When problems were reported
Mileage at the reported incident
Limited mileage data: 0 of 0 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
NHTSA owner reports · September 18, 2026 snapshot.
Official recalls
12Jul 30, 2008
DAIMLER TRUCKS IS RECALLING 3,773 MY 1996 THROUGH 2002 THOMAS BUILT MVP ER SCHOOL BUSES MANUFACTURED FROM JUNE 8, 1995 THROUGH FEBRUARY 16, 2001, EQUIPPED WITH CATERPILLAR 3116 AND 3126 ENGINES. UN-FUSED POWER CABLES WERE TIE-WRAPPED TO A WIRE BRAID ENGINE FUEL RETURN HOSE. OVER TIME THESE CABLES MAY CHAFE, WEARING THROUGH THE WIRE LOOM AND EVENTUALLY THROUGH THE CABLE INSULATION AND FUEL LINE COVERING IN AN AREA NOT EASILY DETECTABLE DURING NORMAL MAINTENANCE WITHOUT REMOVING THE TIE WRAPS AND OPENING THE WIRE LOOM. UN-FUSED AND UN-SWITCHED POWER CABLES WHICH WEAR THROUGH AND CONTACT THE FUEL LINE WIRE BRAID MAY SHORT CIRCUIT.
Consequence & remedy
Consequence: IN THE EVENT OF A SHORT CIRCUIT, A VEHICLE FIRE CAN OCCUR.
Remedy: THOMAS BUILT WILL NOTIFY OWNERS AND INSPECT AND REPLACE THE CABLES AS NECESSARY FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN ON OR ABOUT NOVEMBER 28, 2008. OWNERS MAY CONTACT THOMAS BUILT AT 1-336-889-4871.
Feb 26, 2008
DAIMLER TRUCKS IS RECALLING 243,435 MY 1995-2008 THOMAS BUILT SCHOOL BUSES MANUFACTURED BETWEEN JANUARY 1994, AND MARCH 10, 2008. (ADDITIONAL BUSES HAVE BEEN ADDED TO THIS RECALL CAMPAIGN. PLEASE SEE SUPPLEMENTAL REPORT NO. 4) THE EMERGENCY EXIT DOOR HANDLE BEGINS CORRODING AROUND THE SECURING ROLL PIN AND SQUARE DRIVE MECHANISM CAUSING THE PROTECTIVE FINISH TO CHIP AND FLAKE. CONTINUED CORROSION AND PITTING WEAKENS THE HANDLE. HANDLES WEAKENED BY CORROSION MAY BREAK WHILE TRYING TO OPEN THE DOOR FROM THE EXTERIOR.
Consequence & remedy
Consequence: IN THE EVENT OF AN EMERGENCY, A PERSON ON THE OUTSIDE OF THE BUS MAY BREAK THE DOOR HANDLE TRYING TO OPEN THE EMERGENCY EXIT POTENTIALLY DELAYING EVACUATION AND INCREASING THE RISK OF PERSONAL INJURY TO THE VEHICLE'S OCCUPANTS.
Remedy: DAIMLER TRUCKS WILL NOTIFY OWNERS AND WILL REPLACE THE HANDLES WITH A MORE ROBUST HANDLE FREE OF CHARGE. REPAIRS WILL BE PERFORMED BY THOMAS BUILT BUSES DEALERSHIPS. THE RECALL BEGAN ON AUGUST 18, 2008, AND NOTIFICATION FOR THE REVISED POPULATION IS EXPECTED TO BEGIN ON OR ABOUT APRIL 29, 2009. OWNERS MAY CONTACT THOMAS BUILT AT 336-889-4871.
Mar 23, 2007
CERTAIN MY 2000 THROUGH 2003 THOMAS BUILT HDX AND MVP-ER SCHOOL BUSES MANUFACTURED BETWEEN APRIL 23, 2000, AND NOVEMBER 14, 2003. THE SERVICE AIR BRAKE PEDAL, FOR BOTH NON-ADJUSTABLE AND ADJUSTABLE BRAKE PEDALS, MAY CONTACT THE FRONT STRUCTURE ON THE BUS, LIMITING THE MAXIMUM BRAKE FORCE AVAILABLE.
Consequence & remedy
Consequence: INSUFFICIENT AIR BRAKE PRESSURE MAY CAUSE EXTENDED STOPPING DISTANCES WITHOUT PRIOR WARNING, POSSIBLY RESULTING IN A VEHICLE CRASH.
Remedy: THOMAS BUILT WILL NOTIFY OWNERS AND REPAIR THE AFFECTED BUSES FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 14, 2007. OWNERS CAN CONTACT THOMAS BUILT AT 336-889-4871 OR CONTACT FREIGHTLINER AT 800-547-0712.
