Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 2 of 2 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Electrical System. Review the 2 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports0 fire reports0 injury reports
What owners actually said
2 reports
1,304 miles · Apr 11, 2011
Electrical System
TL* THE CONTACT OWNS A 2009 SUZUKI SFV650 MOTORCYCLE. THE CONTACT RECEIVED NOTIFICATION OF NHTSA RECALL CAMPAIGN ID NUMBER: 11V108000 (ELECTRICAL SYSTEM:ALTERNATOR/GENERATOR/REGULATOR). THE DEALER WAS CONTACTED AND ADVISED THAT THE VOLTAGE REGULATOR THAT WAS NEEDED FOR THE REPAIR WAS NOT READILY AVAILABLE AND WOULD BE ORDERED. O…
Read full complaint
TL* THE CONTACT OWNS A 2009 SUZUKI SFV650 MOTORCYCLE. THE CONTACT RECEIVED NOTIFICATION OF NHTSA RECALL CAMPAIGN ID NUMBER: 11V108000 (ELECTRICAL SYSTEM:ALTERNATOR/GENERATOR/REGULATOR). THE DEALER WAS CONTACTED AND ADVISED THAT THE VOLTAGE REGULATOR THAT WAS NEEDED FOR THE REPAIR WAS NOT READILY AVAILABLE AND WOULD BE ORDERED. ONE MONTH LATER, THE CONTACT WAS STILL AWAITING THE ARRIVAL OF PARTS AND STATED THAT THE RECALL REMEDY HAS EXTENDED BEYOND A REASONABLE AMOUNT OF TIME. THE DEALER HAD YET TO CONTACT HIM IN REGARDS TO THE PART BECOMING AVAILABLE AND THE VEHICLE WAS NOT YET REPAIRED. THE FAILURE MILEAGE WAS 1,304.
Suzuki Motor of America, Inc. (Suzuki) is recalling certain model year 2008-2012 AN400, AN400A, DL1000, GSX1300R, 2008-2009 GSF1250S and GSF1250SA, 2008 GSX1300BK and GSX1300BKA, 2008-2010 GSX650F, GSX-R600, GSX-R750, VLR1800, VLR1800T, and 2009-2010 SFV650 and VZ1500 motorcycles. Due to a problem with the circuit board for the regulator/rectifier power module, the motorcycle may not sufficiently charge the battery and the motorcycle may stall.
Consequence & remedy
Consequence: If the engine stalls while riding, there would be an increased risk of a crash.
Remedy: Suzuki will notify owners, and dealers will replace the regulator/rectifier, free of charge. The recall is expected to begin March 4, 2016. Owners may contact Suzuki customer service at 1-800-444-5077. Suzuki's number for this recall is 2A56 to 2A64.
SUZUKI IS RECALLING CERTAIN MODEL YEAR 2008 THROUGH 2010 MOTORCYCLES MANUFACTURED FROM JULY 2007 THROUGH SEPTEMBER 2009, EQUIPPED WITH REGULATOR/RECTIFIER ASSEMBLIES, SUZUKI PART NUMBERS 32800-41F11, 32800-15H10, 32800-05H11, 32800-41G10, 32800-15H00, 32800-18H00, 32800-05G10, 32800-10G10, 32800-05H20, OR 32800-06G01. SOME REGULATOR/RECTIFIER ASSEMBLIES WERE PRODUCED WITH INSUFFICIENT ADHESION BETWEEN THE POWER MODULE (CIRCUIT BOARD) AND THE RECTIFIER CASE THAT CONTAINS A HEAT SINK TO DISSIPATE HEAT. DUE TO INSUFFICIENT ADHESION, HEAT GENERATED ON THE POWER MODULE CIRCUIT BOARD CAN CAUSE THE CIRCUIT BOARD TO DEFORM, AND LIFT OF THE CASE.
Consequence & remedy
Consequence: THIS CONDITION CAUSES EXCESSIVE HEAT ON THE CIRCUIT BOARD AND UNCONTROLLED ELECTRIC CURRENT OUTPUT, WHICH CAN RESULT IN INSUFFICIENT CHARGING CURRENT BEING PROVIDED TO THE MOTORCYCLE BATTERY. THIS CAN CAUSE DISCHARGE OF THE BATTERY AND CAN LEAD TO ENGINE STALLING AND/OR A NO-START CONDITION. ENGINE STALLING WHILE RIDING CAN INCREASE THE RISK OF A CRASH.
Remedy: SUZUKI WILL NOTIFY OWNERS AND SUZUKI DISTRIBUTORS WILL REPLACE THE REGULATOR/RECTIFIER WITH AN IMPROVED PART FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 2, 2011. OWNERS MAY CONTACT SUZUKI AT 1-714-572-1490.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2009 Suzuki SFV650 Problems, Complaints & Recalls | Skip That Year
Illustration