IllustrationMY CAR ALARM GOES OFF DURING THE NIGHT AND WILL NOT RESET. THIS HAS HAPPENED PERIODICALLY. *TR
2002 Toyota Camry
Owner reports · Recalls · Investigations
More warning signs than most Camry years
Owner complaints for the 2002 Toyota Camry are substantially higher than the model-year median of 295.
About this comparison →How this year compares
Owner complaints by model year
Compare all Camry years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1860–25K
11025–50K
8750–75K
8175–100K
96100–150K
50150K+
610 reports with mileage · 343 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Vehicle Speed Control. Review the 281 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 146 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 107 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
252 crash reports20 fire reports94 injury reports
What owners actually said
953 reportsTL*THE CONTACT OWNS A 2002 TOYOTA CAMRY. WHILE DRIVING AT ANY SPEED, THE CONTACT STATED THAT THE VEHICLE WOULD SUDDENLY STALL INTERMITTENTLY, THEN THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE DEALER ADVISED THE CONTACT TO BRING THE VEHICLE IN FOR DIAGNOSTIC TESTING. THE CONTACT DID NOT INFORM THE MANUFACTURER OF THE FAILURE …
Read full complaint
TL*THE CONTACT OWNS A 2002 TOYOTA CAMRY. WHILE DRIVING AT ANY SPEED, THE CONTACT STATED THAT THE VEHICLE WOULD SUDDENLY STALL INTERMITTENTLY, THEN THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE DEALER ADVISED THE CONTACT TO BRING THE VEHICLE IN FOR DIAGNOSTIC TESTING. THE CONTACT DID NOT INFORM THE MANUFACTURER OF THE FAILURE SINCE HE KNEW THAT THERE WERE NO RELATED RECALLS. NO REPAIRS WERE PERFORMED. THE CURRENT AND FAILURE MILEAGE WAS 50,000.
TL* THE CONTACT OWNS A 2002 TOYOTA CAMRY. THE CONTACT STATED THAT BLUE SMOKE WAS EMITTING FROM THE TAIL PIPE ABNORMALLY. THE CONTACT TOOK THE VEHICLE TO AN INDEPENDENT MECHANIC FOR AN OIL CHANGE AND THE MECHANIC ADVISED THAT THERE WAS SLUDGE BUILDING UP IN THE ENGINE AND CAUSING THE ENGINE TO BURN MILEAGE EXTREMELY QUICKLY. THE …
Read full complaint
TL* THE CONTACT OWNS A 2002 TOYOTA CAMRY. THE CONTACT STATED THAT BLUE SMOKE WAS EMITTING FROM THE TAIL PIPE ABNORMALLY. THE CONTACT TOOK THE VEHICLE TO AN INDEPENDENT MECHANIC FOR AN OIL CHANGE AND THE MECHANIC ADVISED THAT THERE WAS SLUDGE BUILDING UP IN THE ENGINE AND CAUSING THE ENGINE TO BURN MILEAGE EXTREMELY QUICKLY. THE FAILURE MILEAGE WAS 82,000 AND THE CURRENT MILEAGE WAS 89,000.
ATLANTA, GA, REQUIRES AN EMISSION INSPECTION EACH YEAR. MY 2002 CAMRY XLE HAS PASSED WITH NO PROBLEM IN PAST YEARS. WHEN THE INSPECTION TESTER WAS HOOKED TO THE CAR IT REPORTED "NOT READY" CODES IN ALL TEST CATEGORIES AND THE INSPECTION COULD NOT BE COMPLETED. I TOOK THE CAR TO MY MECHANIC AND HE COULD CLEAR THE COMPUTER AND …
Read full complaint
ATLANTA, GA, REQUIRES AN EMISSION INSPECTION EACH YEAR. MY 2002 CAMRY XLE HAS PASSED WITH NO PROBLEM IN PAST YEARS. WHEN THE INSPECTION TESTER WAS HOOKED TO THE CAR IT REPORTED "NOT READY" CODES IN ALL TEST CATEGORIES AND THE INSPECTION COULD NOT BE COMPLETED. I TOOK THE CAR TO MY MECHANIC AND HE COULD CLEAR THE COMPUTER AND GET IT TO RESET BUT ALMOST IMMEDIATELY THE CODES WOULD START TO DROP OFF TO "NOT READY" AGAIN. HE WAS ABLE TO GET IT TO SET LONG ENOUGH TO COMPLETE THE INSPECTION THAT PASSED PROPERLY AND THEN THE CODES BEGAN TO DROP OFF AGAIN. CALLS TO TOYOTA HAVE RECEIVED NO INFORMATION ON WHAT TO DO TO CORRECT THIS PROBLEM. *TR
