2025 Toyota 4RUNNER

On August 29, 2026, I was stopped at a red light with my foot on the brake when I noticed the vehicle moving forward even though I was pressing the brake pedal. I immediately entered a nearby parking lot at very low speed. I had significant difficulty stopping and used the electronic parking brake to help keep the vehicle stopped. While still inside, I noticed a strong burning smell and smoke. After exiting, I saw smoke coming from the passenger side. I walked to that side and saw flames coming from the area near the passenger-side tire. I attempted to extinguish the fire with a small amount of water. I then opened the hood and observed fire in the same general passenger-side area, including near the tire and around the battery area. The heat/fire was severe enough to crack and damage the windshield. I called 911, and the fire department responded and extinguished the fire. The vehicle was not drivable and was towed to an authorized Toyota dealership, where it is currently available for inspection. The cause has not yet been determined. After the incident, the Toyota app displayed 9 active alerts, including Brake System Malfunction, ABS Malfunction, Low Brake Fluid, Parking Brake System Malfunction, Vehicle Stability Control System Malfunction, Secondary Collision Brake System Malfunction, Smart Stop System Malfunction, and Drive-Start Control System Malfunction. The vehicle had approximately 13,310 miles. There were no injuries or collision.

Brakes squeak/squeal very loudly and often, no matter if it’s cold, rainy, hot or humid. It was only squeaking/squealing when applying the brakes while backing up but now starting to squeak/squeal when applying the brakes while moving forward. Seems to be getting worse. Spoke to the dealer and they say there’s nothing they can do until Toyota comes up with a fix.

The brake system emits a high-pitched noise, which seems to be worn down to the discs when used in drive mode and reverse mode. At any moment, they could stop working or cause an accident. The problem was reported to the dealership on October 28, 2025, when the vehicle had only 3,171 miles. The vehicle is still under warranty. It has been inspected by the dealership. To date, it has not been repaired. The dealership reports that this problem has occurred in most of these vehicles. There were no warning lights or warning messages. The situation first occurred when the vehicle had approximately 3,100 miles and was reported to the dealership at 3,171 miles.

My 2025 Toyota 4Runners brakes have a very high pitched squeal. This is most noticeable when backing up but sometimes when applying the brakes going forward, especially in wet conditions. I feel the brakes may fail at some point causing an accident. Twice I’ve had other vehicles slam their brakes on or attempt evasive action thinking I was going to hit them because the noise was so loud they heard it inside their vehicle. This did happen in a parking lot and not on the road. It is my understanding Toyota had a service bulletin to fix the issue under T-SB-0046-25 which was issued in July 2025, however to date, Toyota has not repaired my vehicle. It is my understanding that some vehicles were repaired under the bulletin but the fix did not correct the problem. I was told by my local Toyota dealer this week that Toyota told them to stop all repairs because the TSB was not correcting the issue and they were waiting for Toyota engineers to find a new solution. Request your assistance in getting Toyota to repair all the vehicles affected by this problem before a serious accident occurs because of brake failure or another driver taking evasive action when they hear this noise.

This vehicle’s brakes loudly squeal when in reverse and when just stopping at a stop sign. After a few weeks of purchase I brought it to the Toyota service team in St. Peter’s to fix since it’s under warranty. They said they do not have a fix for the issue! Driving this vehicle scares me and I don’t feel safe. Please help. This is a major safety hazard. Supposedly, these vehicle was brought in and “fixed” for the same brake issue. It clearly has not been fixed. I have video evidence but your platform won’t allow me to upload a video.