2020 Toyota Corolla

Part is the coolant bypass valve. Toyota has been taken to court but dealership claims now that I’m over 100k miles I can’t do it. There was also a second part about 10 years but I wasn’t clear on the details of the outcome. Toyota has acknowledged this issue in court but failed to do so at the customer level in my case. engine light came on at 97k and now I’m at 104k which is over that 100k mark. Issue is I’ve only take my car to Toyota for repairs. They have known about this but failed to repair or notify me of it. I would have immediately brought my car in at 97k if. I had known. This puts not only me but my 3 kids and entire family at risk every time i drive. This is known to the dealership and they been taken to court for failures to notify customers of this known defect. It’s been inspected by Toyota the last time I took it in about a week ago at 104k miles.

The contact owns a 2020 Toyota Corolla. The contact stated that while at a red light, the vehicle shut off with the check engine and several other unknown warning lights illuminated. The vehicle restarted after several attempts. The vehicle was taken to an independent mechanic and the failure was duplicated. The mechanic retrieved DTC: P1603; "Engine Stall History" (ECM recording an unexpected engine shutdown or a communication error with the Transmission Control Module (TCM). The mechanic associated the failure with NHTSA Campaign Number: 20V682000 (Fuel System, Gasoline) and referred the contact to the dealer for assistance. Several dealers were contacted, and the contact was informed that the VIN was not included in the recall. The manufacturer was not notified of the failure. The vehicle was not repaired. The failure mileage was approximately 59,000.

On June 19, 2025, I was driving and out of nowhere, there was a warning notification that said "A warning light was turned on. Would you like to call an operator?" On the digital cluster, there was a message that said "Engine Maintenance Required - Visit Your Dealer. Mileage noted down was 79,632. I asked around for some insight and people are telling me it's the water/coolant bypass valve that's leaking and the Op code is 24TE04R1. Will this be a covered service?

The engine maintenance required message appeared on the dash. I was travel from work to home (about 40 miles). I pulled over immediately at a store, left my car and walked over a mile to the mechanic shop down the road (in 95° weather with a knee that has been through 3 surgeries in less than 5 years). The gentleman took me back to my car. Followed me as i took my car back to the repair shop since it was close and did not have any lights on the dash and I was not overheating. He plugged a reader in it and the error was a coolant bypass valve issue (i can't remember the exact verbage). I purchased a replacement valve 6-17-25, along with toyota coolant. I am having to wait and save up the money to have the valve replaced at the shop got the message code from. I can not afford the dealerships cost to replace the valve. The valve and coolant was expensive in itself. I have read many forums and blogs. Toyota knew there was an issue and I am requesting my reimbursement for the cost of replacing a part you knew was faulty.