TL* THE CONTACT OWNS A 2002 TOYOTA CAMRY. THE CONTACT STATED THAT WHILE DRIVING 50 MPH, HE NOTICED THAT THE TEMPERATURE GAUGE INCREASED AND THE VEHICLE OVERHEATED. HE PULLED OVER AND OPENED THE HOOD AND FOUND THAT THERE WAS NO COOLANT IN THE VEHICLE. THE VEHICLE WAS TOWED TO A LOCAL MECHANIC WHO ADVISED THAT THE HEAD BOLT WAS ST…
Read full complaint
TL* THE CONTACT OWNS A 2002 TOYOTA CAMRY. THE CONTACT STATED THAT WHILE DRIVING 50 MPH, HE NOTICED THAT THE TEMPERATURE GAUGE INCREASED AND THE VEHICLE OVERHEATED. HE PULLED OVER AND OPENED THE HOOD AND FOUND THAT THERE WAS NO COOLANT IN THE VEHICLE. THE VEHICLE WAS TOWED TO A LOCAL MECHANIC WHO ADVISED THAT THE HEAD BOLT WAS STRIPPED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT CALLED THE MANUFACTURER WHO OFFERED NO ASSISTANCE. THE CURRENT AND FAILURE MILEAGE WAS APPROXIMATELY 110,000. UPDATED 08/05/11*LJ UPDATED 08/15/11
STEERING WHEEL BECAME DIFFICULT TO TURN AND DID NOT RETURN TO CENTER WHEN RELEASED. CHECK POWER STEERING FLUID IT WAS OK. NO POWER STEERING LEAKS. TOOK CAR TO HAVE PROBLEM EVALUATED. MECHANIC SAID THAT STEERING SHAFT UNIVERSAL JOINTS WERE WORN AND RUSTED AND BINDING UP. ONLY SOLUTION WAS TO REPLACE ENTIRE STEERING COLUMN. …
Read full complaint
STEERING WHEEL BECAME DIFFICULT TO TURN AND DID NOT RETURN TO CENTER WHEN RELEASED. CHECK POWER STEERING FLUID IT WAS OK. NO POWER STEERING LEAKS. TOOK CAR TO HAVE PROBLEM EVALUATED. MECHANIC SAID THAT STEERING SHAFT UNIVERSAL JOINTS WERE WORN AND RUSTED AND BINDING UP. ONLY SOLUTION WAS TO REPLACE ENTIRE STEERING COLUMN. HE HAS SEEN THIS PROBLEM BEFORE. IF ALLOWED TO GO TOO LONG STEERING COULD LOCK UP COMPLETELY OR SHAFT COULD SHEAR CAUSING LOSS OF CONTROL. REPAIR WILL COST $900 SINCE ENTIRE SHAFT MUST BE REPLACED AND PART IS ONLY AVAILABLE FROM TOYOTA. I HAVE NEVER HAD THIS KIND OF PROBLEM WITH A VEHICLE AND WAS SHOCKED TO KNOW THE DESIGN OF THE STEERING SHAFT LEFT IT EXPOSED TO ROAD SPRAY AND SUBSEQUENT CORROSION DAMAGE. THIS IS A SERIOUS SAFETY ISSUE AND GAVE NO WARNING AS TO THE IMPENDING FAILURE. STEERING WHEEL BECAME VERY DIFFICULT TO TURN EVEN WITH THE POWER STEERING ASSIST. *TR
TRAVELING ON AN INTERSTATE HIGHWAY I ACCELERATED TO 60 OR 65 MPH. THE STEERING WHEEL BEGAN VIBRATING BADLY AND THE CAR STARTED TO SHAKE. ON SLOWING DOWN THE SHAKING LESSENED BUT CONTINUED AND THE STEERING WHEEL STOPPED VIBRATING. ON BRINGING THE CAR TO THE SHOP THEY DETERMINED THAT THE ENGINE MOUNTS HAD FAILED. ON REPLACING THE …
Read full complaint
TRAVELING ON AN INTERSTATE HIGHWAY I ACCELERATED TO 60 OR 65 MPH. THE STEERING WHEEL BEGAN VIBRATING BADLY AND THE CAR STARTED TO SHAKE. ON SLOWING DOWN THE SHAKING LESSENED BUT CONTINUED AND THE STEERING WHEEL STOPPED VIBRATING. ON BRINGING THE CAR TO THE SHOP THEY DETERMINED THAT THE ENGINE MOUNTS HAD FAILED. ON REPLACING THE MOUNTS ONE OF THEM HAD SPLIT INTO TWO PIECES.
I OWN A 2002 TOYOTA CAMRY 70,000 MI AND WHILE DRIVING ONE DAY THE STEERING FROZE AND I WAS UNABLE TO TURN THE WHEEL. SINCE THAT DAY THE STEERING HAS BECOME EXTREMELY STIFF AND HARD TO STEER. AFTER CHECKING THE POWER STEERING FLUID LEVELS AND FOUND IT TO BE NORMAL I HAVE MADE AN APPT WITH THE DEALERSHIP TO HAVE IT LOOKED AT. AFTE…
Read full complaint
I OWN A 2002 TOYOTA CAMRY 70,000 MI AND WHILE DRIVING ONE DAY THE STEERING FROZE AND I WAS UNABLE TO TURN THE WHEEL. SINCE THAT DAY THE STEERING HAS BECOME EXTREMELY STIFF AND HARD TO STEER. AFTER CHECKING THE POWER STEERING FLUID LEVELS AND FOUND IT TO BE NORMAL I HAVE MADE AN APPT WITH THE DEALERSHIP TO HAVE IT LOOKED AT. AFTER READING THESE COMPLAINTS I FEEL IT IS AN ISSUE WITH THE PART ITSELF AND A SAFETY ISSUE THAT TOYOTA SHOULD REPLACE. *TR
I RECEIVED A LETTER IN THE MAIL STATING THERE WAS A RECALL FOR MY SUNROOF MADE BY WEBASTO. THE SERIAL NUMBER OF MY SUNROOF IS BETWEEN THE RANGE OF 6000000 TO 6396298. I WOULD LIKE TO HAVE IT REPLACED IF THAT IS THE CASE, PLEASE. *TR
IN JULY 2010, I WAS DRIVING MY 2002 TOYOTA CAMRY AT APPROXIMATELY 40 MPH ON A HEAVILY TRAVELED TWO LANE HIGHWAY, ACCELERATING AS I APPROACHED A GRADE, WHEN SUDDENLY THERE WAS NO RESPONSE FROM MY ACCELERATOR PEDAL. THE CHECK ENGINE LIGHT CAME ON, AND THE CAR STALLED. THERE WAS A GROUP OF BICYCLISTS ON THE RIGHT SHOULDER. I ACT…
Read full complaint
IN JULY 2010, I WAS DRIVING MY 2002 TOYOTA CAMRY AT APPROXIMATELY 40 MPH ON A HEAVILY TRAVELED TWO LANE HIGHWAY, ACCELERATING AS I APPROACHED A GRADE, WHEN SUDDENLY THERE WAS NO RESPONSE FROM MY ACCELERATOR PEDAL. THE CHECK ENGINE LIGHT CAME ON, AND THE CAR STALLED. THERE WAS A GROUP OF BICYCLISTS ON THE RIGHT SHOULDER. I ACTIVATED MY EMERGENCY FLASHERS, AND MANAGED WITH DIFFICULTY TO PULL OFF THE ROAD. I COULD RESTART THE ENGINE, BUT THE CEL REMAINED ON, AND THE CAR WOULD NOT RESPOND TO THE ACCELERATOR IN ANY GEAR. THE CAR WAS TOWED TO THE DEALERSHIP, WHERE ERROR CODE P1121 WAS FOUND. THE ECU WAS REPLACED, AND I WAS ASSURED THE PROBLEM HAD BEEN RESOLVED. THIS WAS AN EXTREMELY DANGEROUS SITUATION THAT COST ME SEVERAL SLEEPLESS NIGHTS, AND IT WAS FORTUNATE THAT IT DID NOT RESULT IN AN ACCIDENT, INJURY, OR WORSE. ON FEBRUARY 17, 2011, I WAS DRIVING AT ABOUT 30-35 MPH WHEN ONCE AGAIN THE ACCELERATOR WOULD NOT RESPOND AND THE CEL LIT UP. THIS TIME, THE ENGINE DID NOT STALL. I PULLED OFF THE ROAD AND CHANGED GEARS AND DEPRESSED THE ACCELERATOR MANY TIMES WITH NO RESPONSE. FINALLY, THE CAR MOVED AND I WAS ABLE TO DRIVE IT THE SHORT DISTANCE HOME. AFTER CALLING THE DEALERSHIP, WHO AGREED THE CAR WAS NOT SAFE TO DRIVE UNTIL CHECKED, IT WAS TOWED TO THE DEALER, WHERE THE SAME CODE P1121 WAS READ. ALL COMPONENTS INDICATED BY THIS CODE WERE CHECKED AND DEEMED OKAY. AFTER THE DEALER CONTACTED TOYOTA, THE CAR WAS ALSO CHECKED FOR GROUNDING AND VOLTAGE ISSUES. AGAIN, EVERYTHING CHECKED OUT OKAY. THE DEALERSHIP KEPT AND DROVE THE CAR, TRYING UNSUCCESSFULLY TO DUPLICATE THE PROBLEM. IT REMAINS THERE TODAY WHILE WE DECIDE WHAT TO DO WITH IT. THE DEALERSHIP AND TOYOTA ARE NOT OFFERING ANY SOLUTIONS. I FEEL THAT THE CAR IS UNRELIABLE AND UNSAFE. RESEARCH ON THE INTERNET CONVINCES ME THIS IS NOT AN ISOLATED INCIDENT, AND IT NEEDS TO BE RESOLVED NO MATTER HOW MUCH IT COSTS. A PRICE CANNOT BE PUT ON LIFE OR PEACE OF MIND. PLEASE INVESTIGATE! UPDATED 06/24/11 *BF *TR REPAIRS ATTACHED.. UPDATED 01/05/2012 *LN
Official recalls
404V346000 · Air Bags:side/window
Jul 13, 2004
ON CERTAIN VEHICLES EQUIPPED WITH CURTAIN SHIELD AIR BAGS (CSA), ONE OR BOTH OF THE CURTAIN AIR BAGS MAY BE TWISTED NEAR THE INFLATOR DUE TO IMPROPER ASSEMBLY.
