ON NOV.26, 2008 WHILE DRIVING ON THE FREEWAY @ 70 MPH, I EXPERIENCED A CATASTROPHIC ENGINE FAILURE WITH VIRTUALLY NO ADVANCE WARNING AND HAD TO EXIT THE FREEWAY IMMEDIATELY. AFTER COSTLY TOWING AND REPAIR CHARGES THAT I INCURRED FROM THE SUZUKI DEALERSHIP, I WAS TRAVELING ON THE FREEWAY AGAIN AND THE ENGINE FAILED FOR THE EXACT …
Read full complaint
ON NOV.26, 2008 WHILE DRIVING ON THE FREEWAY @ 70 MPH, I EXPERIENCED A CATASTROPHIC ENGINE FAILURE WITH VIRTUALLY NO ADVANCE WARNING AND HAD TO EXIT THE FREEWAY IMMEDIATELY. AFTER COSTLY TOWING AND REPAIR CHARGES THAT I INCURRED FROM THE SUZUKI DEALERSHIP, I WAS TRAVELING ON THE FREEWAY AGAIN AND THE ENGINE FAILED FOR THE EXACT SAME REASON IT HAD FAILED FOR PREVIOUSLY. I WAS INFORMED BY THE SERVICE DEPT. OF THE SUZUKI DEALERSHIP THAT THE CAUSE OF THE ENGINE FAILURE WAS A BROKEN THERMOSTAT. THEY SUPPOSEDLY REPLACED BOTH HEADS, THERMOSTAT, AND VARIOUS OTHER MAINTENANCE ITEMS WERE DONE AS WELL. FROM THE TIME I RECEIVED MY VEHICLE BACK FROM THE DEALERSHIP UNTIL THE SECOND ENGINE FAILURE WAS 6 DAYS. I DID RECEIVE COPIES OF THE REPAIRS AND SERVICES THAT THEY PERFORMED IF YOU NEED THEM. THANK YOU. *TR
SUZUKI IS RECALLING CERTAIN MODEL YEAR MODEL YEAR 2006 GRAND VITARA AND MODEL YEAR 2005-2006 XL-7 VEHICLES. THE TENSION ADJUSTER PULLEY FOR THE DRIVE BELT THAT OPERATES THE POWER STEERING PUMP AND AIR CONDITIONER COMPRESSOR (IF EQUIPPED) HAS AN OUTER PORTION THAT IS MADE OF PLASTIC. REPEATED HEAT STRESS CAN CAUSE THE PLASTIC MATERIAL TO DETERIORATE AND PIECES OF THE PULLEY CAN BREAK OFF.
Consequence & remedy
Consequence: BROKEN PIECES OF THE PULLEY CAN GET CAUGHT BETWEEN THE PULLEY AND THE DRIVE BELT, CAUSING THE DRIVE BELT TO COME OFF AND RESULTING IN THE DRIVER NEEDING INCREASED EFFORT TO STEER THE VEHICLE INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE POWER STEERING PUMP DRIVE BELT TENSION ADJUSTER PULLEY FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JUNE 28, 2010. OWNERS MAY CONTACT SUZUKI AT 1-800-934-0934.
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH 16-INCH WHEELS, THE FRONT BRAKE DISCS MAY BREAK UNDER SEVERE DRIVING CONDITIONS. THE BREAKAGE CAN OCCUR IN CONDITIONS WHERE THE VEHICLE IS DRIVEN ON A REGULAR BASIS ON EXTREMELY STEEP PAVED DOWN-SLOPES WHILE CONTINUOUSLY APPLYING THE BRAKES.
Consequence & remedy
Consequence: THE FRONT BRAKES MAY BECOME INOPERATIVE AND THE VEHICLE MAY PULL TO ONE SIDE. THIS COULD RESULT IN A CRASH WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL REPLACE THE FRONT BRAKE DISCS ON THESE VEHICLES. THE RECALL BEGAN ON NOVEMBER 10, 2005. THESE VEHICLES ARE LOCATED ON ST. THOMAS ISLAND (VIRGIN ISLANDS). OWNERS MAY CONTACT SUZUKI DEL CARIBE AT 787-622-0600.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2005 Suzuki XL-7 Problems, Complaints & Recalls | Skip That Year
Illustration