Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 1 of 4 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Suspension. Review the 2 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Wheels. Review the 2 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Fuel System, Gasoline. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports0 fire reports0 injury reports
What owners actually said
4 reports
70,000 miles · Sep 12, 2025
Fuel System, Gasoline
The contact owns a 2018 Thor Motor Coach Four Winds Motorhome constructed on a 2017 Ford E-350 Chassis and hauling a 17-foot cargo trailer. The contact stated that while traveling to another state in the mountains, the RV suddenly began to buck and lost motive power and stalled on several occasions. The contact was able to pull …
Read full complaint
The contact owns a 2018 Thor Motor Coach Four Winds Motorhome constructed on a 2017 Ford E-350 Chassis and hauling a 17-foot cargo trailer. The contact stated that while traveling to another state in the mountains, the RV suddenly began to buck and lost motive power and stalled on several occasions. The contact was able to pull over safely. There were no warning lights illuminated. The RV was taken to an independent mechanic who determined that the fuel module needed to be replaced. The RV was repaired, but the failure reoccurred. A mobile RV mechanic determined that the fuel module needed to be replaced. The RV was repaired, but the failure persisted. The RV stalled, leaving the occupants stranded for several hours, but eventually restarted. The RV was taken to the local dealer, where it was determined that the OEM fuel module needed to be replaced but eventually used an aftermarket fuel module. The RV was towed to another local dealer, Harry Robinson Sallisaw Ford (2300 S Kerr Blvd, Sallisaw, OK 74955) where it was determined that the fuel module, fuel pump, and PCM needed to be replaced. The vehicle was repaired, but the failure persisted, and the RV was towed back to the same local dealer. The manufacturer was contacted, who confirmed there was no warranty coverage on the RV for the failure. The failure mileage was approximately 70,000.
NHTSA ODI #11686957
Mileage unknown · Oct 11, 2021
Wheels
Twice! Wheel rim developed a hairline crack in the weld adjacent to the valve stem. 2-times, different rims - both on inside dually rear - one left and one right side. The first happened on our first long trip in 2019. The second time was on the next long trip of 2021. Internet forums are showing that this is a rather "COMM…
Read full complaint
Twice! Wheel rim developed a hairline crack in the weld adjacent to the valve stem. 2-times, different rims - both on inside dually rear - one left and one right side. The first happened on our first long trip in 2019. The second time was on the next long trip of 2021. Internet forums are showing that this is a rather "COMMON" issue! Plus, Mercedes has recorded lawsuits with similar rim weld failures on other Mercedes vehicles. I get NO sympathy or compensation through Mercedes or Thor - They each kick the can to the other, and the consumer is left at risk. Human safety is at great risk!
NHTSA ODI #11436297
Mileage unknown · Jul 2, 2018
Suspension
INCORRECT WEIGHT DISTRIBUTION. BACK OF VICHICLE TO LOW,WHICH CAUSES FRONT TO BE TO HIGH. UNABLE TO MAINTAIN LANE WHEN BENG PASSED BY A BIG RIG OR SIDE GUST OF WIND. VICHICLE VERY UNSTABLE,SHOULD NOT HAVE BEEN SOLD IN THAT CONDITION.
NHTSA ODI #11105074
Mileage unknown · Oct 20, 2017
SteeringSuspensionWheels
ONCE YOU GO ABOVE 40 MPH THE STEARING WHEEL STARTS TO SHIMMY AND THE FRONT END VIBRATES. IT TAKES ALL YOUR EFFORT TO HOLD IT ON THE ROAD UNTIL YOU REACH THE SPEED OF 70 MPH OR MORE. THIS HAPPENS WHILE TRAVELING ON MAJOR HIGHWAYS LIKE I95.
Thor Motor Coach (TMC) is recalling certain 2020-2021 Daybreak 23DB, 2018-2021 Four Winds 23U, and 2018-2021 Chateau 23U motorhomes. Bolts of the wrong size were used to secure the barrel chair pedestals, allowing the pedestal to separate from the floor in the event of a crash. As such, these motorhomes fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 207, "Seating Systems" and number 210, "Seat Belt Assembly Anchorages."
Consequence & remedy
Consequence: If the pedestal were to separate from the floor during a crash, the seat belt anchorages may fail, increasing the risk of injury.
Remedy: TMC will notify owners, and dealers will inspect the pedestal bolt size, correcting the hardware as necessary, free of charge. This recall began September 14, 2020. Owners may contact TMC customer service at 1-877-855-2867. TMC's number for this recall is RC000202.
Additional source detail variants (2)
Seats
Thor Motor Coach (TMC) is recalling certain 2020-2021 Daybreak 23DB, 2018-2021 Four Winds 23U, and 2018-2021 Chateau 23U motorhomes. Bolts of the wrong size were used to secure the barrel chair pedestals, allowing the pedestal to separate from the floor in the event of a crash. As such, these motorhomes fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 207, "Seating Systems" and number 210, "Seat Belt Assembly Anchorages."
Consequence: If the pedestal were to separate from the floor during a crash, the seat belt anchorages may fail, increasing the risk of injury.
Remedy: TMC will notify owners, and dealers will inspect the pedestal bolt size, correcting the hardware as necessary, free of charge. This recall began September 14, 2020. Owners may contact TMC customer service at 1-877-855-2867. TMC's number for this recall is RC000202.
Seat Belts
Thor Motor Coach (TMC) is recalling certain 2020-2021 Daybreak 23DB, 2018-2021 Four Winds 23U, and 2018-2021 Chateau 23U motorhomes. Bolts of the wrong size were used to secure the barrel chair pedestals, allowing the pedestal to separate from the floor in the event of a crash. As such, these motorhomes fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 207, "Seating Systems" and number 210, "Seat Belt Assembly Anchorages."
