TL* THE CONTACT OWNS A 1998 TOYOTA 4RUNNER. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC TO HAVE THE RADIATOR REPLACED HOWEVER, WHILE THE VEHICLE WAS BEING HOISTED ON THE LIFT, THE SUB FRAME FRACTURED. THE CONTACT STATED THAT THERE WAS SEVERE FRAME RUST TO THE SUB FRAME. THE CONTACT WAS INFORMED THAT …
Read full complaint
TL* THE CONTACT OWNS A 1998 TOYOTA 4RUNNER. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC TO HAVE THE RADIATOR REPLACED HOWEVER, WHILE THE VEHICLE WAS BEING HOISTED ON THE LIFT, THE SUB FRAME FRACTURED. THE CONTACT STATED THAT THERE WAS SEVERE FRAME RUST TO THE SUB FRAME. THE CONTACT WAS INFORMED THAT THE SUB FRAME WAS COMPROMISED AND THE VEHICLE WAS UNSAFE TO REPAIR WHILE ON A LIFT. THE RADIATOR WAS REPAIRED, HOWEVER THE FRAME RUST FAILURE WAS NOT REPAIRED. THE CONTACT ALSO STATED THAT THE PASSENGER'S SIDE REAR TORSION BAR ALSO FRACTURED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 183,000.
NHTSA ODI #10862784
Mileage unknown · Apr 28, 2016
Structure
THE VEHICLE IN QUESTION HAS SERIOUS SIGNS OF FRAME DECAY THAT SHOULD NOT BE PRESENT ON A VEHICLE OF THIS AGE AND USE. THERE ARE THREE AREAS OF FRAME PERFORATION THAT SUGGEST A DEFECT IN THE MATERIAL AND/OR DESIGN OF THE FRAME. THIS ISSUE SEEMS TO BE PREVALENT ON 1998 MODELS OF THIS SAME VEHICLE AS I HAVE FOUND NUMEROUS COMPLAI…
Read full complaint
THE VEHICLE IN QUESTION HAS SERIOUS SIGNS OF FRAME DECAY THAT SHOULD NOT BE PRESENT ON A VEHICLE OF THIS AGE AND USE. THERE ARE THREE AREAS OF FRAME PERFORATION THAT SUGGEST A DEFECT IN THE MATERIAL AND/OR DESIGN OF THE FRAME. THIS ISSUE SEEMS TO BE PREVALENT ON 1998 MODELS OF THIS SAME VEHICLE AS I HAVE FOUND NUMEROUS COMPLAINTS OF THE SAME NATURE WITHIN THE NHTSA SITE AS WELL AS OTHER SITES AROUND THE INTERNET. I HAVE CONTACTED TOYOTA CORPORATE AND WAS MET WITH AN UNWILLINGNESS TO PROPERLY ADDRESS THIS ISSUE. I WILL FOLLOW UP WITH PHOTOS OF THE FRAME PERFORATION TO SHOW THE EXTENT OF THE DETERIORATION.
NHTSA ODI #10861966
Mileage unknown · Feb 8, 2016
Structure
LIKE THE OVERWHELMING MAJORITY OF TOYOTA COMPLAINTS, FRAME RUST. TOOK THE 1998 4RUNNER FOR NEW TIRES AND ALIGNMENT. ALIGNMENT COULD NOT BE DONE BECAUSE OF MASSIVE EROSION DUE TO RUST ON THE FRAME CONNECTING REAR CONTROL ARMS. 4RUNNER ESSENTIALLY UNDRIVEABLE AT THIS AT THIS POINT. CONTACTED TOYOTA HQ AND, AS EVERYONE ELSE ON …
Read full complaint
LIKE THE OVERWHELMING MAJORITY OF TOYOTA COMPLAINTS, FRAME RUST. TOOK THE 1998 4RUNNER FOR NEW TIRES AND ALIGNMENT. ALIGNMENT COULD NOT BE DONE BECAUSE OF MASSIVE EROSION DUE TO RUST ON THE FRAME CONNECTING REAR CONTROL ARMS. 4RUNNER ESSENTIALLY UNDRIVEABLE AT THIS AT THIS POINT. CONTACTED TOYOTA HQ AND, AS EVERYONE ELSE ON THE NHTSA COMPLAINTS SITE SAYS, THEY WOULD DO NOTHING ALTHOUGH THEY DID TAKE CARE OF THE TACOMA PROBLEM.
