IllustrationFRAME ROLLS ON 2004 THOR TAHOE TOYHAULER 39FEET LONG SAFETY RECALL NOTICE ISSUED HAS HAPPENED 3X AND NOW THEY DON'T WANT TO COME GOOD TO FIX IT. THEY HAVE FIXED HALF THE PROBLEM ONLY.
2004 Thor California Tahoe Fury
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Other model years Selected year
Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 4 of 8 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Structure. Review the 4 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Visibility. Review the 2 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Equipment. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports0 fire reports0 injury reports
What owners actually said
8 reportsWAS DRIVING WITH MY 2004 33' TAHOE FURY TOY HAULER SWAYED THE ENTIRE WAY. IT SWAYED INTO THE MEDIAN AND BLEW THREE TIRES ON THE LEFT SIDE AND DID LOTS OF BODY DAMAGE. THE SWAYING IS A BIG PROBLEM NO MATTER HOW I TRY TO SET THIS UP. I HAVE FOUND A CAMPAIGN ID 04V24300 BUT THE MANUAL CLAIMS IT HAS BEEN CANCELED SO NOW THERE IS …
Read full complaint
WAS DRIVING WITH MY 2004 33' TAHOE FURY TOY HAULER SWAYED THE ENTIRE WAY. IT SWAYED INTO THE MEDIAN AND BLEW THREE TIRES ON THE LEFT SIDE AND DID LOTS OF BODY DAMAGE. THE SWAYING IS A BIG PROBLEM NO MATTER HOW I TRY TO SET THIS UP. I HAVE FOUND A CAMPAIGN ID 04V24300 BUT THE MANUAL CLAIMS IT HAS BEEN CANCELED SO NOW THERE IS NO REMEDY TO MY TOY HAULDER. *JB
DT: NUMEROUS REPAIRS DONE TO PULL BEHIND TRAVEL TRAILER. 1. THE FRAME HAS BEEN OUT OF SQUARE AND COULDN'T OPEN THE REAR DOOR . 2. THE FLOOR ON THE LEFT SAGS BY AN INCH. 3. THE TRAILER BLOWS TIRES EASILY. 4. THE WINDOWS AND VENT OPEN ON THEIR OWN DUE TO VIBRATION. CONSUMER RECEIVED A RECALL ABOUT THE FRAME STRUCTURE THAT WAS…
Read full complaint
DT: NUMEROUS REPAIRS DONE TO PULL BEHIND TRAVEL TRAILER. 1. THE FRAME HAS BEEN OUT OF SQUARE AND COULDN'T OPEN THE REAR DOOR . 2. THE FLOOR ON THE LEFT SAGS BY AN INCH. 3. THE TRAILER BLOWS TIRES EASILY. 4. THE WINDOWS AND VENT OPEN ON THEIR OWN DUE TO VIBRATION. CONSUMER RECEIVED A RECALL ABOUT THE FRAME STRUCTURE THAT WAS ASSOCIATED WITH THE PROBLEMS THAT THE CONSUMER WAS HAVING. CURRENTLY, THE MANUFACTURER SAYS THAT THERE IS NO RECALL ON IT. THEY WILL BE MAILING OUT NEW NOTICES EXPLAINING WHY THEY WERE MISINFORMED. HE TALKED TO SHAWN MAPES. WHEN THE CONSUMER CALLS MR MAPES HE HANGS UP ON HIM. ALSO, TALKED TO CEO. MANUFACTURER IS THORCALIFORNIA, 2004 TAHOE FURY.*AK
CONSUMER RECEIVED RECALL NOTICE 04V241000 CONCERNING FRAME AND MEMBERS. BECAUSE OF IMPROPER WEIGHT DISTRIBUTION DEALER REFUSED TO DO RECALL REPAIRS. *AK