Apr 27, 2005
CERTAIN 1998-2003 MY FREIGHTLINER FS-65 SCHOOL BUS CHASSIS AND MB-45, MB-55, AND XB SHUTTLE BUS CHASSIS, AND THOMAS BUILT BUS: MVP-ER AND MVP-EF SCHOOL BUS AND NON-SCHOOL BUS MODELS EQUIPPED WITH CUMMINS ISB DIESEL ENGINES AND EQUIPPED WITH FEDERAL-MOGAL 12 AND 24 VOLT FUEL LIFT PUMPS. THE FUEL PUMP COULD FAIL TO TRANSFER FUEL APPROPRIATELY CREATING AN ENGINE STALL CONDITION.
Consequence & remedy
Consequence: SHOULD THE ENGINE STALL WHILE THE VEHICLE IS IN USE, A POSSIBLE VEHICLE CRASH COULD OCCUR.
Remedy: CUMMINS WILL NOTIFY THE CUSTOMERS OF FREIGHTLINER AND THOMAS BUILT AND REPLACE THE FUEL LIFT PUMP FREE OF CHARGE. OWNERS MAY CONTACT CUMMINS AT 1-800-DIESELS.
Oct 31, 2002
ON CERTAIN SCHOOL OR TRANSIT BUSES WITH PASSENGER SEAT BELTS WITH RETRACTORS, THE COVER HALVES FOR THE RETRACTABLE PORTION OF THE BELT CAN SEPARATE COMPLETELY AND RELEASE THE SEAT BELT CONNECTOR. IF THIS OCCURS, ONE OF THE LOAD BEARING PINS IN THE CONNECTOR COULD SEPARATE FROM THE CONNECTOR AND RENDER THE SEAT BELT UNUSABLE. IN THE EVENT OF A CRASH, THE SEAT OCCUPANT WOULD NOT BE PROPERLY RESTRAINED RESULTING IN AN INJURY. THE SEAT BELT SUPPLIER, AMSAFE, WILL PROVIDE A SNAP ON "OVER-COVER" TO OWNERS TO PREVENT THE SEAT BELT COVER FROM SEPARATING.
Consequence & remedy
Consequence: IF THIS OCCURS, ONE OF THE LOAD BEARING PINS IN THE CONNECTOR COULD SEPARATE FROM THE CONNECTOR AND RENDER THE SEAT BELT UNUSABLE. IN THE EVENT OF A CRASH, THE SEAT OCCUPANT WOULD NOT BE PROPERLY RESTRAINED RESULTING IN AN INJURY.
Remedy: DEALERS WILL PROVIDE A PLASTIC OUTER COVER THAT SNAPS OVER THE EXISTING COVER ON UNITS IN THE FIELD AND WILL REPLACE BROKEN SEAT BELTS FREE OF CHARGE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT THOMAS BUILT AT 336-841-5924 OR AMSAFE AT 574-266-8330.
Aug 6, 2002
ON CERTAIN SCHOOL AND TRANSIT BUSES, THE WHEEL LUG NUT MAY NOT TIGHTEN COMPLETELY.
Consequence & remedy
Consequence: THE WHEEL COULD LOOSEN INCREASING THE RISK OF LOSS OF CONTROL OF THE VEHICLE.
Remedy: DEALERS WILL INSTALL NEW WHEEL STUDS. OWNER NOTIFICATION BEGAN FEBRUARY 28, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT THOMAS BUILT AT 336-889-4871.
Mar 20, 2002
ON CERTAIN SCHOOL BUSES, MISALIGNMENT OF THE FAN DRIVE SYSTEM COMPONENTS CAN CAUSE PREMATURE BELT AND PULLEY BEARING WEAR.
Consequence & remedy
Consequence: IF THE SCHOOL BUS IS DISABLED BY A COOLING SYSTEM FAILURE AND IS STALLED ON THE SIDE OF THE ROAD, AN INCREASED RISK OF A CRASH RESULTING IN INJURY TO A SCHOOL BUS OCCUPANT COULD OCCUR.
Remedy: DEALERS WILL REPLACE THE FAN BELT, IDLER PULLEY, AND BELT TENSIONER AND THE PULLEY'S LASER WILL BE ALIGNED. OWNER NOTIFICATION BEGAN JUNE 10, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FREIGHTLINER AT 1-800-547-0712.
Jun 26, 2001
VEHICLE DESCRIPTION: SCHOOL AND TRANSIT BUSES EQUIPPED WITH SAFETY BELT ASSEMBLIES PRODUCED BY AM-SAFE. ON SOME SEAT BELTS, THE BUCKLE AND CONNECTOR MAY UNLATCH DURING A COLLISION.
Consequence & remedy
Consequence: SERIOUS INJURY OR DEATH COULD OCCUR IF THE VEHICLE OCCUPANT IS NOT PROPERLY RESTRAINED.
