Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 6 of 6 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Visibility/wiper. Review the 3 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Latches/locks/linkages. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Seat Belts. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports0 fire reports0 injury reports
What owners actually said
6 reports
16,000 miles · Jun 1, 2018
Latches/locks/linkages
EXIT DOOR LOCK BROKE, PREVENTING US FROM EXITING THE MOTORHOME. TRIMARK BRAND LOCK SET IS BOTH A DEAD BOLT AND SPRING LATCH. SPRING LATCH BROKE INTO TWO PIECES AND REMAINED IN THE LOCKED POSITION. TRIMARK HAS MADE A REPLACEMENT LOCK SET TO REPLACE THIS DEFECTIVE SET. SO TRIMARK IS AWARE OF THIS ISSUE. THOR ONLINE FORUM AND O…
Read full complaint
EXIT DOOR LOCK BROKE, PREVENTING US FROM EXITING THE MOTORHOME. TRIMARK BRAND LOCK SET IS BOTH A DEAD BOLT AND SPRING LATCH. SPRING LATCH BROKE INTO TWO PIECES AND REMAINED IN THE LOCKED POSITION. TRIMARK HAS MADE A REPLACEMENT LOCK SET TO REPLACE THIS DEFECTIVE SET. SO TRIMARK IS AWARE OF THIS ISSUE. THOR ONLINE FORUM AND OTHER RV FORUMS REPORT THIS DEFECT AND OTHERS NECESSITATING VEHICLE EXIT VIA A WINDOW. IN AN EMERGENT NEED TO EXIT THE VEHICLE, THIS DEFECT COULD PROVE DISASTROUS. WE WERE PARKED WHEN THIS HAPPENED TO US. THERE WAS NO PRIOR WARNING THAT THE LOCK SET WAS FAILING. *TT
NHTSA ODI #11099251
5,000 miles · Jan 22, 2018
Visibility/wiper
TL* THE CONTACT OWNS A 2016 FORD F-53 MOTORHOME. THE CONTACT STATED THAT THE VEHICLE HAD A RECALL FOR THE WINDSHIELD WIPERS. THE VEHICLE WAS TAKEN TO THE MOTOR COACH HEADQUARTERS (701 COUNTY RD 15, ELKHART, IN 46516) WHERE THE VEHICLE WAS REPAIRED; HOWEVER, THE WINDSHIELD WIPERS STILL FAILED TO FUNCTION PROPERLY. THE CONTACT CAL…
Read full complaint
TL* THE CONTACT OWNS A 2016 FORD F-53 MOTORHOME. THE CONTACT STATED THAT THE VEHICLE HAD A RECALL FOR THE WINDSHIELD WIPERS. THE VEHICLE WAS TAKEN TO THE MOTOR COACH HEADQUARTERS (701 COUNTY RD 15, ELKHART, IN 46516) WHERE THE VEHICLE WAS REPAIRED; HOWEVER, THE WINDSHIELD WIPERS STILL FAILED TO FUNCTION PROPERLY. THE CONTACT CALLED THE MANUFACTURER WHO STATED THAT THE WINDSHIELD WIPERS WERE REPAIRED. THE VEHICLE WAS NOT REPAIRED AGAIN. NOW DURING A RAINSTORM, THE PASSENGER SIDE WIPER GOES BELOW THE LOWER WINDOW AND EVENTUALLY BINDS WITH THE DRIVERS SIDE. I THEN HAVE TO GET OUT, REALIGN THE WIPER ARMS AND RETIGHTEN THE NUTS. I ALSO HAVE PROBLEMS WHEN USING THE INTERMITTENT WIPER FUNCTION. THE DEALER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 5,000. I HAVE ALSO HAD THE BUNK WINDOW REPLACE 2X. IN BOTH CASES THEY FELL OUT WHILE IN ROUTE. I HAVE REQUESTED AND NOT RECEIVED ANY REPAIR ORDERS FOR THE WORK DONE BY GENERAL RV, OR THOR
