1990 Toyota 4RUNNER

I PURCHASED MY 4RUNNER USED IN 1998. THE MILEAGE AT PURCHASE WAS ONLY 30K, AS IT HAD BEEN USED PRIMARILY FOR DRIVING IN INCLEMENT WEATHER. THE ORIGINAL OWNER INFORMED ME THAT A NOTICE HAD BEEN SENT BY TOYOTA REGARDING HEAD GASKET FAILURES (TSB #97121797017), AND THAT TOYOTA WOULD HONOR THE REPAIRS (IF NECESSARY) UP TO 100K MILES, REGARDLESS OF TIME SINCE ORIGINAL USE. THE TSB, HOWEVER, STATES THAT THE EXTENDED WARRANTY LASTS UNTIL 8 YEARS FROM ORIGINAL USE OR 100K MILES, WHICHEVER OCCURS FIRST. SINCE OCTOBER 2000, I HAVE EXPERIENCED INTERMITTENT LOW ENGINE IDLING (AND STALLING) AFTER DRIVING AT HIGH SPEEDS. ON AT LEAST FIVE DIFFERENT OCCASIONS, I HAVE ASKED THAT THE VEHICLE'S IDLE SPEED BE ADJUSTED AND THE THROTTLE PLATE BE CLEANED TO RESOLVE THIS PROBLEM. I DID NOT REALIZE UNTIL JUST RECENTLY THAT THE SOURCE OF THIS PROBLEM IS A LEAKY HEAD GASKET. THE TOYOTA DEALERSHIP I GO TO HERE IN GLENDALE, CA REPORTED THIS DIAGNOSIS AFTER I QUESTIONED THEM ON WHY THE VEHICLE NEEDED REPEATED IDLE SPEED ADJUSTMENTS. THE CURRENT MILEAGE OF THE VEHICLE IS 99K. I HAVE APPROACHED TOYOTA CUSTOMER SERVICE TO INQUIRE IF THEY WILL AUTHORIZE A HEAD GASKET REPLACEMENT FOR THE VEHICLE FREE OF CHARGE SINCE THE PROBLEM IS A PROBLEM THAT THEY HAVE BEEN AWARE OF AND PREVIOUSLY ISSUED AN EXTENDED WARRANTY COVERING IT. I HAVE BEEN TOLD THIS IS NOT POSSIBLE BECAUSE OF THE AGE OF THE VEHICLE. I FEEL THAT TOYOTA SHOULD AUTHORIZE THE REPAIR IN THIS CASE DESPITE THE AGE OF THE VEHICLE, AS THE ENGINE BEGAN EXHIBITING SYMPTOMS OF THE HEAD GASKET PROBLEM WELL BELOW THE 100K MILEAGE REQUIREMENT THAT TOYOTA ORIGINALLY STATED THAT THEY WERE WILLING TO REPAIR IN THE TSB. I DO NOT KNOW WHAT FURTHER I CAN DO REGARDING THIS MATTER, AND WOULD APPRECIATE ANY HELP THAT CAN BE PROVIDED.

