Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 5 of 6 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Electrical System. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Exterior Lighting. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Structure. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports1 fire reports0 injury reports
What owners actually said
6 reports
2,000 miles · Jan 15, 2026
Visibility
The contact owns a 2018 Thor Motor Coach Windsport. The contact stated that on several occasions while driving in cold temperatures, the windshield immediately became foggy. The defroster was activated but only the center vents operated as intended, while the far left and right vents failed to work as intended. The vehicle was t…
Read full complaint
The contact owns a 2018 Thor Motor Coach Windsport. The contact stated that on several occasions while driving in cold temperatures, the windshield immediately became foggy. The defroster was activated but only the center vents operated as intended, while the far left and right vents failed to work as intended. The vehicle was taken to an independent mechanic, where it was diagnosed and determined that the OE system had two hoses connecting to the distribution box and A/C, but had no way for air to reach the far right and left vents. The vehicle was repaired by modifying the system to direct the air to all the vents. The manufacturer was notified of the failure. The failure mileage was approximately 2,000.
NHTSA ODI #11711174
48,900 miles · Aug 26, 2024
Structure
The contact owns a 2018 Thor Motor Coach Wind sport. The contact stated that while the RV was parked, the contact became aware that the front chassis was fractured. The RV was taken to the dealer where the RV was diagnosed, and it was determined that the front chassis had failed and needed to be replaced. The vehicle was not rep…
Read full complaint
The contact owns a 2018 Thor Motor Coach Wind sport. The contact stated that while the RV was parked, the contact became aware that the front chassis was fractured. The RV was taken to the dealer where the RV was diagnosed, and it was determined that the front chassis had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 48,900.
NHTSA ODI #11610881
47,700 miles · Mar 31, 2021
Electrical SystemFire
THE RADIO (AND CAMERA SYSTEM) HAD BEEN ACTING STRANGELY AND MY CIGARETTE OUTLETS STOPPED WORKING WHILE I WAS DRIVING. I STOPPED FOR THE NIGHT AND HAD PARKED AND CONNECTED THE RV TO THE CAMPGROUND POWER. ABOUT 10 MINUTES AFTER PARKING AND HOOKING UP I STARTED TROUBLE SHOOTING THE LOSS OF POWER TO THE CIGARETTE LIGHTERS. I CHEC…
Read full complaint
THE RADIO (AND CAMERA SYSTEM) HAD BEEN ACTING STRANGELY AND MY CIGARETTE OUTLETS STOPPED WORKING WHILE I WAS DRIVING. I STOPPED FOR THE NIGHT AND HAD PARKED AND CONNECTED THE RV TO THE CAMPGROUND POWER. ABOUT 10 MINUTES AFTER PARKING AND HOOKING UP I STARTED TROUBLE SHOOTING THE LOSS OF POWER TO THE CIGARETTE LIGHTERS. I CHECKED THE FUSE AND DID NOT SEE ANY VISIBLE FAILURE OF THE FUSE BUT DECIDED TO TRY A BRAND NEW FUSE JUST IN CASE. AFTER REPLACING THE FUSE FOR THE CIGARETTE LIGHTERS, A FIRE STARTED IN THE AREA OF THE RADIO AND CIGARETTE LIGHTERS. WHILE TRYING TO USE A FIRE EXTINGUISHER TO PUT OUT THE FIRE BY SPRAYING UP FROM UNDER THE DASH, THE RADIO FELL INTO THE DASH. I THEN SPRAYED WHAT WAS LEFT OF THE FIRE EXTINGUISHER INTO THE RADIO OPENING. I WAS UNABLE TO PUT THE FIRE OUT AS I NOTICED A GLOW IN THE DASH STILL TO THE DRIVERS SIDE OF THE RADIO OPENING. AT THAT POINT I EVACUATED THE RV AND CALLED 911. THE RV BURNED DOWN AND IS A TOTAL LOSS.
NHTSA ODI #11405729
Mileage unknown · Aug 31, 2020
Unknown Or Other
THERE IS A CABINET MOUNTED ON THE CEILING THAT IS ABOVE THE DRIVERS AND PASSENGERS SIDE THAT HAS NOT BEEN PROPERLY SECURED. THERE ARE COMPLAINTS AND PICTURES FOUND ON THE FACEBOOK GROUP FOR THOR OWNERS. I DECIDED TO CHECK MINE AND IT WAS LOOSE AND WHEN I OPENED THE DOORS ALL OF THE SCREWS LOCATED ON THE FRONT SIDE HAVE BEEN PU…
Read full complaint
THERE IS A CABINET MOUNTED ON THE CEILING THAT IS ABOVE THE DRIVERS AND PASSENGERS SIDE THAT HAS NOT BEEN PROPERLY SECURED. THERE ARE COMPLAINTS AND PICTURES FOUND ON THE FACEBOOK GROUP FOR THOR OWNERS. I DECIDED TO CHECK MINE AND IT WAS LOOSE AND WHEN I OPENED THE DOORS ALL OF THE SCREWS LOCATED ON THE FRONT SIDE HAVE BEEN PULLED DOWN FROM THE CEILING. I HAVE CONTACTED THOR BY EMAIL AND EXPLAINED TO THEM THAT THIS COULD CAUSE AN ACCIDENT IF IT FELL DOWN WHILE DRIVING.