NHTSA ODI #11064177
2,500 miles · Jul 13, 2017
Visibility/wiper
TL* THE CONTACT OWNS A 2016 THOR OUTLAW. THE CONTACT STATED THAT THE REAR RV EGRESS WINDOW DEATCHED FROM THE RV WHILE BEING OPERATED AT 60 MPH. THIS IS LOCATED IN THE BUNK AREA ABOVE THE FRONT PASSENGER SIDE.THE VEHICLE WAS TAKEN TO GENERAL RV WHERE IT WAS DIAGNOSED THAT THE WINDOW DETACHED AND NEEDED TO BE REPLACED. THE WINDOW …
Read full complaint
TL* THE CONTACT OWNS A 2016 THOR OUTLAW. THE CONTACT STATED THAT THE REAR RV EGRESS WINDOW DEATCHED FROM THE RV WHILE BEING OPERATED AT 60 MPH. THIS IS LOCATED IN THE BUNK AREA ABOVE THE FRONT PASSENGER SIDE.THE VEHICLE WAS TAKEN TO GENERAL RV WHERE IT WAS DIAGNOSED THAT THE WINDOW DETACHED AND NEEDED TO BE REPLACED. THE WINDOW WAS REPLACED, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFED AND DID NOT RESPOND TO THE CONTACT'S CONCERNS. THE FAILURE MILEAGE WAS APPROXIMATELY 2,500. WHEN THE EGRESS WINDOW DETACHED THE 2ND TIME, THE CAR BEHIND ME DID AN AGGRESSIVE MANEUVER BY SPEEDING AROUND ME AND APPLIED HIS BRAKES WHILE IN FRONT OF ME, FORCING ME TO COME TO AN ABRUPT STOP. THE DRIVER NOTIFIED ME THAT HE WAS ALMOST HIS BY A FLYING WINDOW FROM MY RV.
NHTSA ODI #11005010
130 miles · May 5, 2017
Visibility
PLEASE SEE ATTACHED LETTER DESCRIBING WIPER FUNCTIONS AND DAMAGE DONE TO MY RV AS A RESULT. ..UPDATED 05/15/17 *BF *AS *CN
NHTSA ODI #10984128
1,200 miles · Feb 2, 2017
StructureVisibility/wiper
TL* THE CONTACT OWNS A 2016 THOR OUTLAW 37RB RV. WHILE DRIVING 55 MPH, THE SLIDE OPENED. THE FAILURE COULD CAUSE THE SLIDE TO HIT VEHICLES IN ANOTHER LANE. THE MANUFACTURER REPLACED THE MOTORS FOR THE SLIDES AND ADJUSTED THE SLIDE, BUT THE FAILURE RECURRED. ALSO, WHEN DRIVING IN THE RAIN FOR THE FIRST TIME, THE WINDSHIELD WIPERS…
Read full complaint
TL* THE CONTACT OWNS A 2016 THOR OUTLAW 37RB RV. WHILE DRIVING 55 MPH, THE SLIDE OPENED. THE FAILURE COULD CAUSE THE SLIDE TO HIT VEHICLES IN ANOTHER LANE. THE MANUFACTURER REPLACED THE MOTORS FOR THE SLIDES AND ADJUSTED THE SLIDE, BUT THE FAILURE RECURRED. ALSO, WHEN DRIVING IN THE RAIN FOR THE FIRST TIME, THE WINDSHIELD WIPERS FAILED. THE VEHICLE WAS TAKEN TO THE MANUFACTURER WHERE THE WINDSHIELD WIPER ASSEMBLY WAS REPLACED, BUT THE FAILURE RECURRED. BECAUSE THE WIPER FAILURE RECURRED, THE WINDOWS FOGGED AND THE DEFROSTER DID NOT DEFROST THE WINDOW. THE VEHICLE WAS TAKEN TO THE MANUFACTURER WHERE IT WAS DETERMINED THAT THE SYSTEM WAS WORKING PROPERLY, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 1,200.
