2020 Toyota Corolla

coolant bypass valve is defective and failed prematurely. coolant bypass valve cracks and leaks coolant. Once coolant beings leaking, it comes into contact with the electrical connector located near the valve. The coolant corrodes and damages the connector, which eventually causes connector to malfunction. This causes the coolant bypass valve to be stuck in the “open” or “closed” position (i.e. it no longer responds to the needs of the engine), restricting coolant flow and allowing the engine to overheat. I had to repair the vehicle at Harvey's Autotech 521 West Sixth Street Corona, CA 92882 (951) 737-9878 at the cost of $643.91and loss of a work day.

I was driving in traffic when a warning light comes on it says "engine maintenance required visit your dealer". I have looked everywhere in the manual on this message and unable to find anything no other lights are on or anything to determine the issue. Took it to get checked at autozone no codes came up all is clear. I've read online this is a known issue to replace the coolant bypass valve. Unfortunately I take my vehicle to toyota for all oil changes etc and this was not mentioned.

An engine maintenance required warning displayed on the car dashboard. Crown Toyota Ontario performed diagnostic inspection and detected that code P268115 - engine coolant bypass valve was defective. Based on research the P268115 - engine coolant bypass valve is a common failure to Toyota Corolla, RAV 4 and Camry by car owners for models manufactured in 2019 - 2023. Toyota Ontario advised that the defect is not covered by warranty. My corolla is a 2020 model with 77,379 mileage on it.

I had called Toyota colonial dealership in Milford CT. After briefly speaking with the service representative, he advised that it’s most likely the engine coolant bypass valve. He said that it is common with my car models. I did some extra research and found out that many others were having the same issue from only having the car for a few years.

Engine maintenance light came on after turning on air conditioner. Vehicle information: warning light came on at 56,800 miles on 2020 Toyota Corolla, no after market modifications to vehicle. I took vehicle to Toyota dealership for diagnostic testing. Conclusion: coolant bypass valve faulty causing leaks (this can cause overheating, stalling, increased emissions, and total engine failure and also allows coolant to leak into and damage surrounding engine components, including a vehicle's electrical system, the complaint relays). Fortunately, I PURCHASED AN EXTENDED WARRANTY when I bought the vehicle new, which covered the repairs. The faulty coolant bypass valve was replaced at the Toyota dealership. Had I not purchased the extended warranty, I would of been out of pocket for said repairs.