NHTSA ODI #10824832
211,750 miles · Jan 21, 2016
Structure
RUSTED FRAME ON DRIVERS SIDE REAR, HOLES IN FRAME, WHICH HOLDS THE SWAY BAR. MECHANIC NOTICED DURING OIL CHANGE. TOOK TO DEALER AND WAS TOLD NOTHING THEY COULD DO. VERY DANGEROUS CONDITION.
NHTSA ODI #10821443
198,000 miles · Jan 14, 2016
Structure
TL* THE CONTACT OWNS A 1998 TOYOTA 4RUNNER. THE CONTACT STATED THAT WHILE CHANGING THE OIL AND FUEL FILTER, IT WAS DISCOVERED THAT THE VEHICLE HAD SEVERE CORROSION TO THE FRAME. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 198,000.
NHTSA ODI #10820290
157,000 miles · Jan 9, 2016
Structure
FRAME IS ROTTING OUT BY CONTROL BRACKETS. I'VE BEEN TOLD BY A MECHANIC THAT IT WILL NOT MAKE IT THROUGH THE WINTER. ITS NOT SAFE AND WILL CRUMPLE ON IMPACT.
NHTSA ODI #10819149
180,000 miles · Dec 5, 2015
Structure
REAR FRAME RUSTED OUT WHERE SWAY BARS ATTACH, FRAME MOUNTS BROKE WHILE TOWING A TRAILER ON SR 22 IN SOUTHERN OHIO. LOST CONTROL OF VEHICLE CROSSED TWO LANES OF TRAFFIC BEFORE GAINING CONTROL AND STOPPING THE 4RUNNER.
NHTSA ODI #10808589
Mileage unknown · Sep 23, 2015
Structure
1998 TOYOTA 4-RUNNER. CONSUMER WRITES IN REGARDS TO VEHICLE FRAME RUST ISSUES. *SMD
NHTSA ODI #10682303
165,000 miles · Jul 13, 2015
StructureSuspension
FRAME RUSTED THROUGH PREMATURELY ON MY TRUCK. TRUCK IS UNSAFE TO DRIVE AND A HUGE DISAPPOINTMENT.
NHTSA ODI #10733798
34,000 miles · Jul 2, 2015
Structure
TL* THE CONTACT OWNS A 1998 TOYOTA 4RUNNER. THE CONTACT STATED THAT THE TRAILING ARM REAR AXLE OF THE FRAME WAS RUSTED COMPLETELY AND CAUSED THE VEHICLE TO SHAKE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE FRAME NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAI…
Read full complaint
TL* THE CONTACT OWNS A 1998 TOYOTA 4RUNNER. THE CONTACT STATED THAT THE TRAILING ARM REAR AXLE OF THE FRAME WAS RUSTED COMPLETELY AND CAUSED THE VEHICLE TO SHAKE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE FRAME NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 34,000. MA 10/19/15 UPDATED 11/06/2017*CN
ON CERTAIN 2-WHEEL-DRIVE (2WD) AND 4-WHEEL-DRIVE (4WD) 4RUNNER SPORT UTILITY VEHICLES, A COMBINATION OF HEAVY LOADING (SIMULTANEOUS LOADING TO REAR GROSS AXLE WEIGHT RATING AND GROSS VEHICLE WEIGHT RATING) AND SEVERE STEERING MANEUVERS COULD CAUSE THE 2WD 4RUNNER TO LOSE DIRECTIONAL STABILITY.
Consequence & remedy
Consequence: THIS MAY RESULT IN A LOSS OF CONTROL AND COULD INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE REAR SUSPENSION PARTS. ALTHOUGH THE 4WD 4RUNNERS DO NOT EXHIBIT THE HANDLING CONDITION, TOYOTA WILL RECALL THESE VEHICLES TO AVOID ANY PUBLIC CONFUSION AS TO WHICH VEHICLES SHOULD RECEIVE THE REPLACEMENT PARTS. OWNER NOTIFICATION BEGAN FEBRUARY 28, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT TOYOTA AT 1-800-331-4331.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
1998 Toyota 4RUNNER Problems, Complaints & Recalls | Skip That Year
Illustration