Consequence & remedy
Consequence: IF THIS OCCURS, THE CSA MAY NOT DEPLOY RAPIDLY ENOUGH WHEN ACTIVATED IN A SIDE IMPACT COLLISION. THIS MAY RESULT IN FAILURE TO PROVIDE THE INTENDED HEAD PROTECTION, INCREASING THE RISK OF INJURY.
Remedy: DEALERS WILL INSPECT THE CSAS AND REPLACE THE AIR BAG ASSEMBLY IF NECESSARY. THE RECALL BEGAN ON AUGUST 6, 2004. OWNERS SHOULD CONTACT TOYOTA AT 1-800-331-4331.
01V372000 · Air Bags:frontal
Dec 11, 2001
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH A THREE-SPOKE STYLE STEERING WHEEL. DURING AIR BAG DEPLOYMENT, IT IS POSSIBLE THAT THE BOTTOM SEAM OF THE FRONT DRIVER'S SIDE AIR BAG MODULE COVER (HORN PAD) COULD BE TORN AWAY ALLOWING THE BOTTOM PORTION OF THE COVER TO COMPLETELY DETACH FROM THE AIR BAG MODULE.
Consequence & remedy
Consequence: IF THIS SHOULD OCCUR, THERE IS A POSSIBILITY THAT THE DETACHED BOTTOM PORTION MAY STRIKE THE DRIVER CAUSING PERSONAL INJURY.
Remedy: DEALERS WILL REPLACE THE DRIVER'S SIDE AIR BAG MODULE. OWNER NOTIFICATION BEGAN DECEMBER 28, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT TOYOTA AT 1-800-331-4331 OR LEXUS AT 1-888-333-9376.
01V302000 · Tires
Oct 1, 2001
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH CONTINENTAL TOURING TIRES, P205-65R15 92S, INSTALLED AT THE PORTS IN JACKSONVILLE, FLORIDA. THE INCORRECT TIRES WERE INSTALLED ON VEHICLES THAT HAD DAMAGED TIRES. THE TIRES WERE DAMAGED DURING A PORT UPGRADE TO ALUMINUM WHEELS.
Consequence & remedy
Consequence: THE TIRES DO NOT CONFORM TO THE SPEED RATING FOR THE VEHICLE. IF THE VEHICLE EXCEEDED THE MAXIMUM SPEED RATING (112 MPH), POSSIBLE TIRE FAILURE COULD OCCUR.
Remedy: DEALERS WILL REPLACE ALL FIVE TIRES. OWNER NOTIFICATION BEGAN SEPTEMBER 13, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
01V306000 · Air Bags:frontal
Sep 25, 2001
VEHICLE DESCRIPTION: PASSENGER VEHICLES. INCOMPLETE DEPLOYMENT OF THE FRONT PASSENGER SIDE AIR BAG COULD OCCUR IN THE EVENT OF A CRASH.
Consequence & remedy
Consequence: UNEXPECTED AIR BAG DEPLOYMENT CAN RESULT IN OCCUPANT INJURY.
Remedy: DEALERS WILL REPLACE THE FRONT PASSENGER SIDE AIR BAG ASSEMBLY. BOTH OWNERS WERE NOTIFIED BY TELEPHONE AND ARRANGEMENTS HAVE BEEN MADE TO CORRECT THIS PROBLEM. THIS CAMPAIGN IS 100% COMPLETED. BOTH OWNERS HAVE BEEN NOTIFIED AND THEIR VEHICLES REPAIRED.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4DP06003 · Engine Surging
Opened Sep 14, 2006 · Closed Apr 3, 2007
Status: closed (inferred from source dates) · Vehicle Speed Control; Vehicle Speed Control:accelerator Pedal
THE PETITIONER OWNS A MY 2006 TOYOTA CAMRY WITH A 4-CYLINDER ENGINE THAT WAS PURCHASED NEW IN JANUARY 2006. THE PETITIONER ALSO PREVIOUSLY OWNED A MY 2005 CAMRY. HE ALLEGES THAT BOTH VEHICLES EXHIBITED VEHICLE ENGINE SURGING, WHICH HE DESCRIBED AS A SHORT DURATION (1 TO 2 SECOND) INCREASE IN ENGINE SPEED OCCURRING WHILE THE ACCELERATOR PEDAL IS NOT DEPRESSED. IN AN INITIAL INTERVIEW, THE PETITIONER ESTIMATED THAT 6 TO 8 SURGE INCIDENTS, OF VARYING SEVERITY, OCCURRED IN THE MY 2006 VEHICLE OVER THE COURSE OF 10,000 MILES AND 7 MONTHS OF OWNERSHIP. THE PETITIONER REPORTS THAT THE BRAKE SYSTEM IS EFFECTIVE AT OVERCOMING THE SURGE. HOWEVER, HE IS CONCERNED ABOUT REPORTS FILED WITH NHTSA ALLEGING UNCONTROLLEDSURGING IN MY 2002 TO 2006 CAMRY VEHICLES BRINGING THOSE VEHICLES TO A HIGH RATE OF SPEED (IN SOME CASES, PURPORTEDLY, WITH THE BRAKES APPLIED).AFTER REVIEW AND ANALYSIS OF THE AVAILABLE INFORMATION, ODI HAS NOT IDENTIFIED A