IllustrationWHILE DRIVING HOME AT 65 MPH REAR INSIDE PASSENGER TIRE BLEW OUT. MICHELIN, SIZE 255/80R22.5, DOT#V6H6AK30100. *AK
2000 Thomas Bus
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Bus years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 2 of 3 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Latches/locks/linkages. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Seat Belts. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Tires. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
1 crash reports0 fire reports1 injury reports
Tires complaints
1 reportsOfficial recalls
0No recalls in this snapshot.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3PE07008 · Restricted Brake Pedal Movement
Opened Feb 12, 2007 · Closed Apr 16, 2007
Status: closed (inferred from source dates) · Service Brakes, Air:controls:foot Control/valve
ODI WAS CONTACTED BY THE NEW YORK DOT WHO REPORTEDSEVERAL BUSES FAILED BRAKING TESTS WHEN BEING TESTED DURING AN ANNUAL INSPECTION. THE SUBJECT SCHOOL BUSES ARE OPTIONED WITH AN ADJUSTABLE FOOT PEDAL POSITIONING DEVICE THAT ALLOWS THE DRIVER TO RAISE AND LOWER THE BRAKE PEDAL HEIGHT TO SUIT HIS/HER SEATING POSITION.WHEN THE LOWEST PEDAL POSITION IS SELECTED (BY A BUTTON ON THE DASHBOARD), NYDOT REPORTED THAT THE BRAKE PEDAL BOTTOMED OUT ON THE FLOOR, THUS PREVENTING A FULL BRAKE PEDAL APPLICATION.THIS RESULTED IN A REDUCTION OF BRAKE TORQUE AT THE WHEEL ENDS.FREIGHTLINER WILL CONDUCT A SAFETY RECALL TO CORRECT THIS PROBLEM.THE REMEDY CALLS FOR A LONGER PEDAL PUSH ROD BEING INSTALLED IN- PLACE OF THE ORIGINAL PUSH ROD. THEY ALSO INCREASED THE POPULATION TO INCLUDE THE MVP-ER MODEL BUSES.THIS RESOLVES THE ISSUE RAISED BY THIS INVESTIGATION. ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
EA04014 · School Bus Lighting Failures
Opened Jun 9, 2004 · Closed Dec 20, 2004
Status: closed (inferred from source dates) · Exterior Lighting:headlights:switch; Interior Lighting
SEE ATTACHED FOUR PAGE TECHNICAL REPORT FOR DETAILS.
Additional source detail variants (2)
Exterior Lighting:headlights:switch
SEE ATTACHED FOUR PAGE TECHNICAL REPORT FOR DETAILS.
Interior Lighting
SEE ATTACHED FOUR PAGE TECHNICAL REPORT FOR DETAILS.
PE04012 · Headlight Switch Failures
Opened Feb 2, 2004 · Closed Jun 9, 2004
Status: closed (inferred from source dates) · Exterior Lighting:headlights:switch; Interior Lighting
ODI HAS RECEIVED SEVERAL FAILED SWITCHES THAT SHOW SIGNS OF MELTING OR DAMAGE FROM OVER- HEATING.THE SWITCH SUPPLIER HAS INITIATED A TEST PROGRAM TO DETERMINE THE CAUSE OF THESE FAILURES.ODI IS CONCERNED ABOUT THE PRESENCE OF A HEAT SOURCE THAT POTENTIALLY COULD LEAD TO AN ELECTRICAL FIRE, AS WELL AS THE ABSENCE OF NECESSARY VEHICLE LIGHTING.ODI WILL CONTINUE ITS INVESTIGATION TO VERIFY THE EXTENT OF THE PROBLEM REPRESENTED BY THE REPORTED FAILURES AND EVALUATE THE ASSOCIATED RISKS.
Additional source detail variants (2)
Exterior Lighting:headlights:switch
ODI HAS RECEIVED SEVERAL FAILED SWITCHES THAT SHOW SIGNS OF MELTING OR DAMAGE FROM OVER- HEATING.THE SWITCH SUPPLIER HAS INITIATED A TEST PROGRAM TO DETERMINE THE CAUSE OF THESE FAILURES.ODI IS CONCERNED ABOUT THE PRESENCE OF A HEAT SOURCE THAT POTENTIALLY COULD LEAD TO AN ELECTRICAL FIRE, AS WELL AS THE ABSENCE OF NECESSARY VEHICLE LIGHTING.ODI WILL CONTINUE ITS INVESTIGATION TO VERIFY THE EXTENT OF THE PROBLEM REPRESENTED BY THE REPORTED FAILURES AND EVALUATE THE ASSOCIATED RISKS.
Interior Lighting
ODI HAS RECEIVED SEVERAL FAILED SWITCHES THAT SHOW SIGNS OF MELTING OR DAMAGE FROM OVER- HEATING.THE SWITCH SUPPLIER HAS INITIATED A TEST PROGRAM TO DETERMINE THE CAUSE OF THESE FAILURES.ODI IS CONCERNED ABOUT THE PRESENCE OF A HEAT SOURCE THAT POTENTIALLY COULD LEAD TO AN ELECTRICAL FIRE, AS WELL AS THE ABSENCE OF NECESSARY VEHICLE LIGHTING.ODI WILL CONTINUE ITS INVESTIGATION TO VERIFY THE EXTENT OF THE PROBLEM REPRESENTED BY THE REPORTED FAILURES AND EVALUATE THE ASSOCIATED RISKS.