NHTSA ODI #10949141
1,500 miles · Aug 21, 2016
Seat Belts
WHILE DRIVING ON THE HIGHWAY I WAS HIT IN THE SIDE OF THE HEAD BY THE UPPER SAFETY BELT ASSEMBLY AND NUT CAUSING ME TO SWERVE OFF THE ROAD AND ALMOST HIT CONSTRUCTION BARRELS ON THE SIDE OF THE ROAD. HAD MY WIFE TAKE A PICTURE OF THE NUT THAT CAME OFF. I ALSO HAD MY PASSENGER CHECK THE SEAT BELT UPPER ATTACHMENT ON HIS SIDE AN…
Read full complaint
WHILE DRIVING ON THE HIGHWAY I WAS HIT IN THE SIDE OF THE HEAD BY THE UPPER SAFETY BELT ASSEMBLY AND NUT CAUSING ME TO SWERVE OFF THE ROAD AND ALMOST HIT CONSTRUCTION BARRELS ON THE SIDE OF THE ROAD. HAD MY WIFE TAKE A PICTURE OF THE NUT THAT CAME OFF. I ALSO HAD MY PASSENGER CHECK THE SEAT BELT UPPER ATTACHMENT ON HIS SIDE AND THE NUT WAS NOT SECURE JUST ON BY A FEW THREADS. HAD TO PULL OVER AT THE NEXT EXIT AND SECURE THE NUTS WITH THE TOOLS THAT I HAD WITH ME.
Thor Motor Coach (Thor) is recalling various 2003-2018 recreational vehicles, equipped with Kidde Plastic-Handle or Push Button 'Pindicator' Fire Extinguishers. See a list of the affected trailer models at: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17V758-5764.pdf. These extinguishers may become clogged, preventing the extinguisher from discharging as expected or excessive force may be needed to activate the extinguisher. Additionally, in certain models, the nozzle may detach from the valve assembly with enough force that it could cause injury and also render the product inoperable. For a full list of the affected fire extinguisher models visit: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17E062-5427.pdf
Consequence & remedy
Consequence: In the event of a fire, if the fire extinguisher does not function properly, it can increase the risk of injury.
Remedy: Thor will notify owners, instructing them to contact Kidde for a replacement fire extinguisher, free of charge. The recall began on January 15, 2018. Owners may contact Thor customer service at 1-877-500-1020, or Kidde customer service toll-free at 1-855-262-3540, or online at www.kidde.com and click on "Product Safety Recall" for more information.
Thor Motor Coach (TMC) is recalling certain 2014-2016 Ace, Challenger, Daybreak, Hurricane, Miramar, Outlaw, Windsport, Palazzo, Tuscany, and Tuscany XTE motorhomes. The windshield wipers may fail due to the system being incorrectly installed or secured.
Consequence & remedy
Consequence: If the windshield wipers cannot be used, driver visibility would be reduced, increasing the risk of a crash.
Remedy: TMC will notify owners, and dealers will inspect the wiper system to verify it is installed correctly, repairing or replacing the system as necessary, free of charge. The recall began on September 27, 2017. Owners may contact TMC customer service at 1-877-855-2867. TMC's number for this recall is RC000146. Note: Although some of the vehicles included in this recall have previously been remedied under recalls 17V-096 or 17V-162, the vehicles may need additional repairs under this campaign.
Thor Motor Coach (TMC) is recalling certain 2014-2015 ACE, Hurricane, Challenger, Daybreak, Miramar, Outlaw, and Windsport motorhomes. These vehicles have windshield wiper systems that may have been improperly installed and secured, possibly causing the wipers to fail during use.
Consequence & remedy
Consequence: Failure of the windshield wipers may impair the driver's visibility, increasing the risk of a crash.
Remedy: TMC has notified owners, and dealers will inspect and tighten the wiper arm securing nuts, free of charge. The recall began on May 5, 2017. Owners may contact TMC customer service at 1-877-855-2867.
Thor Motor Coach (TMC) is recalling certain model year 2016-2017 Outlaw motorhomes, models 37BG, 37LS, 37RB, 38RE and 38RF, manufactured January 13, 2016, to December 8, 2016. The affected vehicles have rear cargo door hinges with welds that may be inadequate for securing the hinge pin to the hinge plate.