VEHICLE-BASED DEFECT THAT WOULD HAVE PRODUCED THE ALLEGED ENGINE SURGE IN THE PETITIONER?S VEHICLE, NOR WAS IT ABLE TO WITNESS SUCH AN EVENT WHEN ROAD TESTING THE PETITIONER?S VEHICLE.EVALUATION OF A SUSPECT THROTTLE ACTUATOR REMOVED FROM THE PETITIONER?S VEHICLE DID NOT REVEAL A COMPONENT PROBLEM. WARRANTY AND PARTS SALES OF THE ACTUATOR ARE UNREMARKABLE.THESE DATA DO NOT SUPPORT THE EXISTENCE OF A WIDE-SPREAD DEFECT OR ONGOING CONCERN. THE FAULT DETECTION AND REACTION STRATEGY DESCRIBED IN TOYOTA?S TECHNICAL DOCUMENTS INDICATES THAT A LOSS OF THROTTLE CONTROL DUE TO A COMPONENT OR SYSTEM FAILURE WOULD BE DETECTED WITHIN A ONE SECOND PERIODAFTER WHICH ENGINE POWER WOULD BE LIMITED. THE PETITIONER?S MY 2006 VEHICLE BRAKE SYSTEM OVERCOMES FULL ENGINE POWER AT EASILY ACHIEVABLE BRAKE PEDAL FORCES. BASED ON THE ANALYSIS CONDUCTED, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION AND REMEDY OF A SAFETY RELATED DEFECT AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.CONSEQUENTLY, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA?S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY?S SAFETY MISSION, THE PETITION IS DENIED.PLEASE SEE THE MARCH 9, 2007 FEDERAL REGISTER NOTICE FOR FURTHER DETAILS.
Additional source detail variants (2)
Vehicle Speed Control:accelerator Pedal
THE PETITIONER OWNS A MY 2006 TOYOTA CAMRY WITH A 4-CYLINDER ENGINE THAT WAS PURCHASED NEW IN JANUARY 2006. THE PETITIONER ALSO PREVIOUSLY OWNED A MY 2005 CAMRY. HE ALLEGES THAT BOTH VEHICLES EXHIBITED VEHICLE ENGINE SURGING, WHICH HE DESCRIBED AS A SHORT DURATION (1 TO 2 SECOND) INCREASE IN ENGINE SPEED OCCURRING WHILE THE ACCELERATOR PEDAL IS NOT DEPRESSED. IN AN INITIAL INTERVIEW, THE PETITIONER ESTIMATED THAT 6 TO 8 SURGE INCIDENTS, OF VARYING SEVERITY, OCCURRED IN THE MY 2006 VEHICLE OVER THE COURSE OF 10,000 MILES AND 7 MONTHS OF OWNERSHIP. THE PETITIONER REPORTS THAT THE BRAKE SYSTEM IS EFFECTIVE AT OVERCOMING THE SURGE. HOWEVER, HE IS CONCERNED ABOUT REPORTS FILED WITH NHTSA ALLEGING UNCONTROLLEDSURGING IN MY 2002 TO 2006 CAMRY VEHICLES BRINGING THOSE VEHICLES TO A HIGH RATE OF SPEED (IN SOME CASES, PURPORTEDLY, WITH THE BRAKES APPLIED).AFTER REVIEW AND ANALYSIS OF THE AVAILABLE INFORMATION, ODI HAS NOT IDENTIFIED A VEHICLE-BASED DEFECT THAT WOULD HAVE PRODUCED THE ALLEGED ENGINE SURGE IN THE PETITIONER?S VEHICLE, NOR WAS IT ABLE TO WITNESS SUCH AN EVENT WHEN ROAD TESTING THE PETITIONER?S VEHICLE.EVALUATION OF A SUSPECT THROTTLE ACTUATOR REMOVED FROM THE PETITIONER?S VEHICLE DID NOT REVEAL A COMPONENT PROBLEM. WARRANTY AND PARTS SALES OF THE ACTUATOR ARE UNREMARKABLE.THESE DATA DO NOT SUPPORT THE EXISTENCE OF A WIDE-SPREAD DEFECT OR ONGOING CONCERN. THE FAULT DETECTION AND REACTION STRATEGY DESCRIBED IN TOYOTA?S TECHNICAL DOCUMENTS INDICATES THAT A LOSS OF THROTTLE CONTROL DUE TO A COMPONENT OR SYSTEM FAILURE WOULD BE DETECTED WITHIN A ONE SECOND PERIODAFTER WHICH ENGINE POWER WOULD BE LIMITED. THE PETITIONER?S MY 2006 VEHICLE BRAKE SYSTEM OVERCOMES FULL ENGINE POWER AT EASILY ACHIEVABLE BRAKE PEDAL FORCES. BASED ON THE ANALYSIS CONDUCTED, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION AND REMEDY OF A SAFETY RELATED DEFECT AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.CONSEQUENTLY, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA?S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY?S SAFETY MISSION, THE PETITION IS DENIED.PLEASE SEE THE MARCH 9, 2007 FEDERAL REGISTER NOTICE FOR FURTHER DETAILS.