Consequence: If the pedestal were to separate from the floor during a crash, the seat belt anchorages may fail, increasing the risk of injury.
Remedy: TMC will notify owners, and dealers will inspect the pedestal bolt size, correcting the hardware as necessary, free of charge. This recall began September 14, 2020. Owners may contact TMC customer service at 1-877-855-2867. TMC's number for this recall is RC000202.
Thor Motor Coach (TMC) is recalling certain 2018 Thor Chateau and Four Winds motorhomes and 2019-2020 Magnitude and Omni motorhomes. The backup camera displays may revert back to the factory default settings which may cause the camera image to be reversed.
Consequence & remedy
Consequence: If the monitor displays the image in reverse, the driver may unintentionally turn in the wrong direction, increasing the risk of crash.
Remedy: TMC will notify owners, and dealers will install a harness to install that will prevent the image from inverting, free of charge. The recall began April 30, 2019. Owners may contact TMC customer service at 1-877-855-2867. TMC's number for this recall is RC000168.
Additional source detail variants (2)
Visibility:rearview Mirrors/devices
Thor Motor Coach (TMC) is recalling certain 2018 Thor Chateau and Four Winds motorhomes and 2019-2020 Magnitude and Omni motorhomes. The backup camera displays may revert back to the factory default settings which may cause the camera image to be reversed.
Consequence: If the monitor displays the image in reverse, the driver may unintentionally turn in the wrong direction, increasing the risk of crash.
Remedy: TMC will notify owners, and dealers will install a harness to install that will prevent the image from inverting, free of charge. The recall began April 30, 2019. Owners may contact TMC customer service at 1-877-855-2867. TMC's number for this recall is RC000168.
Visibility:rearview Mirrors/devices:interior
Thor Motor Coach (TMC) is recalling certain 2018 Thor Chateau and Four Winds motorhomes and 2019-2020 Magnitude and Omni motorhomes. The backup camera displays may revert back to the factory default settings which may cause the camera image to be reversed.
Consequence: If the monitor displays the image in reverse, the driver may unintentionally turn in the wrong direction, increasing the risk of crash.
Remedy: TMC will notify owners, and dealers will install a harness to install that will prevent the image from inverting, free of charge. The recall began April 30, 2019. Owners may contact TMC customer service at 1-877-855-2867. TMC's number for this recall is RC000168.
Thor Motor Coach (TMC) is recalling certain 2018-2019 Thor Four Winds, Chateau, and Freedom Elite vehicles. The liquid propane (LP) hose may not have adequate space between the floor and the metal plate on the refrigerator, causing damage to the hose and possibly creating a propane leak.
Consequence & remedy
Consequence: A propane leak can increase the risk of a fire.
Remedy: TMC will notify owners, and dealers will remove a portion of the refrigerator base plate to provide additional clearance for the LP hose, free of charge. The recall began December 11, 2018. Owners may contact TMC customer service at 1-877-855-2867. TMC's number for this recall is RC000162.
Thor Motor Coach (Thor) is recalling various 2003-2018 recreational vehicles, equipped with Kidde Plastic-Handle or Push Button 'Pindicator' Fire Extinguishers. See a list of the affected trailer models at: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17V758-5764.pdf. These extinguishers may become clogged, preventing the extinguisher from discharging as expected or excessive force may be needed to activate the extinguisher. Additionally, in certain models, the nozzle may detach from the valve assembly with enough force that it could cause injury and also render the product inoperable. For a full list of the affected fire extinguisher models visit: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17E062-5427.pdf
Consequence & remedy
Consequence: In the event of a fire, if the fire extinguisher does not function properly, it can increase the risk of injury.
Remedy: Thor will notify owners, instructing them to contact Kidde for a replacement fire extinguisher, free of charge. The recall began on January 15, 2018. Owners may contact Thor customer service at 1-877-500-1020, or Kidde customer service toll-free at 1-855-262-3540, or online at www.kidde.com and click on "Product Safety Recall" for more information.
Thor Motor Coach (TMC) is recalling certain 2017-2018 Challenger, Axis, Chateau, Four Winds, Hurricane, Miramar, Palazzo, Tuscany, Vegas, Venetian, and Windsport motorhomes. The cargo carrying capacity (CCC) label on these vehicles may indicate an incorrect water capacity for the water heater/fresh water tank. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 120, "Tires and Rims for Motor vehicles over 10,000lbs."
Consequence & remedy
Consequence: If the water capacity information is incorrect and it causes the vehicle to be over loaded, there would be an increased risk of a crash.
Remedy: TMC will notify owners and send them corrected labels, free of charge. The recall began on November 15, 2017. Owners may contact TMC customer service at 1-877-500-1020. TMC's number for this recall is RC000147.
Thor Motor Coach (TMC) is recalling certain 2018 Four Winds, Chateau and Freedom Elite recreational vehicles. The liquid propane (LP) hose may sag and become pinched between the frame and the leaf spring u-bolts, potentially damaging the hose and causing a propane leak.
Consequence & remedy
Consequence: A propane fuel leak may increase the risk of a fire.
Remedy: TMC will notify owners, and dealers will inspect the LP hose routing and install additional P-clamps or relocate the P-clamps to properly secure the hose, free of charge. The recall began on October 13, 2017. Owners may contact TMC customer service at 1-877-500-1020. TMC's number for this recall is RC000144.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2018 Thor Motor Coach Four Winds Problems, Complaints & Recalls | Skip That Year
Illustration