IllustrationLED LIGHT STARTED SMOKING AND BURNED UP EMITTING SMOKE INSIDE THE BUS. THIS WAS THE SECOND INCIDENT WITH THIS TYPE OF LIGHT. *TR
2005 Thomas FS-65
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all FS-65 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 1 of 2 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Exterior Lighting. Review the 2 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports0 fire reports0 injury reports
What owners actually said
2 reportsI WRITING IN RESPONSE TO A SERVICE BULLETIN ISSUED BY FREIGHTLINER CUSTOM CHASSIS, SB 54-26. THIS SERVICE BULLETIN COVERS AN ISSUE WITH THE TURN SIGNAL CANCELLATION RING ON A 2005 MODEL THOMAS SCHOOL BUS. THE MANUFACTURER HAS INCORRECTLY INSTALLED THE PART WHICH CANCELS THE TURN SIGNAL AFTER A TURN IS COMPLETED. DUE TO THE FACT…
Read full complaint
I WRITING IN RESPONSE TO A SERVICE BULLETIN ISSUED BY FREIGHTLINER CUSTOM CHASSIS, SB 54-26. THIS SERVICE BULLETIN COVERS AN ISSUE WITH THE TURN SIGNAL CANCELLATION RING ON A 2005 MODEL THOMAS SCHOOL BUS. THE MANUFACTURER HAS INCORRECTLY INSTALLED THE PART WHICH CANCELS THE TURN SIGNAL AFTER A TURN IS COMPLETED. DUE TO THE FACT THAT THIS PART WAS INCORRECTLY INSTALLED, IT IS IMPOSSIBLE AT TIMES TO SIGNAL WHEN MAKING A TURN, AS IS INDICATED IN THEIR SERVICE BULLETIN. I WAS NOT ABLE TO GET ANY INFORMATION ON THIS DEFECT UNTIL MY 19 SCHOOL BUSES WERE OUT OF THEIR WARRANTY PERIOD. I BELIEVE THIS SERVICE BULLETIN SHOULD BE UPGRADED TO A RECALL DUE TO THE SAFETY FACTOR INVOLVED. NO ONE HAS BEEN INJURED AS A RESULT OF THIS DEFECT, BUT I FEEL THIS PROBLEM SHOULD BE CORRECTED AND THE MANUFACTURER SHOULD TAKE FINANCIAL RESPONSIBILITY FOR THEIR NEGLIGENCE BEFORE AN ACCIDENT RESULTS FROM IT. *NM
Official recalls
205V467000 · Suspension:rear:axle:spindle
Oct 5, 2005
CERTAIN 2005 THOMAS BUILT FS-65 AND C-2 SCHOOL BUSES AND 2005 FREIGHTLINER ARGOSY, COLUMBIA, CENTURY ST, AND M2 BUSINESS CLASS TRUCKS MANUFACTURED BETWEEN JUNE 4 AND JULY 8, 2005. THE SPINDLES IN THE REAR AXLE HOUSING WERE OVERHEATED DURING THE HEAT TREATMENT PROCESS. INCORRECTLY HEAT TREATED SPINDLES COULD RESULT IN A FRACTURE OF THE SPINDLE.
Consequence & remedy
Consequence: INCORRECTLY HEAT TREATED SPINDLES COULD FRACTURE, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Remedy: FREIGHTLINER WILL NOTIFY ITS CUSTOMERS AND INSPECT FOR THE HEAT TREAT DATE CODE ON THE END OF THE REAR SPINDLES AND REPLACE THE AXLE HOUSING IF NECESSARY. THE RECALL IS EXPECTED TO BEGIN ON JANUARY 23, 2006. OWNERS MAY CONTACT FREIGHTLINER
05V426000 · Service Brakes, Hydraulic
Sep 20, 2005
CERTAIN FREIGHTLINER CUSTOM CHASSIS FS-65 SCHOOL BUS CHASSIS AND FB-65 SHUTTLE BUS CHASSIS EQUIPPED WITH CATERPILLAR C7 ENGINES AND REVISED COOLING PACKAGES AND MANUFACTURED BETWEEN JANUARY 24, 2004, AND JUNE 15, 2005. THE FRONT HYDRAULIC LINE MAY RUB THROUGH ON A RADIATOR TUBE, POSSIBLY RESULTING IN THE LOSS OF BRAKE FLUID TO THE FRONT BRAKES.
