2020 Toyota Camry

Did not happen to this vehicle, but others the same year. I am a tech who has seen multiple failures of the crankshaft position plate which is mounted between the flywheel and crankshaft brake causing engine to shut down while driving due to crank position sensor not receiving signal. I am concerned because my wife drives one which is the vin I gave, that her car may cut off in traffic causing a accident. This part is defective with holes cut around it where the new replacement part is solid.This should be replaced at no cost to customers when vehicle warranty coverage has run out. Information below is for a vehicle that I worked on and have seen 3 others. One resulting in engine & transmission replacement due to excessive damage from plate coming apart. I work for Toyota & don't want my identity shared with them.

Fuel pump failure 1st. Car immediately stopped while driving on main road almost causing collision, engine light appeared only. Car had been inspected by local repair codes identify fuel pump malfunction. Fuel pump was replaced . Car was driven less than 5 minutes and overheated. Overheating light on dashboard , exclamation light and engine light appeared. reason is still yet unknown.

Car is regularly maintained, vehicle had to be what was a software or fuel supply issue. In hotter weather car stutters and engine will completely shut off while driving. It will begin to throw errors for second brake system malfunction, check engine, lane departure assist. Codes from obd2 read p12d5 and p107d. Seems like fuel stops is being cut off or extreme software issue. Regardless it has left my pregnant wife and 3 yr old son stranded in the middle of the road in 100 degree plus weather or then runs extremely rough. Have gone to a mechanic twice each time engine codes had shut off and there was nothing to be done at the moment. Issue still persists, it is still a danger and often it is difficult to have enough momentum to pull over somewhere safe. This issue may also cause further engine problems

I have owned 5 Toyotas and a Lexus SUV and never had so many problems. This is a 2020 Camry Hybrid with only 20492 miles on it. It has had to be jump-started 3-4 times so far, but now it has a new issue: While on a road trip with my wife thru Utah, the car suddenly shuts down, bells ringing and messages appearing. Cruise control, Lane departure, and Headlight System Failure. This happened on a 2-lane highway with very minimal shoulder. I pulled over as far as I could, but still slightly in the lane. Turned off the ignition and after a minute or so, was able to restart the car. Noted that the sign on the road said "Next Services 129 Miles"! This was on July 11, 2022 at about 3 PM. Once car was restarted, we drove to our destination without further issues, however I would not use Cruise control for fear it would happen again. Got back to California the next day and took it to dealer to investigate the cause. Their conclusion: "Extreme heat caused the warning lights to come on, but history code indicates that the issue resolved itself. The vehicle is operating normally at this time but the system will be affected by high temperatures and direct sunlight"!!! The temperature on the road at the time was 95 degrees. Dealer contacted Toyota's technical assistance hot line to document concern Case #221930394. Per the service department, they called the field rep who said if everything was functioning at this time, then there was no action to be taken. First of all, I am 75 years old and do not expect this from a car with only 20492 miles on it, and especially not from a Toyota. I find the "solution" to be completely foolish - avoid high temperatures and direct sunlight!! Temperatures over 95 degrees and direct sunlight are common in many states. Can someone please get to the bottom of this? I am beginning to think that I bought a lemon. I am also reporting it to NHTSA, as it is a safety issue that must be dealt with. Thank you,

When I press the button to start my 2020 Camry it has difficulty starting. It chugs/lags. It also smells of coolant/antifreeze when this happens. It has done this since the day I leased it. I have taken the vehicle back to the dealership 3 times and each time I’m told that they hooked it up to their computer and can’t find anything wrong and they can’t replicate the problem. I have had several witnesses/passengers inside and outside my vehicle who have heard the starting issue and commented on coolant smell. To date, my vehicle only has 7000 miles on it.

First time went to get in my vehicle and the car would not even open, not even the trunk. Had been parked over night. The car was deader than a door nail. The Toyota dealer had a tow truck dispatched to me with a charge box. The charge box would not even crank the vehicle. Had to use his tow truck to jump the car took to Toyota they said it needed a software update. Did it seemed fine now fast forward several months later now when it cranks doesn’t want to crank, dies then have to try again finally it crank. Took in today at dealer they tested battery said it’s showing 100% testing so not the battery then they say the update didn’t take back months ago so needs to be updated again 🤬. So now I’ve been shuttled home as it will take 2 plus hours. I’ve googled and seen so many complaints that are identical to mine and wondering why my vehicle has no recall when my vehicle has same issues apparently or I’m being lied to by the dealer cause I’ve got a complete lemon. I’ve owned many Toyota’s and never once had issues like this.