DT: CONSUMER STATES THAT WHILE MAKING A LEFT TURN STEERING LOCKED UP. HE THEN DISCONNECTED THE STEERING DEVICE, WHICH WAS LOCATED UNDER THE MOTOR HOME. THIS CAUSED THE STEERING TO FREE UP, AND HE TOOK THE VEHICLE TO THE DEALER, AND THE CONSUMER WAS TOLD THE DEVICE HAD BEEN TAKEN BACK TO BLUE OX . THERE WAS A MACHINING PROBLE…
Read full complaint
DT: CONSUMER STATES THAT WHILE MAKING A LEFT TURN STEERING LOCKED UP. HE THEN DISCONNECTED THE STEERING DEVICE, WHICH WAS LOCATED UNDER THE MOTOR HOME. THIS CAUSED THE STEERING TO FREE UP, AND HE TOOK THE VEHICLE TO THE DEALER, AND THE CONSUMER WAS TOLD THE DEVICE HAD BEEN TAKEN BACK TO BLUE OX . THERE WAS A MACHINING PROBLEM ON A PISTON OR A CYLINDER WHICH CAUSED IT TO SEIZE UP.*AK
NAVISTAR IS RECALLING CERTAIN MODEL YEAR MY 2001-2008 WORKHORSE W20, W21 AND W22 CHASSIS AND CERTAIN MODEL YEAR 2009 THROUGH 2011 MONACO RV ADMIRAL, ARISTA, MONARCH, AND RIPTIDE RECREATIONAL VEHICLES EQUIPPED WITH AXLES THAT INCLUDE BOSCH ZOPS OR ZOHT PIN SLIDE HYDRAULIC DISC BRAKES. WHEN COMBINED WITH OCCASIONAL OR SEASONAL VEHICLE OPERATION MAY EXPERIENCE CALIPERS STICKING IN THE APPLIED POSITION. THIS CAN RESULT IN ABNORMAL HEAT GENERATION AT THE WHEEL END CAUSING BRAKE DRAG. THE DRIVER WOULD NORMALLY HAVE WARNING OF THE BRAKE DRAG IF UNDETECTED BY THE DRIVER.
Consequence & remedy
Consequence: THE TEMPERATURE INCREASE AT THE WHEEL END CAN EVENTUALLY LEAD TO SOFT PEDAL CONDITIONS DUE TO BRAKE FLUID BOIL, AND POSSIBLE EXTENDED STOPPING DISTANCE INCREASING THE RISK OF A CRASH.
Remedy: WORKHORSE DEALERS WILL REPLACE ALL FOUR BOSCH BRAKE CALIPER ASSEMBLIES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 16, 2010. OWNERS MAY CONTACT WORKHORSE AT 1-877-246-7731.
TIFFIN IS RECALLING 3,507 MY 2004-2007 ALLEGRO, ALLEGRO BAY AND ALLERO BUS, MY 2004-2005 PHAETON AND MY 2005-2007 ZEPHYR MOTOR HOMES EQUIPPED WITH A TWO-DOOR REFRIGERATOR MANUFACTURED BY THE DOMETIC CORPORATION. THE REFRIGERATOR MAY HAVE A DEFECT IN THE BOILER TUBE. PRESSURIZED COOLANT SOLUTION COULD BE RELEASED INTO AN AREA WHERE AN IGNITION SOURCE (GAS FLAME) IS PRESENT.
Consequence & remedy
Consequence: RELEASE OF COOLANT UNDER CERTAIN CONDITIONS COULD IGNITE AND RESULT IN A FIRE.
Remedy: TIFFIN WILL BE WORKING WITH DOMETIC IN ORDER TO REPAIR THESE REFRIGERATORS (PLEASE SEE 08E032). DOMETIC WILL REPAIR THESE REFRIGERATORS BY INSTALLING A SECONDARY BURN HOUSING, A THERMAL FUSE, AND A MELT FUSE FREE OF CHARGE. DOMETIC HAS RETAINED STERICYCLE INC. TO MANAGE THIS CAMPAIGN. STERICYCLE WILL ASSIST THE OWNER IN LOCATING DEALERSHIPS OR SERVICE CENTERS AND WILL PROVIDE ASSISTANCE WITH SCHEDULING OF APPOINTMENTS. OWNERS MAY CONTACT DOMETIC/STERICYCLE AT 1-888-446-5157 OR TIFFIN AT 256-356-8661.