Vehicle Speed Control
THE PETITIONER OWNS A MY 2006 TOYOTA CAMRY WITH A 4-CYLINDER ENGINE THAT WAS PURCHASED NEW IN JANUARY 2006. THE PETITIONER ALSO PREVIOUSLY OWNED A MY 2005 CAMRY. HE ALLEGES THAT BOTH VEHICLES EXHIBITED VEHICLE ENGINE SURGING, WHICH HE DESCRIBED AS A SHORT DURATION (1 TO 2 SECOND) INCREASE IN ENGINE SPEED OCCURRING WHILE THE ACCELERATOR PEDAL IS NOT DEPRESSED. IN AN INITIAL INTERVIEW, THE PETITIONER ESTIMATED THAT 6 TO 8 SURGE INCIDENTS, OF VARYING SEVERITY, OCCURRED IN THE MY 2006 VEHICLE OVER THE COURSE OF 10,000 MILES AND 7 MONTHS OF OWNERSHIP. THE PETITIONER REPORTS THAT THE BRAKE SYSTEM IS EFFECTIVE AT OVERCOMING THE SURGE. HOWEVER, HE IS CONCERNED ABOUT REPORTS FILED WITH NHTSA ALLEGING UNCONTROLLEDSURGING IN MY 2002 TO 2006 CAMRY VEHICLES BRINGING THOSE VEHICLES TO A HIGH RATE OF SPEED (IN SOME CASES, PURPORTEDLY, WITH THE BRAKES APPLIED).AFTER REVIEW AND ANALYSIS OF THE AVAILABLE INFORMATION, ODI HAS NOT IDENTIFIED A VEHICLE-BASED DEFECT THAT WOULD HAVE PRODUCED THE ALLEGED ENGINE SURGE IN THE PETITIONER?S VEHICLE, NOR WAS IT ABLE TO WITNESS SUCH AN EVENT WHEN ROAD TESTING THE PETITIONER?S VEHICLE.EVALUATION OF A SUSPECT THROTTLE ACTUATOR REMOVED FROM THE PETITIONER?S VEHICLE DID NOT REVEAL A COMPONENT PROBLEM. WARRANTY AND PARTS SALES OF THE ACTUATOR ARE UNREMARKABLE.THESE DATA DO NOT SUPPORT THE EXISTENCE OF A WIDE-SPREAD DEFECT OR ONGOING CONCERN. THE FAULT DETECTION AND REACTION STRATEGY DESCRIBED IN TOYOTA?S TECHNICAL DOCUMENTS INDICATES THAT A LOSS OF THROTTLE CONTROL DUE TO A COMPONENT OR SYSTEM FAILURE WOULD BE DETECTED WITHIN A ONE SECOND PERIODAFTER WHICH ENGINE POWER WOULD BE LIMITED. THE PETITIONER?S MY 2006 VEHICLE BRAKE SYSTEM OVERCOMES FULL ENGINE POWER AT EASILY ACHIEVABLE BRAKE PEDAL FORCES. BASED ON THE ANALYSIS CONDUCTED, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION AND REMEDY OF A SAFETY RELATED DEFECT AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.CONSEQUENTLY, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA?S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY?S SAFETY MISSION, THE PETITION IS DENIED.PLEASE SEE THE MARCH 9, 2007 FEDERAL REGISTER NOTICE FOR FURTHER DETAILS.