I PURCHASED MY 4RUNNER USED IN 1998. THE MILEAGE AT PURCHASE WAS ONLY 30K, AS IT HAD BEEN USED PRIMARILY FOR DRIVING IN INCLEMENT WEATHER. THE ORIGINAL OWNER INFORMED ME THAT A NOTICE HAD BEEN SENT BY TOYOTA REGARDING HEAD GASKET FAILURES (TSB #97121797017), AND THAT TOYOTA WOULD HONOR THE REPAIRS (IF NECESSARY) UP TO 100K MILES, REGARDLESS OF TIME SINCE ORIGINAL USE. THE TSB, HOWEVER, STATES THAT THE EXTENDED WARRANTY LASTS UNTIL 8 YEARS FROM ORIGINAL USE OR 100K MILES, WHICHEVER OCCURS FIRST. SINCE OCTOBER 2000, I HAVE EXPERIENCED INTERMITTENT LOW ENGINE IDLING (AND STALLING) AFTER DRIVING AT HIGH SPEEDS. ON AT LEAST FIVE DIFFERENT OCCASIONS, I HAVE ASKED THAT THE VEHICLE'S IDLE SPEED BE ADJUSTED AND THE THROTTLE PLATE BE CLEANED TO RESOLVE THIS PROBLEM. I DID NOT REALIZE UNTIL JUST RECENTLY THAT THE SOURCE OF THIS PROBLEM IS A LEAKY HEAD GASKET. THE TOYOTA DEALERSHIP I GO TO HERE IN GLENDALE, CA REPORTED THIS DIAGNOSIS AFTER I QUESTIONED THEM ON WHY THE VEHICLE NEEDED REPEATED IDLE SPEED ADJUSTMENTS. THE CURRENT MILEAGE OF THE VEHICLE IS 99K. I HAVE APPROACHED TOYOTA CUSTOMER SERVICE TO INQUIRE IF THEY WILL AUTHORIZE A HEAD GASKET REPLACEMENT FOR THE VEHICLE FREE OF CHARGE SINCE THE PROBLEM IS A PROBLEM THAT THEY HAVE BEEN AWARE OF AND PREVIOUSLY ISSUED AN EXTENDED WARRANTY COVERING IT. I HAVE BEEN TOLD THIS IS NOT POSSIBLE BECAUSE OF THE AGE OF THE VEHICLE. I FEEL THAT TOYOTA SHOULD AUTHORIZE THE REPAIR IN THIS CASE DESPITE THE AGE OF THE VEHICLE, AS THE ENGINE BEGAN EXHIBITING SYMPTOMS OF THE HEAD GASKET PROBLEM WELL BELOW THE 100K MILEAGE REQUIREMENT THAT TOYOTA ORIGINALLY STATED THAT THEY WERE WILLING TO REPAIR IN THE TSB. I DO NOT KNOW WHAT FURTHER I CAN DO REGARDING THIS MATTER, AND WOULD APPRECIATE ANY HELP THAT CAN BE PROVIDED.

I WAS LOCKED INSIDE THIS VEHICLE AND UNABLE TO GET OUT. I ENDED UP SMASHING THE WINDOW AFTER 45 MINUTES AND CRAWLING OUT OF THE VEHICLE. THE DOOR LOCKS WERE "ENERGIZED" AND HOLDING THE LOCK LEVERS DOWN. MECHANIC IS UNABLE TO UNDERSTAND WHAT HAPPENED AND THE LOCK SOLENOIDS ARE STILL IN THIS SAME SITUATION. THE LOCK ARMS HAVE BEEN DISCONNECTED.

1990 TOYOTA 4-RUNNER INTERMITTANTLY JUMPS IN AND OUT OF OVERDRIVE AT APPROXIMATELY 55 MILES PER HOUR OR HIGHER WHEN HIGHWAY DRIVING, CAUSING INCREASE IN GAS MILEAGE AND HIGH RPMS ON THE ENGINE. IN 2001 I WENT TO TOYOTA FOR THIS PROBLEM AND THEY TOLD ME I WOULD NEED TO REPLACE THE TRANSMISSION SO I SHOULD DRIVE THE VEHICLE UNTIL I COULD NOT DRIVE IT ANYMORE. AT THAT POINT I SHOULD HAVE THE TRANSMISSION REPLACED. AFTER EXTENSIVE RESEARCH I LOCATED TSBS FOR THIS VEHICLE AND FOUND ONE THAT ADDRESSES THIS ISSUE (TSB ATRATB351 DATED JAN 96). THIS MONTH 1/2003 I RETURNED TO TOYOTA WITH THE SAME COMPLAINT AND THEY TOLD ME IT WOULD COST APPROXIMATELY $150.00 TO PERFORM THIS TSB. I TOLD THEM IF THEY HAD PERFORMED IT THE PREVIOUS YEAR WHEN I HAD THE HEAD GASKETS REPLACED IT WOULD NOT HAVE COST ME ANYTHING SINCE THE ENGINE WAS ALREADY APART FOR OTHER WORK. THE SERVICE MANAGER SAID HE COULD NOT ADDRESS THE RECOMMENDATION AND FINDINGS OF THEIR WORK FROM A YEAR AGO. I CALLED ANOTHER DEALER AND THEY SAID IT WOULD COST $71.00 FOR THE WORK TO BE PERFORMED. AS FAR AS I AM CONCERNED SINCE A TSB HAS BEEN ISSUED IT IS BASICALLY ADMITTING THAT THE VEHICLE HAS A PROBLEM AND PROVIDES THE DEALER/SERVICE DEPARTMENTS WITH THE FIX, SO WHY ARE THE SERVICE MANAGERS RELUCTANT TO PERFORM THE CORRECTION, BUT INSTEAD RECOMMEND AN TRANSMISSION CHANGE?