CERTAIN MOTOR HOMES BUILT ON WORKHORSE CHASSIS AND EQUIPPED WITH ACTIA CORPORATE INSTRUMENT CLUSTERS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 101, CONTROLS AND DISPLAYS, AND NO. 105, HYDRAULIC AND ELECTRIC BRAKE SYSTEMS. IF THE BRAKE FAIL INPUT FALLS BELOW A VOLTAGE OF 1.5V, THE BRAKE FAILURE LAMP AND ALARM WILL BE ACTIVATED. ALSO ACTIVATION OF THE ABS TELLTALE WHEN THE ABS IS NOT PROPERLY FUNCTIONING DOES NOT ALWAYS OCCUR.
Consequence & remedy
Consequence: AT NIGHT THE INSTRUMENT CLUSTER LIGHTS MAY FAIL AND THE DRIVER MAY NOT BE ABLE TO SEE THE INSTRUMENT PANEL GAUGES AND THE BRAKE WARNING LIGHT INDICATOR WHICH COULD INCREASING THE RISK OF A CRASH.
Remedy: TIFFIN IS WORKING WITH WORKHORSE TO CONTACT THE OWNERS AND REMEDY THIS CAMPAIGN . WORKHORSE WILL REPROGRAM THE INSTRUMENT PANEL CLUSTER FREE OF CHARGE. OWNERS MAY CONTACT WORKHORSE AT 1-877-246-7731 OR TIFFIN AT 1-256-356-0205.
ON CERTAIN MOTOR HOMES CONTAINING A 50 AMP TRANSFER SWITCH BUILT BY INTELLITEC, THE MATERIAL USED FOR THE WIRE LUGS WAS CHANGED FROM NICKEL PLATED TO COPPER LUGS. THE COPPER LUGS ARE SOFTER THAN THE NICKEL PLATED AND DO NOT RETAIN THE TORQUE OF THE SCREW THAT CLAMPS THE WIRE CONNECTOR.
Consequence & remedy
Consequence: WHEN THE TORQUE IS RELAXED, THE LUGS CAN BECOME LOOSE RESULTING IN EXCESSIVE HEAT WITHIN THE CONNECTED WIRE THAT COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE CHANGEOVER BOX. THE RECALL BEGAN ON JULY 21, 2005. OWNERS MAY CONTACT TIFFIN AT 1-256-356-8661.
ON CERTAIN RECREATIONAL VEHICLES, THE WASHER/DRYER IN THE REAR OF THE MOTOR HOME CAN MOVE.
Consequence & remedy
Consequence: A VEHICLE OCCUPANT COULD BE INJURED IF THE WASHER/DRYER MOVED.
Remedy: TIFFIN HAS PROVIDED THE OWNERS WITH A REPAIR KIT AND INSTALLATION INSTRUCTIONS. THE RECALL BEGAN ON JANUARY 7, 2005. OWNERS MAY CONTACT TIFFIN AT 1-256-356-0205.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
PE05014 · Potential Movement Of Washer/dryer
Opened Mar 17, 2005 · Closed Apr 19, 2005
Status: closed (inferred from source dates) · Equipment:mechanical
IN JANUARY 2005, TIFFIN ISSUED A SERVICE BULLETIN (UNNUMBERED) ENTITLED ?SERVICE BULLETIN FOR POTENTIAL MOVEMENT OF WASHER/DRYER.?THE BULLETIN ADDRESSED THE POSSIBILITY THAT THE WASHER AND DRYER COULD MOVE UNEXPECTEDLY WHILE THE MOTORHOME IS BEING DRIVEN.DURING DISCUSSIONS WITH TIFFIN, ODI LEARNED THAT TWO INCIDENTS HAD BEEN REPORTED WHERE THE WASHER AND DRYER FELL OR TIPPED OVER INTO THE LIVING SPACE.ON APRIL 7TH, 2005, TIFFIN NOTIFIED ODI THAT AFTER FURTHER REVIEW, THEY HAD DECIDED THAT THIS ISSUE SHOULD BE RESOLVED BY CONDUCTING A SAFETY RECALL CAMPAIGN AND SUBSEQUENTLY FILED SAFETY RECALL 05V-145 (COPY ATTACHED). TIFFAN WILL BE INSTALLING A KIT THAT PREVENTS THE MOVEMENT OF THE WASHER AND DRYER ASSEMBLY. THIS ACTION RESOLVES THE ISSUES RAISED BY THIS INVESTIGATION. THIS INVESTIGATION IS CLOSED.
2005 Tiffin Allegro Bay Problems, Complaints & Recalls | Skip That Year
Illustration