DP05002 · Vehicle Speed Control
Opened Aug 5, 2005 · Closed Jan 5, 2006
Status: closed (inferred from source dates) · Vehicle Speed Control
IN A LETTER DATED JULY 8, 2005, AND AFTER EXPERIENCING TWO INCIDENTS (AND ONE CRASH) WHERE HE ALLEGES HIS MODEL YEAR (MY) 2002 CAMRY ACCELERATED WITHOUT DRIVER INPUT, MR. JORDAN ZIPRIN PETITIONED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION?S (NHTSA) OFFICE OF DEFECTS INVESTIGATION (ODI) TO COMMENCE A PROCEEDING TO DETERMINE THE EXISTENCE OF A DEFECT WITHIN THE ETC SYSTEM IN MY 2002 TO 2005 TOYOTA AND LEXUS VEHICLES, OR TO REOPEN A PRIOR INVESTIGATION PRELIMINARY EVALUATION (PE) 04-021.IN A LETTER DATED AUGUST 18, 2005, MR. ZIPRIN AMENDED HIS PETITION TO INCLUDE ALLEGATIONS OF INTERRELATED BRAKE AND ACCELERATION PROBLEMS THAT ALLEGEDLY RESULT IN INAPPROPRIATE AND UNCONTROLLABLE VEHICLE ACCELERATIONS.THE 1172 VEHICLE OWNER QUESTIONNAIRE REPORTS CITED BY THE PETITIONER INVOLVE 4 LEXUS AND 15 TOYOTA MODELS DEFINING A POPULATION OF 7 MILLION VEHICLES.THE REPORTS TYPICALLY ALLEGED A DEFECT IN THE BRAKE SYSTEM, THE THROTTLE CONTROL SYSTEM, OR A COMBINATION OF BOTH SYSTEMS.IN ITS REVIEW OF THE REPORTS, ODI A) FAILED TO FIND EVIDENCE TO SUPPORT THE EXISTENCE OF A BRAKE RELATED DEFECT IN THE CITED MODELS, AND B) DETERMINED THAT MANY CITED PRODUCTS WERE NOT EQUIPPED WITH ETC.ACCORDINGLY, ODI RESTRICTED ITS ANALYSIS TO THE 432 PETITIONER REPORTS INVOLVING MY 2002 TO 2005 CAMRY, SOLARA, AND ES MODELS (ALL EQUIPPED WITH ETC) THAT ALLEGED AN ABNORMAL THROTTLE CONTROL EVENT (SEE THE JANUARY 3, 2006 FEDERAL REGISTER NOTICE FOR FURTHER DETAILS).ABOUT 40% OF THE 432 REPORTS INVOLVE A DRIVEABILITY CONCERN WHERE THE OPERATOR INTENTIONALLY APPLIES THE THROTTLE PEDAL, IN EXPECTATION THAT THE VEHICLE WILL ACCELERATE, AND THEN EXPERIENCES A DELAY OR HESITATION IN VEHICLE RESPONSE.THESE REPORTS INVOLVE VEHICLE RESPONSE TO INTENTIONAL DRIVER COMMANDS WHICH ODI CONSIDERS UNRELATED TO THE ALLEGATIONS RAISED BY THE PETITIONER.THEREFORE, THE REPORTS DO NOT PROVIDE SUPPORT FOR THE INVESTIGATION REQUESTED.ABOUT 20% OF THE REPORTS INVOLVE INCIDENTS WHERE OPERATORS ALLEGE VEHICLE ACCELERATION WITHOUT DRIVER INPUT AND AN INABILITY OF THE BRAKE SYSTEM TO CONTROL THE VEHICLE WHEN APPLIED.NEITHER THE REPORTS, NOR THE INTERVIEWS CONDUCTED BY ODI, IDENTIFIED ANY VEHICLE-BASED CAUSE TO EXPLAIN THE INCIDENTS OR DISCLOSED EVIDENCE TO SUPPORT THAT A FAILURE OF THE BRAKE OR THROTTLE CONTROL SYSTEM HAD OCCURRED.BECAUSE THESE REPORTS DO NOT INDICATE A DISTINCT SAFETY DEFECT FOR INVESTIGATION, THE REPORTS DO NOT PROVIDE SUPPORT FOR THE INVESTIGATION REQUESTED BY THE PETITIONERTHE REMAINING REPORTS (~ 40%, SIMILAR TO THE PETITIONER?S AND THOSE OF PE04-021) TYPICALLY DESCRIBE INCIDENTS WHERE A VEHICLE IS BEING MANEUVERED AT SLOW SPEED IN A CLOSE QUARTER SITUATION AT WHICH POINT THE OPERATOR ALLEGES THAT THE VEHICLE ACCELERATES WITHOUT DRIVER INPUT AND CRASHES.IN THE AFTERMATH, OPERATORS ARE UNSURE OF WHETHER THE BRAKES WERE APPLIED OR NOT, SOMETIMES STATING THERE WAS INSUFFICIENT TIME TO USE THE BRAKE; A CRASH OCCURRED AND THE OPERATOR BELIEVES AN UNCOMMANDED ACCELERATION CAUSED IT.IN SPITE OF THE EFFORT EXPENDED DURING PE04-021 AND DURING THIS ANALYSIS, ODI HAS NOT IDENTIFIED ANY VEHICLE-BASED CAUSE TO EXPLAIN THE REPORTS, OR UNCOVERED ANY EVIDENCE TO INDICATE THAT A THROTTLE CONTROL SYSTEM FAILURE OCCURRED.THEREFORE, THE REPORTS HAVE AMBIGUOUS SIGNIFICANCE AND DO NOT CONSTITUTE A BASIS ON WHICH ANY FURTHER INVESTIGATIVE ACTION IS WARRANTED.BASED ON THE ANALYSIS CONDUCTED, IT IS UNLIKELY THAT THE NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION AND REMEDY OF A SAFETY RELATED DEFECT AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.CONSEQUENTLY, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA?S LIMITED RESOURCES T