Remedy: AM-SAFE NOTIFIED THOMAS BUILT'S CUSTOMERS TO RETURN THEIR VEHICLE TO AN AUTHORIZED DEALER TO HAVE THE SEAT BELTS REPAIRED FREE OF CHARGE. OWNER NOTIFICATION BEGAN SEPTEMBER 21, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT THOMAS BUILT AT 1-336-889-4871.
Mar 27, 2001
VEHICLE DESCRIPTION: CERTAIN SCHOOL BUSES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 121, "AIR BRAKE SYSTEMS." THESE VEHICLES DO NOT COMPLY DUE TO THE LOW AIR WARNING SYSTEM DETECTING PRESSURE IN ONLY ONE RESERVOIR SYSTEM AND NOT BOTH AS REQUIRED.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE STANDARD.
Remedy: DEALERS WILL CORRECT THE LOW AIR PRESSURE SWITCH WIRING. OWNER NOTIFICATION BEGAN JULY 27, 2001. OWNER NOTIFICATION IS EXPECTED TO BEGIN OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT THOMAS BUILT AT 336-881-7219.
Nov 3, 2000
VEHICLE DESCRIPTION: CERTAIN SCHOOL BUSES AND TRANSIT BUSES EQUIPPED WITH NATIONAL SEATING'S SERIES 93B-SB DRIVER SEAT. A BRACKET ATTACHING THE GAS SPRING SHOCK TO THE HEIGHT ADJUSTER OF THE SEAT CAN DEFORM AND BREAK. THIS BRACKET IS LOCATED AT THE TOP OF THE HEIGHT ADJUSTER.
Consequence & remedy
Consequence: IF THE BRACKET IS NOT REPLACED AFTER DEFORMING, AND IS ALLOWED TO BREAK, ITS BREAKING WILL RESULT IN A SUDDEN DROP OF THE DRIVER'S SEAT, INCREASING THE RISK OF LOSS OF CONTROL OF THE VEHICLE AND A CRASH.
Remedy: DEALERS WILL REPLACE THE SEAT BASE AND ADD REINFORCEMENT TO THE SEAT ASSEMBLY
Aug 7, 2000
VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS AND SCHOOL BUS CHASSIS BUILT WITH BENDIX AIR ABS WITH AN EC-17 1030R ELECTRONIC CONTROL UNIT (ECU), THERE HAVE BEEN REPORTS OF UNWANTED ABS ACTIVATION AT LOW SPEEDS CAUSED BY 1) CHAFED ABS WHEEL SPEED SENSOR WIRES ON ROTATING PARTS OR 2) A DAMAGED COMPONENT AT THE WHEEL END THAT GENERATES A CERTAIN TYPE OF ERRATIC SENSOR SIGNAL.
Consequence & remedy
Consequence: THIS CONDITION COULD CAUSE THE ABS ECU TO EXHAUST THE AIR AT THE AIR BRAKE MODULATORS FOR ONE OR MORE OF THE WHEELS. THIS COULD RESULT IN EXTENDED BRAKING DISTANCES AND A POSSIBLE CRASH.
Remedy: DEALERS WILL REPLACE THE ABS ECU.
Aug 7, 2000
VEHICLE DESCRIPTION: SCHOOL BUS CHASSIS AND EMERGENCY VEHICLES BUILT WITH BENDIX AIR ABS WITH AN EC-17 1030R ELECTRONIC CONTROL UNIT (ECU), THERE HAVE BEEN REPORTS OF UNWANTED ABS ACTIVATION AT LOW SPEEDS CAUSED BY 1) CHAFED ABS WHEEL SPEED SENSOR WIRES ON ROTATING PARTS OR 2) A DAMAGED COMPONENT AT THE WHEEL END THAT GENERATES A CERTAIN TYPE OF ERRATIC SENSOR SIGNAL.
Consequence & remedy
Consequence: THIS CONDITION COULD CAUSE THE ABS ECU TO EXHAUST THE AIR AT THE AIR BRAKE MODULATORS FOR ONE OR MORE OF THE WHEELS. THIS COULD RESULT IN EXTENDED BRAKING DISTANCES AND A POSSIBLE CRASH.