I BOUGHT A NEW 2004 TOUAREG IN DALLAS. TWO TO THREE WEEKS INTO DRIVING IT, THE NAVIGATION SYSTEM/RADIO/CD WENT COMPLETELY "DARK" AND STOPPED WORKING. IT'S NOW STUCK ON ONE RADIO STATION. NOTHING ELSE WORKS AND THE SCREEN IS 100% BLACK. THE DEALERSHIP TOLD ME THAT THEY A) HAVE NO REPLACEMENT UNIT B) THERE IS NOT A UNIT IN THE USA…
Read full complaint
I BOUGHT A NEW 2004 TOUAREG IN DALLAS. TWO TO THREE WEEKS INTO DRIVING IT, THE NAVIGATION SYSTEM/RADIO/CD WENT COMPLETELY "DARK" AND STOPPED WORKING. IT'S NOW STUCK ON ONE RADIO STATION. NOTHING ELSE WORKS AND THE SCREEN IS 100% BLACK. THE DEALERSHIP TOLD ME THAT THEY A) HAVE NO REPLACEMENT UNIT B) THERE IS NOT A UNIT IN THE USA C) THEY CAN'T SHIP ONE FROM GERMANY D) THEY WON'T DISABLE A CAR ON THE LOT AND SWAP UNITS AND E) THAT I HAVE TO RETURN MY LOAN CAR AND DRIVE MY TOUAREG UNTIL A PART COMES IN (WHICH MAY BE NEVER ACCORDING TO THEM). I ASKED FOR EITHER A NEW CAR OR ALL OF MY MONEY BACK. THEY REFUSED THAT AS WELL. AT THIS POINT I HAVE KEPT THEIR LOAN CAR AND MY LAWYER SERVED PAPERS ON THE GM OF THE DEALERSHIP THIS MORNING. I REALLY HOPE THAT EITHER VOLKSWAGENOR THE DEALERSHIP DOES THE RIGHT THING.*AK
SUDDEN ACCELERATION FROM SLOW SPEED. REPEATABLE AT WILL. STEPS TO REPRODUCE: BRING VEHICLE TO SLOW SPEED (<5MPH), PUSH ACCELERATOR. NOTHING HAPPENS FOR A FEW SECONDS, THEN VEHICLE UNEXPECTEDLY *LEAPS* FORWARD THROWING VEHICLE OCCUPANTS BACK INTO THEIR SEATS.
NEW CAR NEW MODEL VOLKSWAGEN TOUAREG. A LOT OF PROBLEMS WINDSHIELD IS WARPED AND HAS A LOT OF FLAWS ON THE GLASS- WHEN DRIVING IN SUNLIGHT THE GLASS IS WAVY AND ROAD AND SIGNS ARE BLURY AT TIMES. *LA
"RUNNING GEAR FAULT / WORKSHOP!" COMES ON WHEN THE VEHICLE IS MOVING OVER A HARD BUMP. DEALER SAYS THAT VW SENT A 'FIX" AND IT SHOULD BE OK. IT IS NOT OK !! I WAS READING IN A PORSCHE FORUM THAT THE AIR SPRING ON A CAYENNE GAVE OUT AND THE VEHICLE TROLLED OVER IN AN OFF ROADING TRIP!!! (ROADFLY.COM). *JB
Official recalls
406V468000 · Structure
Dec 4, 2006
ON CERTAIN CARGO/TRAVEL TRAILERS, OVERLOADING AND INCORRECTLY POSITIONING CARGO IN THE REAR CARGO AREA CAN RESULT IN ALIGHT HITCH WEIGHT AND AFFECT STABILITY.
Consequence & remedy
Consequence: DEPENDING ON THE SPECIFIC TOW VEHICLE AND ITS HITCH EQUIPMENT, A SUFFICIENTLY LIGHT HITCH WEIGHT CAN RESULT IN SWAY AT HIGHWAY SPEEDS. TOO MUCH WEIGHT INCORRECTLY POSITIONED CAN ALSO RESULT IN SEVERE BENDING OF THE A-FRAME ASSEMBLY, FAILURE OF THE COUPLER ASSEMBLY, AND/OR FAILURE OF THE SAFETY CHAINS. THIS CAN CAUSE A CRASH INVOLVING THE TRAILER AND TOW VEHICLE.
