CERTAIN SCHOOL BUSES WITH WELDON TECHNOLOGIES' 5050-1400 SURFACE MOUNT MARKER LIGHTS HAVE AN OPTION TO REPLACE EACH OF THE TWELVE CLEARANCE/MARKER/IDENTIFICATION LIGHTS WITH FOUR-CANDLEPOWER LIGHTS, TWICE THE CANDLEPOWER NORMALLY USED. THE HIGHER CURRENT DEMAND CREATED BY THESE LIGHTS CAN CAUSE EXCESSIVE HEAT THROUGH THE HEADLIGHT SWITCH CONNECTION IF A RELAY IS NOT INSTALLED BETWEEN THE COMBINATION TAIL/MARKER LIGHT CIRCUIT AND THE HEADLIGHT SWITCH.
Consequence & remedy
Consequence: THIS CAN RESULT IN DEFORMATION OF THE PLASTIC CONNECTORS THAT CONNECT THE HEADLIGHT SWITCH TO ITS WIRING HARNESS.
Remedy: DEALERS WILL INSTALL A RELAY TO REDUCE THE CURRENT DRAW THROUGH THE HEADLIGHT SWITCH. OWNER NOTIFICATION BEGAN SEPTEMBER 8, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT THOMAS BUILT AT 1-336-881-7219.
VEHICLE DESCRIPTION: TRANSIT AND SCHOOL BUSES EQUIPPED WITH ELECTRONIC ENGINES. THE BOTTOM EDGE OF THE ACCELERATOR PEDAL CAN CATCH ON THE FLOOR MAT WHEN THE PEDAL IS FULLY DEPRESSED. THIS DOES NOT MEET THE REQUIREMENTS OF FMVSS NO. 124, "ACCELERATOR CONTROL SYSTEMS."
Consequence & remedy
Consequence: IF THE ACCELERATOR PEDAL CATCHES ON THE FLOOR MAT, ENGINE OVERSPEED COULD OCCUR, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSTALL A NEW ACCELERATOR PEDAL MOUNTING BRACKET TO RAISE THE ACCELERATOR SO THE PEDAL DOES NOT CATCH ON THE FLOOR MAT.
VEHICLE DESCRIPTION: TRANSIT AND SCHOOL BUSES EQUIPPED WITH CUMMINS ISB OR CATERPILLAR 3126 ENGINES. A DECAL THAT WARNS OF THE DANGER OF USING ETHER OR OTHER STARTING FLUIDS IN THE ENGINE AIR INTAKE SYSTEM WAS OMITTED. THE LABEL SHOULD BE LOCATED ON THE FIXED HEADLIGHT PANEL ON THE FRONT OF THE BUS.
Consequence & remedy
Consequence: THE ELECTRICAL PREHEATER ELEMENT COULD POSSIBLY BE IGNITED BY STARTING FLUID SPRAYED INTO THE AIR INTAKE SYSTEM, RESULTING IN EXPLOSION AND POSSIBLE PERSONAL INJURY TO THOSE IN AND AROUND THE BUS.
Remedy: OWNERS WILL BE PROVIDED WITH A WARNING LABEL AND INSTALLATION INSTRUCTIONS.
VEHICLE DESCRIPTION: SCHOOL AND TRANSIT BUSES EQUIPPED WITH IN-LINE SIX ENGINE,"S" TYPE FRAME RAILS AND SIDE MOUNTED BATTERY BOX. THE BATTERY CABLE ROUTING ALLOWS THE POSITIVE CABLE TO CHAFE RESULTING IN A POSSIBLE SHORT CIRCUIT OF THE CABLE.
Consequence & remedy
Consequence: IF AN ELECTRICAL SHORT OCCURS, IT CAN CAUSE LOSS OF POWER TO THE VEHICLE AND A POSSIBLE VEHICLE FIRE.
Remedy: THOMAS BUILT WILL PROVIDE OWNERS WITH REPAIR PARTS AND DETAILED REPAIR PROCEDURES TO SECURE THE CABLE TO PREVENT FURTHER DAMAGE. IF THE OWNER SO DESIRES, THOMAS BUILT WILL PERFORM THE REPAIR FOR THEM.
AN ITEM WORN BY A CHILD, SUCH AS A LONG DRAWSTRING, SASH, OR BACKPACK/BOOKBAG ACCESSORY, CAN BECOME CAUGHT ON THE FATENERS THAT SECURE THE HANDRAIL SUPPORT TO THE HANDRAIL.