PE04021 · Throttle Control System
Opened Mar 3, 2004 · Closed Jul 22, 2004
Status: closed (inferred from source dates) · Vehicle Speed Control
THE LEXUS MODELS WERE THE SUBJECT OF DEFECT PETITION (DP) 04-003.TWELVE ODI COMPLAINTS ARE DUPLICATIVE TO TOYOTA REPORTS, INCLUDING THE TWO MINOR CRASHES.THE V6 EQUIPPED SOLARA MODELS HAVE BEEN EXCLUDED BECAUSE THEY DO NOT CONTAIN THE SUBJECT THROTTLE CONTROL SYSTEM.TOYOTA INTRODUCED ELECTRONIC THROTTLE CONTROL (ETC) ON THE SUBJECT VEHICLES BEGINNING IN MODEL YEAR (MY) 2002.ODI OPENED THE INVESTIGATION TO DETERMINE IF THE SYSTEM COULD BE THE CAUSE OF COMPLAINTS ALLEGING THE ENGINE SPEED INCREASED, OR FAILED TO DECREASE, (FOR A SHORT DURATION) WHEN THE ACCELERATOR PEDAL WAS NOT DEPRESSED (THE ALLEGED DEFECT).DURING THE COURSE OF THE INVESTIGATION, ODI ANALYZED AGENCY DATA AND REVIEWED VEHICLE OWNER QUESTIONNAIRE (VOQ) REPORTS, CONDUCTED INTERVIEWS INVOLVING 113 VOQ AND 36 TOYOTA REPORTS, INSPECTED TWO COMPLAINANT VEHICLES, REVIEWED RELEVANT TOYOTA SERVICE AND NEW CAR FEATURE DOCUMENTATION, REVIEWED AND ANALYZED TOYOTA?S RESPONSES TO ODI?S INFORMATION REQUEST LETTER, CONDUCTED A LIMITED CONTROL PEDAL ASSESSMENT, AND ATTENDED A TOYOTA TECHNICAL PRESENTATION THAT INCLUDED THE ASSESSMENT OF TWO DEMONSTRATION VEHICLES.THROUGH INTERVIEWS, ODI IDENTIFIED 14 VOQ AND 6 TOYOTA REPORTS (20 UNIQUE VEHICLES) WHERE COMPLAINANTS REPORT MULTIPLE OCCURRENCES OF THE ALLEGED DEFECT.IN SOME CASES THE CONDITION WAS EXPERIENCED BY DIFFERENT VEHICLE OPERATORS OR WAS WITNESSED BY OTHER OCCUPANTS.ODI WAS UNABLE TO MAKE A DETERMINATION AS TO THE CAUSE OF 9 TOYOTA AND AN ADDITIONAL 37 VOQ REPORTS (WHICH DESCRIBE 28 UNIQUE INCIDENTS) DUE TO INSUFFICIENT INFORMATION.THE REMAINING COMPLAINANTS INTERVIEWED (62 VOQ, 21 TOYOTA) DESCRIBED CONDITIONS NOT CAUSED BY A FAILURE OF THE THROTTLE CONTROL SYSTEM AND WERE THUS CONSIDERED UNRELATED TO THE INVESTIGATION.NONE OF THE COMPLAINANTS INTERVIEWED REPORTED A COMPONENT FAILURE (OR OTHER INDICATOR OF A SYSTEM FAILURE) AS THE POTENTIAL CAUSE OF INCIDENTS RELEVANT TO THIS INVESTIGATION.IN MANY CASES, THE COMPLAINT VEHICLES WERE SUBSEQUENTLY INSPECTED BY DEALERSHIP OR MANUFACTURER REPRESENTATIVES WHO ALSO FAILED TO IDENTIFY A FAULT WITHIN THE VEHICLE.TOYOTA IDENTIFIED 43 RELATED WARRANTY CLAIMS, 24 OF WHICH WERE FOR DIAGNOSTIC PURPOSES ONLY (NO REPAIRS PERFORMED).ODI FOUND NOTHING ABNORMAL IN THE CONTROL PEDAL CONFIGURATION OF THE SUBJECT VEHICLES.A DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE THE ATTACHED SUMMARY FOR FURTHER DETAIL.
PE02079 · Engine Compartment Fire
Opened Oct 22, 2002 · Closed Mar 18, 2003
Status: closed (inferred from source dates) · Engine And Engine Cooling
ODI'S DATA ANALYSIS FOUND THE FIRES RATES TO BE CONSISTENTLY LOW AND EVENLY DISTRIBUTED AMONG SIX MODEL YEARS AND SIX DIFFERENT ENGINE CONFIGURATIONS.ODI EXAMINED A VARIETY OF ROOT CAUSES, THOSE BEING DETONATION (RESULTING IN OIL PAN PUNCTURE FROM CONNECTING ROD), STARTER FIRES, VARIOUS FUEL RELATED FIRES, LEAKING OIL FILTERS, WIRING ISSUES, IMPROPER REPAIRS AND BRAKE FLUID LEAKS.NONE OF THE ISSUES EXAMINED HAD REPORTS THAT INDICATED A TREND WHEN NORMALIZED FOR POPULATON AND EXPOSURE.SEE ATTACHED REPORT FOR FULL DETAILS.