NHTSA ODI #11352353
9,854 miles · Feb 4, 2020
Suspension
AXEL HANGERS ON THE PASSENGER SIDE OF MOTOR HOME WERE LOOSE, FOUND THAT THIS IS A PROBLEM WITH THE MOTOR-HOMES VERY UNSAFE WHEN TOWING A CAR OR TRAILER. ON HIGHWAY TRAVELING HAD TO STOP AND GET IT TORQUED TO CONTINUE. *DT*JB
NHTSA ODI #11307021
1,026 miles · May 20, 2019
Exterior Lighting
HEADLIGHTS NOT SECURELY FASTENED AND NOT AIMED APPROPRIATELY. TEN FEET AHEAD OF VEHICLE ON LOW BEAMS.
Thor Motor Coach (TMC) is recalling certain 2018-2021 Hurricane and Windsport recreational vehicles. The driver and front passenger overhead cabinets may detach.
Consequence & remedy
Consequence: Overhead cabinets that detach while the vehicle is in motion can fall onto seat occupants, increasing the risk of a crash or injury.
Remedy: Dealers will inspect and reinstall the overhead cabinets, if necessary, free of charge. Owner notification letters were mailed March 15, 2023. Owners may contact TMC customer service at 1-877-855-2867. TMC's number for this recall is RC000290.
Additional source detail variants (2)
Structure
Thor Motor Coach (TMC) is recalling certain 2018-2021 Hurricane and Windsport recreational vehicles. The driver and front passenger overhead cabinets may detach.
Consequence: Overhead cabinets that detach while the vehicle is in motion can fall onto seat occupants, increasing the risk of a crash or injury.
Remedy: Dealers will inspect and reinstall the overhead cabinets, if necessary, free of charge. Owner notification letters were mailed March 15, 2023. Owners may contact TMC customer service at 1-877-855-2867. TMC's number for this recall is RC000290.
Equipment:recreational Vehicle/trailer
Thor Motor Coach (TMC) is recalling certain 2018-2021 Hurricane and Windsport recreational vehicles. The driver and front passenger overhead cabinets may detach.
Consequence: Overhead cabinets that detach while the vehicle is in motion can fall onto seat occupants, increasing the risk of a crash or injury.
Remedy: Dealers will inspect and reinstall the overhead cabinets, if necessary, free of charge. Owner notification letters were mailed March 15, 2023. Owners may contact TMC customer service at 1-877-855-2867. TMC's number for this recall is RC000290.
Thor Motor Coach (TMC) is recalling certain 2018-2019 Hurricane and Windsport motorhomes. The overhead cabinets located above the driver and front passenger seats may detach and fall onto the seat occupants, possibly causing the driver to lose control of the vehicle.
Consequence & remedy
Consequence: A loss of vehicle control can increase the risk of a crash.
Remedy: TMC will notify owners, and dealers will inspect the overhead cabinets, and reinstall them as necessary, free of charge. The recall began January 29, 2021. Owners may contact TMC customer service at 1-877-855-2867. TMC's number for this recall is RC000208.
Thor Motor Coach (Thor) is recalling various 2003-2018 recreational vehicles, equipped with Kidde Plastic-Handle or Push Button 'Pindicator' Fire Extinguishers. See a list of the affected trailer models at: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17V758-5764.pdf. These extinguishers may become clogged, preventing the extinguisher from discharging as expected or excessive force may be needed to activate the extinguisher. Additionally, in certain models, the nozzle may detach from the valve assembly with enough force that it could cause injury and also render the product inoperable. For a full list of the affected fire extinguisher models visit: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17E062-5427.pdf
Consequence & remedy
Consequence: In the event of a fire, if the fire extinguisher does not function properly, it can increase the risk of injury.
Remedy: Thor will notify owners, instructing them to contact Kidde for a replacement fire extinguisher, free of charge. The recall began on January 15, 2018. Owners may contact Thor customer service at 1-877-500-1020, or Kidde customer service toll-free at 1-855-262-3540, or online at www.kidde.com and click on "Product Safety Recall" for more information.
Thor Motor Coach (TMC) is recalling certain 2018 Ace, Axis, Hurricane, Windsport, and Vegas motorhomes. The wiring for the trailer lights may have been inserted into the wrong locations of the trailer lighting socket causing the trailer lights to not function properly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: If the trailer lights do not function as intended, it can increase the risk of a crash.
Remedy: Thor has notified owners and dealers will re-wire a new connector, free of charge. The recall began on November 21, 2017. Owners may contact TMC customer service at 1-877-500-1020. TMC's number for this recall is RC000148.
Thor Motor Coach (TMC) is recalling certain 2017-2018 Challenger, Axis, Chateau, Four Winds, Hurricane, Miramar, Palazzo, Tuscany, Vegas, Venetian, and Windsport motorhomes. The cargo carrying capacity (CCC) label on these vehicles may indicate an incorrect water capacity for the water heater/fresh water tank. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 120, "Tires and Rims for Motor vehicles over 10,000lbs."
Consequence & remedy
Consequence: If the water capacity information is incorrect and it causes the vehicle to be over loaded, there would be an increased risk of a crash.
Remedy: TMC will notify owners and send them corrected labels, free of charge. The recall began on November 15, 2017. Owners may contact TMC customer service at 1-877-500-1020. TMC's number for this recall is RC000147.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2018 Thor Motor Coach Windsport Problems, Complaints & Recalls | Skip That Year
Illustration