IllustrationTHE FUSE THAT GOES TO THE FUEL INJECTORS KEEPS BLOWING, IT ONLY BLOWS HALF OF THE FUSE, EVERY FEW WEEKS, THE CAR WON'T START AND THE FUSE HAS TO BE REPLACED. *TR
2006 Suzuki XL-7
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2006 Suzuki XL-7 do not stand out strongly from the model-year median of 26.
About this comparison →How this year compares
Owner complaints by model year
Compare all XL-7 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 19 of 28 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Air Bags. Review the 10 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Steering. Review the 5 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 3 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
7 crash reports0 fire reports5 injury reports
Electrical System complaints
3 reportsONE DAY WHEN I GO TO START MY CAR WHEN I TURN THE KEY, A STATIC NOISE COMES FROM WHERE THE KEY GOES. VEHICLE STARTED BUT WHILE DRIVING, WOULD LOOSE POWER AND ACT LIKE IT IS GOING TO CUT OFF. *TR
WHEN GETTING ON THE INTERSTATE, CAR SUDDENLY LOST SPEED BUT RPM'S KEPT GOING UP, COULD NOT GO OVER 40, WHEN PULLED OVER, PUT IN PARK BUT ENGINE KEPT REVVING UP. *TR
Official recalls
210V250000 · Steering:hydraulic Power Assist:pump
Jun 9, 2010
SUZUKI IS RECALLING CERTAIN MODEL YEAR MODEL YEAR 2006 GRAND VITARA AND MODEL YEAR 2005-2006 XL-7 VEHICLES. THE TENSION ADJUSTER PULLEY FOR THE DRIVE BELT THAT OPERATES THE POWER STEERING PUMP AND AIR CONDITIONER COMPRESSOR (IF EQUIPPED) HAS AN OUTER PORTION THAT IS MADE OF PLASTIC. REPEATED HEAT STRESS CAN CAUSE THE PLASTIC MATERIAL TO DETERIORATE AND PIECES OF THE PULLEY CAN BREAK OFF.
Consequence & remedy
Consequence: BROKEN PIECES OF THE PULLEY CAN GET CAUGHT BETWEEN THE PULLEY AND THE DRIVE BELT, CAUSING THE DRIVE BELT TO COME OFF AND RESULTING IN THE DRIVER NEEDING INCREASED EFFORT TO STEER THE VEHICLE INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE POWER STEERING PUMP DRIVE BELT TENSION ADJUSTER PULLEY FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JUNE 28, 2010. OWNERS MAY CONTACT SUZUKI AT 1-800-934-0934.
05V452000 · Service Brakes, Hydraulic:foundation Components:disc:rotor
Oct 5, 2005
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH 16-INCH WHEELS, THE FRONT BRAKE DISCS MAY BREAK UNDER SEVERE DRIVING CONDITIONS. THE BREAKAGE CAN OCCUR IN CONDITIONS WHERE THE VEHICLE IS DRIVEN ON A REGULAR BASIS ON EXTREMELY STEEP PAVED DOWN-SLOPES WHILE CONTINUOUSLY APPLYING THE BRAKES.
Consequence & remedy
Consequence: THE FRONT BRAKES MAY BECOME INOPERATIVE AND THE VEHICLE MAY PULL TO ONE SIDE. THIS COULD RESULT IN A CRASH WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL REPLACE THE FRONT BRAKE DISCS ON THESE VEHICLES. THE RECALL BEGAN ON NOVEMBER 10, 2005. THESE VEHICLES ARE LOCATED ON ST. THOMAS ISLAND (VIRGIN ISLANDS). OWNERS MAY CONTACT SUZUKI DEL CARIBE AT 787-622-0600.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.