Consequence & remedy
Consequence: THE DEFECT MAY CAUSE THE LOSS OF FRONT BRAKES, RESULTING IN EXTENDED STOPPING DISTANCES AND POSSIBLY A VEHICLE CRASH.
Remedy: FREIGHTLINER AND THOMAS BUILT WILL NOTIFY ITS CUSTOMERS AND WILL INSPECT AND SECURE THE BRAKE LINE TO PROVIDE MORE CLEARANCE FREE OF CHARGE. THE RECALL BEGAN ON JANUARY 20, 2006. OWNERS MAY CONTACT FREIGHTLINER AT 1-800-547-0712.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1EA07002 · Steering Column Weld Cracks
Opened Jan 30, 2007 · Closed Jul 12, 2007
Status: closed (inferred from source dates) · Steering; Steering:column
AS A RESULT OF THE ODI INVESTIGATION, FREIGHTLINER HAS AGREED TO RECALL (NUMBER 07V-289) ALL OF THE VEHICLES MANUFACTURED WITH STEERING COLUMNS POTENTIALLY MISSING WELDS.THE RECALL REMEDY WILL INVOLVE INSPECTING THE RECALLED VEHICLES FOR MISSING WELDS AND IF FOUND REPLACE THE STEERING COLUMN.EARLY WARNING AGGREGATE DATA SUBMITTED TO NHTSA BY FREIGHTLINER SUGGESTED THAT A STEERING PROBLEM (EWR CODE 01) EXISTED FOR THE 2004 AND 2005 CENTURY AND COLUMBIA CLASS VEHICLES.THE COUNT OF FIELD REPORTS SUBMITTED FOR THE FIRST QUARTER OF 2006 WAS HIGHER THAN THE AVERAGE OF THE PREVIOUS 6 QUARTERS FOR THE AGGREGATE STEERING DATA.ODI'S FURTHER REVIEW OF THE EWR DATA FOUNDFIELD REPORTS THAT DESCRIBED STEERING COLUMN FAILURES AS A RESULT OF STEERING COLUMN WELDS CRACKING OR BREAKING.INFORMATION RECEIVED FROM FREIGHTLINER DETAILED FAILURES OF THE STEERING COLUMNS ON THE SUBJECT VEHICLES.THESE FAILURES WERE THE RESULT OF MISSING AND CRACKED WELDS ON THE STEERING COLUMN ASSEMBLY.DURING TESTING OF VEHICLES CONTAINING DEFECTIVE STEERING COLUMNS, ODI DETERMINED THAT WELD FAILURES IN THE STEERING COLUMN CREATE A SITUATION WHERE THE VEHICLE BECOMES DIFFICULT TO STEER OR MAY STARTLE THE DRIVER UPON FAILING, THUS PRESENTING A SAFETY RISK.A COPY OF THE RECALL IS ATTACHED.FREIGHTLINER'S ACTION RESOLVES THE ISSUES RAISED BY THIS INVESTIGATION AND, THEREFORE, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (2)
Steering:column
AS A RESULT OF THE ODI INVESTIGATION, FREIGHTLINER HAS AGREED TO RECALL (NUMBER 07V-289) ALL OF THE VEHICLES MANUFACTURED WITH STEERING COLUMNS POTENTIALLY MISSING WELDS.THE RECALL REMEDY WILL INVOLVE INSPECTING THE RECALLED VEHICLES FOR MISSING WELDS AND IF FOUND REPLACE THE STEERING COLUMN.EARLY WARNING AGGREGATE DATA SUBMITTED TO NHTSA BY FREIGHTLINER SUGGESTED THAT A