Remedy: DEALERS WILL REPLACE THE ABS ECU.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3PE07054 · Emergency Door Handle Failure
Opened Nov 9, 2007 · Closed Mar 4, 2008
Status: closed (inferred from source dates) · Structure:body:door:hinge And Attachments
THE OFFICE OF DEFECTS INVESTIGATION OPENED THIS PRELIMINARY EVALUATIONAFTERBECOMING AWARE THAT FLEETS WERE HAVING HANDLE FAILURES ON THE REAR EMERGENCY DOOR EXIT.THE FAILURE RESULTED IN THE DOOR HANDLE SEPARATING FROM THEDOOR LATCH MECHANISM.WHEN THE HANDLE FAILS, THE REAR EMERGENCY EXIT DOOR CAN NOT BE OPENED FROM OUTSIDE THE BUS.THE FAILURE RESULTS FROM CORROSION OF THE EXTERIOR DOOR HANDLE AROUND THE SECURING ROLL PIN AND SQUARE DRIVE LATCH MECHANISM, CAUSING THE PROTECTIVE FINISH TO CHIP AND FLAKE.CONTINUED CORROSION WEAKENS THE HANDLE AND EVENTUALLY THE HANDLE MAY BREAK WHILE TRYING TO OPEN THE EXIT DOOR.ODI WAS CONCERNED THAT DURING AN EMERGENCY, A PERSON OUTSIDE OF THE BUS WOULD BREAK THE DOOR HANDLE WHILE TRYING TO OPEN THE EMERGENCY EXIT DOOR,POTENTIALLY DELAYING EVACUATION OF THE BUS.UNDER THE SAFETY RECALL, THE ALUMINUM HANDLES WILL BE REPLACED WITH A MORE ROBUST HANDLE.THE RECALL ACTION RESOLVES THE ISSUES RAISED BY THIS INVESTIGATION. ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
PE07008 · Restricted Brake Pedal Movement
Opened Feb 12, 2007 · Closed Apr 16, 2007
Status: closed (inferred from source dates) · Service Brakes, Air:controls:foot Control/valve
ODI WAS CONTACTED BY THE NEW YORK DOT WHO REPORTEDSEVERAL BUSES FAILED BRAKING TESTS WHEN BEING TESTED DURING AN ANNUAL INSPECTION. THE SUBJECT SCHOOL BUSES ARE OPTIONED WITH AN ADJUSTABLE FOOT PEDAL POSITIONING DEVICE THAT ALLOWS THE DRIVER TO RAISE AND LOWER THE BRAKE PEDAL HEIGHT TO SUIT HIS/HER SEATING POSITION.WHEN THE LOWEST PEDAL POSITION IS SELECTED (BY A BUTTON ON THE DASHBOARD), NYDOT REPORTED THAT THE BRAKE PEDAL BOTTOMED OUT ON THE FLOOR, THUS PREVENTING A FULL BRAKE PEDAL APPLICATION.THIS RESULTED IN A REDUCTION OF BRAKE TORQUE AT THE WHEEL ENDS.FREIGHTLINER WILL CONDUCT A SAFETY RECALL TO CORRECT THIS PROBLEM.THE REMEDY CALLS FOR A LONGER PEDAL PUSH ROD BEING INSTALLED IN- PLACE OF THE ORIGINAL PUSH ROD. THEY ALSO INCREASED THE POPULATION TO INCLUDE THE MVP-ER MODEL BUSES.THIS RESOLVES THE ISSUE RAISED BY THIS INVESTIGATION. ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
PE02023 · Fan Drive Update
Opened Feb 12, 2002 · Closed Mar 25, 2002
Status: closed (inferred from source dates) · Engine And Engine Cooling
IN OCTOBER 2001, THOMAS BUILT BUSES SENT OUT A VEHICLE OWNER NOTIFICATION (VON) TO BUS OWNERS OUTLINING PROCEDURES FOR THE PROPER ALIGNMENT AND REPLACEMENT OF THE ENGINE'S FAN DRIVE COMPONENTS.DIRECTIONS IN THE COMMUNICATION REQUIRE THAT THE IDLER PULLEY, BELT TENSIONER, AND THE FAN BELT WILL NEED TO BE REPLACED.PRESUMABLY, THIS ACTION WAS BEING RECOMMENDED TO ELIMINATE FAN BELT SEPARATIONS WHILE THE BUSES ARE IN SERVICE.A FAN BELT SEPARATION WOULD RESULT IN THE NGINE OVERHEATING AND ULTIMATELY STALLING.AS A RESULT OF THIS ACTION, ODI CONTACTED TWO FLEETS AND DETERMINED THAT THEY HAD SUFFERED DISABLED BUSES ON THE SHOULDER OF THE ROAD AS A RESULT OF A FAN BELT FAILURE.ON FEBRUARY 12, 2001, ODI OPENED THIE PRELIMINARY EVALUATION TO UNDERSTAND THE EXTENT OF THE FAILURES AND THE RATIONALE FOR CONDUCTING AN OWNER NOTIFICATION PROGRAM IN LIEU OF A SAFETY RECALL CAMPAIGN.ON MARCH 15, 2002, THOMAS BUILT FILED A DEFECT REPORT OUTLINING THEIR PLANS TO CONDUCT A SAFETY RECALL TO NOTIFY THE REMAINING OWNERS AND REMEDY THE AFFECTED SCHOOL BUSES.THIS INVESTIGATION IS CLOSED.
Illustration