Remedy: DEALERS WILL INSPECT THE TRAILER, TOW VEHICLE AND HITCH EQUIPMENT; INSTALL NEW CARGO LOAD LIMIT LABELS AND PLACARDS IN THE CARGO AREA; FURNISH LOADING LIMIT INFORMATION; REPLACE THE COUPLER AND SAFETY CHAINS; AND REINFORCE THE A-FRAME. THE RECALL BEGAN ON NOVEMBER 15, 2006. OWNERS SHOULD CONTACT THOR AT 1-888-697-8467. NOTE: THIS CAMPAIGN SUPERSEDES A PREVIOUS RECALL (PLEASE SEE 04V243).
04V241000 · Structure
May 25, 2004
ON CERTAIN TRAVEL TRAILERS, IMPROPER WEIGHT DISTRIBUTION MAY OCCUR WHEN THE BACK OF THE TRAVEL TRAILER IS LOADED WITH CARGO.
Consequence & remedy
Consequence: UNDER CERTAIN LOAD CONDITIONS, THE IMPROPER WEIGHT DISTRIBUTION MAY CAUSE HANDLING PROBLEMS, INCLUDING BUT NOT LIMITED TO, POTENTIAL SWAYING OF THE TRAILER WHILE BEING TOWED ON THE ROAD. THIS COULD ULTIMATELY RESULT IN AN CRASH INVOLVING THE TRAVEL TRAILER AND THE TOW VEHICLE.
Remedy: DEALERS WILL ADD REINFORCING STEEL TO THE A-FRAME, INSTALL A NEW COUPLER WITH HIGHER WEIGHT CAPACITY, AND HIGHER CAPACITY SAFETY CHAINS. OWNERS SHOULD CONTACT THOR CALIFORNIA AT 1-888-697-8467.
04V242000 · Structure
May 25, 2004
ON CERTAIN TRAVEL TRAILERS, IMPROPER WEIGHT DISTRIBUTION MAY OCCUR WHEN THE BACK OF THE TRAVEL TRAILER IS LOADED WITH CARGO.
Consequence & remedy
Consequence: UNDER CERTAIN LOAD CONDITIONS, THE IMPROPER WEIGHT DISTRIBUTION MAY CAUSE HANDLING PROBLEMS, INCLUDING BUT NOT LIMITED TO, POTENTIAL SWAYING OF THE TRAILER WHILE BEING TOWED ON THE ROAD. THIS COULD ULTIMATELY RESULT IN AN CRASH INVOLVING THE TRAVEL TRAILER AND THE TOW VEHICLE.
Remedy: DEALERS WILL ADD THE NECESSARY WEIGHT AT THE TRAILER'S A-FRAME. OWNERS SHOULD CONTACT THOR CALIFORNIA AT 1-888-697-8467. THIS RECALL WAS SUPERSEDED BY 06V-466.
04V243000 · Structure
May 25, 2004
ON CERTAIN 'TOY BOX' TRAVEL TRAILERS, IMPROPER WEIGHT DISTRIBUTION MAY OCCUR WHEN THE BACK OF THE TRAVEL TRAILER IS LOADED WITH CARGO.
Consequence & remedy
Consequence: UNDER CERTAIN LOAD CONDITIONS, THE IMPROPER WEIGHT DISTRIBUTION MAY CAUSE HANDLING PROBLEMS WITH THE TRAVEL TRAILER, INCLUDING BUT NOT LIMITED TO, POTENTIAL SWAYING OF THE TRAILER WHILE BEING TOWED ON THE ROAD, WHICH COULD ULTIMATELY RESULT IN A CRASH INVOLVING THE TRAVEL TRAILER AND THE TOW VEHICLE.
Remedy: DEALERS WILL ADD THE NECESSARY WEIGHT AT THE TRAILER'S A-FRAME, CHANGE THE TRAILERS A-FRAME TO A THICKER STEEL, AND CHANGE THE TRAILER'S COUPLER AND SAFETY CHAINS TO A HIGHER WEIGHT RATING. THE RECALL IS EXPECTED TO BEGIN DURING JANUARY OR FEBRUARY 2005. OWNERS SHOULD CONTACT THOR CALIFORNIA AT 1-888-697-8467.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.