STEERING PROBLEM (EWR CODE 01) EXISTED FOR THE 2004 AND 2005 CENTURY AND COLUMBIA CLASS VEHICLES.THE COUNT OF FIELD REPORTS SUBMITTED FOR THE FIRST QUARTER OF 2006 WAS HIGHER THAN THE AVERAGE OF THE PREVIOUS 6 QUARTERS FOR THE AGGREGATE STEERING DATA.ODI'S FURTHER REVIEW OF THE EWR DATA FOUNDFIELD REPORTS THAT DESCRIBED STEERING COLUMN FAILURES AS A RESULT OF STEERING COLUMN WELDS CRACKING OR BREAKING.INFORMATION RECEIVED FROM FREIGHTLINER DETAILED FAILURES OF THE STEERING COLUMNS ON THE SUBJECT VEHICLES.THESE FAILURES WERE THE RESULT OF MISSING AND CRACKED WELDS ON THE STEERING COLUMN ASSEMBLY.DURING TESTING OF VEHICLES CONTAINING DEFECTIVE STEERING COLUMNS, ODI DETERMINED THAT WELD FAILURES IN THE STEERING COLUMN CREATE A SITUATION WHERE THE VEHICLE BECOMES DIFFICULT TO STEER OR MAY STARTLE THE DRIVER UPON FAILING, THUS PRESENTING A SAFETY RISK.A COPY OF THE RECALL IS ATTACHED.FREIGHTLINER'S ACTION RESOLVES THE ISSUES RAISED BY THIS INVESTIGATION AND, THEREFORE, THIS INVESTIGATION IS CLOSED.
Steering
AS A RESULT OF THE ODI INVESTIGATION, FREIGHTLINER HAS AGREED TO RECALL (NUMBER 07V-289) ALL OF THE VEHICLES MANUFACTURED WITH STEERING COLUMNS POTENTIALLY MISSING WELDS.THE RECALL REMEDY WILL INVOLVE INSPECTING THE RECALLED VEHICLES FOR MISSING WELDS AND IF FOUND REPLACE THE STEERING COLUMN.EARLY WARNING AGGREGATE DATA SUBMITTED TO NHTSA BY FREIGHTLINER SUGGESTED THAT A STEERING PROBLEM (EWR CODE 01) EXISTED FOR THE 2004 AND 2005 CENTURY AND COLUMBIA CLASS VEHICLES.THE COUNT OF FIELD REPORTS SUBMITTED FOR THE FIRST QUARTER OF 2006 WAS HIGHER THAN THE AVERAGE OF THE PREVIOUS 6 QUARTERS FOR THE AGGREGATE STEERING DATA.ODI'S FURTHER REVIEW OF THE EWR DATA FOUNDFIELD REPORTS THAT DESCRIBED STEERING COLUMN FAILURES AS A RESULT OF STEERING COLUMN WELDS CRACKING OR BREAKING.INFORMATION RECEIVED FROM FREIGHTLINER DETAILED FAILURES OF THE STEERING COLUMNS ON THE SUBJECT VEHICLES.THESE FAILURES WERE THE RESULT OF MISSING AND CRACKED WELDS ON THE STEERING COLUMN ASSEMBLY.DURING TESTING OF VEHICLES CONTAINING DEFECTIVE STEERING COLUMNS, ODI DETERMINED THAT WELD FAILURES IN THE STEERING COLUMN CREATE A SITUATION WHERE THE VEHICLE BECOMES DIFFICULT TO STEER OR MAY STARTLE THE DRIVER UPON FAILING, THUS PRESENTING A SAFETY RISK.A COPY OF THE RECALL IS ATTACHED.FREIGHTLINER'S ACTION RESOLVES THE ISSUES RAISED BY THIS INVESTIGATION AND, THEREFORE, THIS INVESTIGATION IS CLOSED.