Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 4 of 8 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Electrical System. Review the 3 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Equipment. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports0 fire reports0 injury reports
What owners actually said
8 reports
100,000 miles · Feb 24, 2016
Electrical System
TL* THE CONTACT OWNS A 2011 (NA) SUZUKI HAYABUSA MOTORCYCLE. THE CONTACT STATED THAT THE MOTORCYCLE WAS INOPERABLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE BATTERY HAD BEEN OVERCHARGED AND LEAKED SULPHURIC ACID. AS A RESULT, THE BATTERY AND RECTIFIER NEEDED TO BE REPLACED. THE VEHICLE WAS…
Read full complaint
TL* THE CONTACT OWNS A 2011 (NA) SUZUKI HAYABUSA MOTORCYCLE. THE CONTACT STATED THAT THE MOTORCYCLE WAS INOPERABLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE BATTERY HAD BEEN OVERCHARGED AND LEAKED SULPHURIC ACID. AS A RESULT, THE BATTERY AND RECTIFIER NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V018000 (ELECTRICAL SYSTEM); HOWEVER, THE PART TO DO THE REPAIR WAS NOT AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 100,000. PARTS DISTRIBUTION DISCONNECT. UPDATED 04/14/16*LJ UPDATED 6/6/18*JB
NHTSA ODI #10838037
5,100 miles · Dec 6, 2004
EquipmentStructure
THE BRACKET HOLDING THE TIP OVER SENSOR BROKE. MOTORCYCLE BECAME TOTALLY DISABLED AND STALLED. CONSUMER HAD THE MOTORCYCLE TOWED TO THE DEALER, AND THE MOTORCYCLE WAS REPAIRED AT CONSUMER'S EXPENSE. *AK
NHTSA ODI #10103156
Mileage unknown · Aug 20, 2004
Unknown Or Other
WHILE DRIVING UNDER 30 MPH MY MOTORCYCLE'S CHAIN SNAPPED. MANUFACTURER AND DEALERSHIP WERE CONTACTED. *AK THIS FAILURE CAUSED SIGNIFICANT DAMAGE TO THE UNDER SIDE OF THE BIKE TOTALING $2300. THE CONSUMER PAID FOR THE REPAIR BECAUSE THE MANUFACTURER REFUSED ASSISTANCE. *NM
NHTSA ODI #10080232
Mileage unknown · Aug 14, 2003
Electrical System
THERE WOULD BE A LOUD NOISE COMING FROM THE IGNITION WHEN STARTING UP THE MOTORCYCLE. DEALER NOTIFIED.*AK
NHTSA ODI #10033941
7,500 miles · Jun 2, 2003
Electrical System
I HAVE A 2002 HAYABUSA MOTORCYCLE. ABOUT A MONTH AGO WHEN ATTEMPTING TO START THE BIKE THE STARTER GEAR WOULD SLIP AND I WOULD HEAR AN ABNORMALLY LOUD CLANKING SOUND. FINALLY, I ATTEMPTED TO START THE BIKE AND THE STARTER WOULD NOT ENGAGE, (JUST SPINNING UP). I HAD TO HAVE THE BIKE TOWED ($75) TO THE DEALER WHO IS AWARE OF THE…
Read full complaint
I HAVE A 2002 HAYABUSA MOTORCYCLE. ABOUT A MONTH AGO WHEN ATTEMPTING TO START THE BIKE THE STARTER GEAR WOULD SLIP AND I WOULD HEAR AN ABNORMALLY LOUD CLANKING SOUND. FINALLY, I ATTEMPTED TO START THE BIKE AND THE STARTER WOULD NOT ENGAGE, (JUST SPINNING UP). I HAD TO HAVE THE BIKE TOWED ($75) TO THE DEALER WHO IS AWARE OF THE ISSUE. WHEN I CALLED SUZUKI USA THEY REFUSED TO ACKNOWLEDGE THE ISSUE. AFTER SOME RESEARCH I DISCOVERED THAT THE ISSUE IS DISCUSSED IN TECHNICAL SERVICE BULLETIN 126 ISSUED BY SUZUKI. THEY WILL UPGRADE THE STARTER GEAR PARTS ONLY WHEN FAILURE OCCURS. I FEEL THEY SHOULD ISSUE A RECALL. *AK
NHTSA ODI #10020884
Mileage unknown · May 14, 2002
Service Brakes, Hydraulic
CONSUMER STATES THERE IS BRAKE FLUID IN THE CLUTCH SYSTEM IS CONTAMINATED AND NEEDS TO BE CHANGED. CONSUMER HAS SPOKEN TO DEALER, MECHANIC STATED FLUID DID NOT NEED TO BE CHANGED FOR 2 YEARS. MANUEL STATED SAME INFORMATION, HOWEVER FLUID COMPANY STATED DIFFERENT OPINION.*AK . ALSO THE FRONT BRAKES WERE NOISY.*YH
NHTSA ODI #8009850
10,500 miles · May 1, 2002
Unknown Or Other
(SUZUKI MOTORCYCLE HYABUSA) CONTACTED US SUZUKI, THEY SAID NO RECALL, TAKE TO DEALER TO BE LOOKED AT. * TS *JB ****DIMSII IVOQ ENTRY POSTED AFTER 12-12-02 CUT OVER TO ARTEMIS****761434
NHTSA ODI #10008800
Mileage unknown · Apr 23, 2002
Power Train
THERE IS A FAILURE IN THE SEAL FOR THE CLUTCH ROD. CONTAMINENTS ARE GETTING IN AND DISCOLORING THE DOT 4 BRAKE FLUID. THIS DISCOLORATION IS THE FIRST SIGN OF FAILURE AND YET THE DEALER SAYS TO CHANGE ONLY DURING NORMAL MAINTENANCE, TWO YEARS. THIS SEAL IS UNPROTECTED AND IS SUBJECT TO FAILURE THUS COMPROMISING THE CLUTCH SYST…
Read full complaint
THERE IS A FAILURE IN THE SEAL FOR THE CLUTCH ROD. CONTAMINENTS ARE GETTING IN AND DISCOLORING THE DOT 4 BRAKE FLUID. THIS DISCOLORATION IS THE FIRST SIGN OF FAILURE AND YET THE DEALER SAYS TO CHANGE ONLY DURING NORMAL MAINTENANCE, TWO YEARS. THIS SEAL IS UNPROTECTED AND IS SUBJECT TO FAILURE THUS COMPROMISING THE CLUTCH SYSTEM.*AK
NHTSA ODI #761056
Official recalls
0
No recalls in this snapshot.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2002 Suzuki Hayabusa Problems, Complaints & Recalls | Skip That Year
Illustration