Consequence & remedy
Consequence: If the welds are insufficient, the hinge may fail and the door could open with more force than normal, increasing the risk of injury.
Remedy: TMC will notify owners, and dealers will inspect the hinge weld thickness, replacing the hinge as necessary, free of charge. The recall began on February 6, 2017. Owners may contact TMC customer service at 1-877-500-1020.
Thor Motor Coach (TMC) is recalling certain model year 2016 Ace, Challenger, Hurricane, Miramar, Outlaw, and Windsport vehicles manufactured July 14, 2015, to October 16, 2015. Due to an incorrect shift cable bracket and an improper shift cable adjustment, the affected vehicles can be shifted out of 'PARK' without applying the brakes.
Consequence & remedy
Consequence: If the vehicle can be shifted into reverse without the brakes being applied, the vehicle may unintentionally move, increasing the risk of a crash.
Remedy: Ford will notify owners on TMC's behalf, and Ford dealers will replace the transmission shift control bracket and adjust the transmission shift cable, free of charge. The recall began on November 12, 2015. Owners may contact TMC customer service at 1-877-500-1020. TMC's number for this recall is RC000110.
Thor Motor Coach (TMC) is recalling certain model year 2016 Four Winds, Citation, Outlaw, Chateau, Siesta, and Freedom Elite motorhomes manufactured February 14, 2015, to April 6, 2015. The affected vehicles may be missing the water weight carrying capability information on the Occupant and Cargo Carrying Capacity (OCCC) label . As a result, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 120, "Tire Selection and Rims and Motor Home/Recreation Vehicle Trailer Load Carrying Capacity Information for Motor Vehicles with a GVWR of more than 4,536 kilograms (10,000 pounds)."
Consequence & remedy
Consequence: If the vehicle is loaded to its weight capacity without including the weight of the water carried onboard, the motorhome may be overloaded. This can cause a loss of vehicle control, increasing the risk of a crash.
Remedy: TMC will notify owners and will provide a new OCCC label with the correct information, free of charge. The recall began on May 1, 2015. Owners may contact TMC customer service at 1-877-500-1020. TMC's number for this recall is RC000099.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
PE20021 · Trimark 060-1650 Door Latch Failures
Opened Nov 23, 2020 · Closed Dec 13, 2024
Status: closed (inferred from source dates) · Equipment
On November 23, 2020, the Office of Defects Investigation (ODI) opened PE20021 to investigate allegations of inoperative Trimark THP 060-1650 door lock/latches originally equipped on model years (MY) 2015-2017 Class A and Class C motorhomes.ODI received forty-six Vehicle Owner’s Questionnaires (VOQs) describing consumers being locked in or out of their vehicles.The door latch, containing a die-cast zinc plunger, was produced by Equality during calendar years 2014-2016. The die-cast may become porous and brittle over time and can break without warning, causing the vehicle owner to be unable to open the recreational vehicle door equipped with the latch.If the motorhome does not have any other doors such as some Class A models, occupants could be trapped inside, needing to climb out using the emergency exits. If locked out, owners would be unable to easily get in and retrieve children and pets. ODI analyzed the data provided by Trimark in response to its January 27, 2021 information request letter.Although an elevated failure rate was evident on a specific combination of plunger bolt, door lock/latch assembly and door, the data showed that most failures occurred within the first two years of service on the affected 2015-2017 vehicles.This data suggests that component failures generally would have already occurred.Further, ODI data reflects a downward trend in complaints after calendar year 2018 and for post- MY 2016 vehicles.This downward trend may be attributed Trimark's actions in 2016 such as changes in the manufacturing process of its zinc plunger component for the relevant population and its 2016 decision to switch to a steel plunger. In view of the nature of early-life failure, and failure rate trending downward for model years 2017 and newer, this Preliminary Evaluation (PE) is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
2016 Thor Motor Outlaw Problems, Complaints & Recalls | Skip That Year
Illustration