Consequence & remedy
Consequence: IF AN ITEM WORN BY A CHILD WERE TO CATCH ON THIS AREA, AND THE DRIVER WERE TO CLOSE THE DOOR AND PUT THE VEHICLE IN MOTION, THIS CAN RESULT IN SERIOUS INJURY OR DEATH.
Remedy: THE EXISTING 1" BOLTS THAT SECURE THE HANDRAIL SUPPORT WILL BE REPLACED WITH 1/2" BOLTS.
AN ITEM WORN BY A CHILD, SUCH AS A LONG DRAWSTRING, SASH, OR BACKPACK/BOOKBAG ACCESSORY, CAN BECOME CAUGHT IN THE AREA BETWEEN THE SERVICE DOOR AND THE DOOR CONTROL ROD ATTACHING BRACKET.
Consequence & remedy
Consequence: IF AN ITEM WORN BY A CHILD WERE TO CATCH ON THIS AREA, AND THE DRIVER WERE TO CLOSE THE DOOR AND PUT THE VEHICLE IN MOTION, THIS CAN RESULT IN SERIOUS INJURY OR DEATH.
Remedy: A MOLDED COVER WILL BE INSTALLED BETWEEN THE MANUALLY OPERATED OUTWARD OPENING ENTRANCE DOOR AND THE DOOR CONTROL ROD ATTACHING BRACKET WHICH WILL ELIMINATE THE OPENING THAT COULD ALLOW AN ITEM OF A CHILD'S CLOTHING TO BECOME SNAGGED.
THE METAL HOUSING OF THE SAFETY BELT RETRACTORS ON AUTOMATIC LOCKING RETRACTOR/EMERGENCY LOCKING RETRACTOR SAFETY BELTS CAN BECOME DEFORMED PREVENTING EXTENSION AND/OR RETRACTION OF THE BELT.
Consequence & remedy
Consequence: PASSENGERS WOULD BE UNABLE TO EXTEND OR RETRACT THEIR SAFETY BELTS AND WOULD BE AT A RISK OF INJURY IN THE EVENT OF AN ACCIDENT.
Remedy: DEALERS WILL INSTALL A HARDENED WASHER WHICH WILL DECREASE THE POSSIBILITY OF DEFORMATION OF THE SAFETY BELT RETRACTOR. DAMAGED RETRACTORS WILL BE REPLACED.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
PE06057 · Seat Belts Webbing Abrading On Frame
Opened Nov 21, 2006 · Closed Mar 30, 2007
Status: closed (inferred from source dates) · Seat Belts
THIS INVESTIGATION WAS OPENED AFTER ODI RECEIVED NOTIFICATION FROM TWO FLEETS ALLEGING THEDISCOVERY OFNUMEROUS SEAT BELTS WITH CUT WEBBING AS A RESULT OF THE WEBBING ABRADING AGAINST ANUNDERSEAT METAL BRACKET.THE SUBJECT VEHICLES ARE CLASS A SCHOOL BUSES WEIGHING UNDER 10,000 POUNDS.THEY ARE REQUIRED BY FEDERAL STANDARD FMVSS 208 TO HAVE SEAT BELTS.AS A RESULT OF THIS INVESTIGATION, FREIGHTLINER WILL CONDUCT A SAFETY RECALL TO INSPECT ALL AFFECTED BUSES FOR SEAT BELT ?CHAFING? AND WILL REPLACEDAMAGED BELTS AS NEEDED. ALSO, THE SEAT BELT RETAINER STRIP WILL BE MODIFIED OR REPLACED TO PREVENT FUTURE CHAFING.FREIGHTLINER EXPANDED THE SCOPE OF THE RECALL (BEYOND THE ORIGINAL INVESTIGATION POPULATION) TO INCLUDE APPROXIMATELY 10,251 ADDITIONAL BUSES HAVING GROSS VEHICLE WEIGHT RATINGS GREATER THAN 10,000 LBS.THEY DETERMINED THAT THESE BUSES ARE ALSO SUSCEPTIBLE TO THE CHAFING ACTION.THERE IS NO FEDERALREQUIREMENT FOR SEAT BELTS IN SCHOOL BUSES WEIGHING OVER 10,000 POUNDS.HOWEVER, SOME CUSTOMERS HAVE ORDERED SEAT BELTS AND SOME STATES HAVE REQUIREMENTS FOR SEAT BELTS.THEREFORE, FREIGHTLINER HAS AGREED TO ADDRESS THOSE BUSES EVEN THOUGH THERE IS NO APPLICABLE FEDERAL STANDARD.THE RECALL ACTION TAKEN BY FREIGHTLINER RESOLVES THE ISSUES RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
1994 Thomas Mvp Problems, Complaints & Recalls | Skip That Year
Illustration