PE24023 · Trailer Hitch Receiver Structure May Crack And Separate
Opened Aug 14, 2024 · Closed Jan 16, 2026
Status: closed (inferred from source dates) · Structure:frame And Members; Trailer Hitches
The Office of Defects Investigation (ODI) opened this Preliminary Evaluation, PE24023, on August 14, 2024, to investigate allegations of Thor Motor Coach motorhome frame or trailer hitch structure cracking and separating. The hitch was manufactured by Lippert and installed by Thor as standard original equipment. ODI received eight Vehicle Owner Questionnaires (VOQs) describing the hitch structure cracking. If not caught in time, a cracked hitch can fully fracture and separate from the vehicle. ODI sent information requests to Thor and Lippert on September 6, 2024 and September 27, 2024, respectively. Thor's full response was received October 31, 2024, and Lippert's full response was received December 6, 2024. ODI reviewed the responses and learned of improvements introduced to increase the overall strength of the system. The manufacturers reported 32 total incidents, and ODI is aware of 37 non-duplicative subject vehicle incidents in total, including four crash incidents where the towed vehicle separated and struck a roadside feature. The overall failure rate for all subject vehicles is low, and ODI isnot aware of any failures on vehicles produced in the last 30 months. Although a defect has not been identified, the manufacturers understand the seriousness of a potential hitch receiver structure failure. As a result, Thor, supported by Lippert, is conducting a customer satisfaction campaign that instructs consumers to inspect their hitch structure and informs what to look for and what to do if issues are found. If consumers areuncomfortable performing this inspection, Thor dealers can inspect the trailer hitch for them. The inspection and repair will be done at no expense to the consumer. ODI is closing this Preliminary Evaluation (PE) with this manufacturer action. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Structure:frame And Members
The Office of Defects Investigation (ODI) opened this Preliminary Evaluation, PE24023, on August 14, 2024, to investigate allegations of Thor Motor Coach motorhome frame or trailer hitch structure cracking and separating. The hitch was manufactured by Lippert and installed by Thor as standard original equipment. ODI received eight Vehicle Owner Questionnaires (VOQs) describing the hitch structure cracking. If not caught in time, a cracked hitch can fully fracture and separate from the vehicle. ODI sent information requests to Thor and Lippert on September 6, 2024 and September 27, 2024, respectively. Thor's full response was received October 31, 2024, and Lippert's full response was received December 6, 2024. ODI reviewed the responses and learned of improvements introduced to increase the overall strength of the system. The manufacturers reported 32 total incidents, and ODI is aware of 37 non-duplicative subject vehicle incidents in total, including four crash incidents where the towed vehicle separated and struck a roadside feature. The overall failure rate for all subject vehicles is low, and ODI isnot aware of any failures on vehicles produced in the last 30 months. Although a defect has not been identified, the manufacturers understand the seriousness of a potential hitch receiver structure failure. As a result, Thor, supported by Lippert, is conducting a customer satisfaction campaign that instructs consumers to inspect their hitch structure and informs what to look for and what to do if issues are found. If consumers areuncomfortable performing this inspection, Thor dealers can inspect the trailer hitch for them. The inspection and repair will be done at no expense to the consumer. ODI is closing this Preliminary Evaluation (PE) with this manufacturer action. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Trailer Hitches
The Office of Defects Investigation (ODI) opened this Preliminary Evaluation, PE24023, on August 14, 2024, to investigate allegations of Thor Motor Coach motorhome frame or trailer hitch structure cracking and separating. The hitch was manufactured by Lippert and installed by Thor as standard original equipment. ODI received eight Vehicle Owner Questionnaires (VOQs) describing the hitch structure cracking. If not caught in time, a cracked hitch can fully fracture and separate from the vehicle. ODI sent information requests to Thor and Lippert on September 6, 2024 and September 27, 2024, respectively. Thor's full response was received October 31, 2024, and Lippert's full response was received December 6, 2024. ODI reviewed the responses and learned of improvements introduced to increase the overall strength of the system. The manufacturers reported 32 total incidents, and ODI is aware of 37 non-duplicative subject vehicle incidents in total, including four crash incidents where the towed vehicle separated and struck a roadside feature. The overall failure rate for all subject vehicles is low, and ODI isnot aware of any failures on vehicles produced in the last 30 months. Although a defect has not been identified, the manufacturers understand the seriousness of a potential hitch receiver structure failure. As a result, Thor, supported by Lippert, is conducting a customer satisfaction campaign that instructs consumers to inspect their hitch structure and informs what to look for and what to do if issues are found. If consumers areuncomfortable performing this inspection, Thor dealers can inspect the trailer hitch for them. The inspection and repair will be done at no expense to the consumer. ODI is closing this Preliminary Evaluation (PE) with this manufacturer action. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
PE20021 · Trimark 060-1650 Door Latch Failures
Opened Nov 23, 2020 · Closed Dec 13, 2024
Status: closed (inferred from source dates) · Equipment
On November 23, 2020, the Office of Defects Investigation (ODI) opened PE20021 to investigate allegations of inoperative Trimark THP 060-1650 door lock/latches originally equipped on model years (MY) 2015-2017 Class A and Class C motorhomes.ODI received forty-six Vehicle Owner’s Questionnaires (VOQs) describing consumers being locked in or out of their vehicles.The door latch, containing a die-cast zinc plunger, was produced by Equality during calendar years 2014-2016. The die-cast may become porous and brittle over time and can break without warning, causing the vehicle owner to be unable to open the recreational vehicle door equipped with the latch.If the motorhome does not have any other doors such as some Class A models, occupants could be trapped inside, needing to climb out using the emergency exits. If locked out, owners would be unable to easily get in and retrieve children and pets. ODI analyzed the data provided by Trimark in response to its January 27, 2021 information request letter.Although an elevated failure rate was evident on a specific combination of plunger bolt, door lock/latch assembly and door, the data showed that most failures occurred within the first two years of service on the affected 2015-2017 vehicles.This data suggests that component failures generally would have already occurred.Further, ODI data reflects a downward trend in complaints after calendar year 2018 and for post- MY 2016 vehicles.This downward trend may be attributed Trimark's actions in 2016 such as changes in the manufacturing process of its zinc plunger component for the relevant population and its 2016 decision to switch to a steel plunger. In view of the nature of early-life failure, and failure rate trending downward for model years 2017 and newer, this Preliminary Evaluation (PE) is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration