DT*: THE CONTACT STATED WHILE DRIVING 25 MPH ON A STREET WITH AN INFANT SEAT RESTRAINED WITH THE LAP AND SHOULDER BELT IN THE REAR, THE CHILD SAFETY SEAT COMPLETELY FLIPPED OVER WITH THE INFANT INSIDE. ALTHOUGH THIS HAPPENED WITHOUT WARNING, NO INJURIES WERE SUSTAINED. THE MANUFACTURER WAS NOT ALERTED. THE INFANT SEAT WAS A G…
Read full complaint
DT*: THE CONTACT STATED WHILE DRIVING 25 MPH ON A STREET WITH AN INFANT SEAT RESTRAINED WITH THE LAP AND SHOULDER BELT IN THE REAR, THE CHILD SAFETY SEAT COMPLETELY FLIPPED OVER WITH THE INFANT INSIDE. ALTHOUGH THIS HAPPENED WITHOUT WARNING, NO INJURIES WERE SUSTAINED. THE MANUFACTURER WAS NOT ALERTED. THE INFANT SEAT WAS A GRACO, SNUG RIDE, MODEL # 8643DDH2, DATE OF MANUFACTURE 12-03-2005. UPDATED 11/9/2006 - *NM
CERTAIN SPORT UTILITY VEHICLES HAVE A CHILD PROTECTION LOCK (CPL) SYSTEM ON BOTH OF THE REAR SIDE DOORS. WHEN AN OPERATOR OF THE VEHICLE CLOSES THE DOOR VERY HARD WITH THE CPL LEVER SET TO THE LOCK POSITION, THERE IS A POSSIBILITY THAT THE LEVER MAY CONTACT THE BODY PANEL, CAUSING THE CPL LEVER TO MOVE INTO THE UNLOCK POSITION.
Consequence & remedy
Consequence: THIS CONDITION COULD ALLOW THE DOOR TO BE OPENED WITH THE INSIDE WHILE THE OPERATOR BELIEVES THAT THE CPL WAS ACTIVATED. IF THE DOOR WERE OPENED FROM THE INSIDE WHILE THE VEHICLE WAS IN MOTION, AN OCCUPANT COULD FALL OUT AND BE INJURED.
Remedy: DEALERS WILL SHORTEN THE CPL LEVER. OWNER NOTIFICATION BEGAN MAY 7, 2004. OWNERS SHOULD CONTACT TOYOTA AT 1-800-331-4331.
ON SPORT UTILITY VEHICLES, THERE IS A BREATHER HOSE THAT ATTACHES TO THE NOZZLE OF THE ON-BOARD REFUELING VAPOR RECOVERY (ORVR) VALVE, WHICH IS LOCATED ON THE TOPSIDE OF THE FUEL TANK. THE BREATHER HOSE IS ATTACHED WITH A CLAMP, WHOSE "TABS" FACE IN THE UPWARD DIRECTION. WHEN THE VEHICLE WAS CRASHED UNDER THE NEW CAR ASSESSMENT PROGRAM (NCAP) TEST (I.E., 35 MPH FRONTAL BARRIER CRASH), THE CLAMP "TABS" CONTACTED THE UNDERSIDE OF THE BODY DUE TO MOVEMENT OF THE FUEL TANK, CAUSING THE NOZZLE TO BREAK.
Consequence & remedy
Consequence: IN THE WORST CASE, NOZZLE BREAKAGE COULD RESULT IN FUEL LEAKAGE IF THE VEHICLE ROLLS-OVER AFTER A HIGH SPEED FRONTAL CRASH.
Remedy: DEALERS WILL ROTATE THE SPECIFIED CLAMP. OWNER NOTIFICATION BEGAN SEPTEMBER 23, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT TOYOTA AT 1-800-331-4331.
VEHICLE DESCRIPTION: SPORT UTIITY VEHICLES. THE RESERVOIR FILLER CAP OF THE BRAKE MASTER CYLINDER MAY INDUCE A VACUUM, INTRODUCING SOME AIR INTO THE BRAKE MASTER CYLINDER RESERVOIR. THIS COULD CAUSE ABNORMAL BRAKE NOISE AND INCREASED PEDAL STROKE WHEN THE BRAKES ARE APPLIED.
Consequence & remedy
Consequence: THE INCREASED PEDAL STROKE WILL LENGTHEN THE STOPPING DISTANCE OF THE VEHICLE, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL BLEED THE AIR FROM THE BRAKE LINES AND REPLACE THE RESERVOIR FILLER CAP. OWNER NOTIFICATION BEGAN JULY 30, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT TOYOTA AT 1-800-331-4331.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2001 Toyota Highlander Problems, Complaints & Recalls | Skip That Year
Illustration