRONT PASSENGER SIDE TIRE HAD A BLOWOUT. BRIDGESTONE HAS BEEN CONTACTED.*AK *JB
CERTAIN SPORT UTILITY VEHICLES HAVE A CHILD PROTECTION LOCK (CPL) SYSTEM ON BOTH OF THE REAR SIDE DOORS. WHEN AN OPERATOR OF THE VEHICLE CLOSES THE DOOR VERY HARD WITH THE CPL LEVER SET TO THE LOCK POSITION, THERE IS A POSSIBILITY THAT THE LEVER MAY CONTACT THE BODY PANEL, CAUSING THE CPL LEVER TO MOVE INTO THE UNLOCK POSITION.
Consequence & remedy
Consequence: THIS CONDITION COULD ALLOW THE DOOR TO BE OPENED WITH THE INSIDE WHILE THE OPERATOR BELIEVES THAT THE CPL WAS ACTIVATED. IF THE DOOR WERE OPENED FROM THE INSIDE WHILE THE VEHICLE WAS IN MOTION, AN OCCUPANT COULD FALL OUT AND BE INJURED.
Remedy: DEALERS WILL SHORTEN THE CPL LEVER. OWNER NOTIFICATION BEGAN MAY 7, 2004. OWNERS SHOULD CONTACT TOYOTA AT 1-800-331-4331.
ON SPORT UTILITY VEHICLES, THERE IS A BREATHER HOSE THAT ATTACHES TO THE NOZZLE OF THE ON-BOARD REFUELING VAPOR RECOVERY (ORVR) VALVE, WHICH IS LOCATED ON THE TOPSIDE OF THE FUEL TANK. THE BREATHER HOSE IS ATTACHED WITH A CLAMP, WHOSE "TABS" FACE IN THE UPWARD DIRECTION. WHEN THE VEHICLE WAS CRASHED UNDER THE NEW CAR ASSESSMENT PROGRAM (NCAP) TEST (I.E., 35 MPH FRONTAL BARRIER CRASH), THE CLAMP "TABS" CONTACTED THE UNDERSIDE OF THE BODY DUE TO MOVEMENT OF THE FUEL TANK, CAUSING THE NOZZLE TO BREAK.
Consequence & remedy
Consequence: IN THE WORST CASE, NOZZLE BREAKAGE COULD RESULT IN FUEL LEAKAGE IF THE VEHICLE ROLLS-OVER AFTER A HIGH SPEED FRONTAL CRASH.
Remedy: DEALERS WILL ROTATE THE SPECIFIED CLAMP. OWNER NOTIFICATION BEGAN SEPTEMBER 23, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT TOYOTA AT 1-800-331-4331.
VEHICLE DESCRIPTION: SPORT UTIITY VEHICLES. THE RESERVOIR FILLER CAP OF THE BRAKE MASTER CYLINDER MAY INDUCE A VACUUM, INTRODUCING SOME AIR INTO THE BRAKE MASTER CYLINDER RESERVOIR. THIS COULD CAUSE ABNORMAL BRAKE NOISE AND INCREASED PEDAL STROKE WHEN THE BRAKES ARE APPLIED.
Consequence & remedy
Consequence: THE INCREASED PEDAL STROKE WILL LENGTHEN THE STOPPING DISTANCE OF THE VEHICLE, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL BLEED THE AIR FROM THE BRAKE LINES AND REPLACE THE RESERVOIR FILLER CAP. OWNER NOTIFICATION BEGAN JULY 30, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT TOYOTA AT 1-800-331-4331.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2001 Toyota Highlander Problems, Complaints & Recalls | Skip That Year
Illustration