IllustrationPASSENGER AND DRIVER SEATBELT LIGHT STAYS ON. *TR
2006 Suzuki Grand Vitara
Owner reports · Recalls · Investigations
More warning signs than most Grand Vitara years
Owner complaints for the 2006 Suzuki Grand Vitara are substantially higher than the model-year median of 29.
About this comparison →How this year compares
Owner complaints by model year
Compare all Grand Vitara years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
340–25K
3425–50K
3250–75K
1675–100K
14100–150K
2150K+
132 reports with mileage · 29 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Air Bags. Review the 50 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Exterior Lighting. Review the 30 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 26 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
15 crash reports3 fire reports5 injury reports
Seats complaints
10 reportsA HOT DAY OR ANY BAG WEIGHING OVER 5 LBS. WILL TRIGGER THE PASSENGER SEAT SENSOR FOR THE AIR BAG. THE ONLY WAY TO STOP THIS PROBLEM IS TO PERMANENTLY BUCKLE THE PASSENGER SEATBELT. *TR
THE SENSOR BUILT INTO THE PASSENGER SEAT THAT CONTROLS THE AIRBAG IS DEFECTIVE. THE FIX IS A $2000 TOTAL SEAT REPLACEMENT. UNACCEPTABLE. THE CAR THINKS A DOOR OR HATCH IS OPEN AND TURNS THE OVERHEAD LIGHT ON AND OFF ALL THE TIME. ANOTHER SENSOR. YOU HAVE TO BE HOUDINI TO INSTALL A BULB IN THE FRONT LIGHT ASSEMBLY AND THE BULB I…
Read full complaint
THE SENSOR BUILT INTO THE PASSENGER SEAT THAT CONTROLS THE AIRBAG IS DEFECTIVE. THE FIX IS A $2000 TOTAL SEAT REPLACEMENT. UNACCEPTABLE. THE CAR THINKS A DOOR OR HATCH IS OPEN AND TURNS THE OVERHEAD LIGHT ON AND OFF ALL THE TIME. ANOTHER SENSOR. YOU HAVE TO BE HOUDINI TO INSTALL A BULB IN THE FRONT LIGHT ASSEMBLY AND THE BULB IS HELD BY A RINKY DINK CLIP THAT DOESN'T HOLD SO THE FRONT LIGHTS ARE SUBJECT TO GOING OUT. THE CLIP WON'T HOLD THE BULB IN PLACE AND EVEN THE DEALER HAS PROBLEMS WHEN YOUR BULB BURNS OUT OR MANY TIMES JUST BECOMES LOOSE. *TR
SEAT AIRBAG SENSOR FAILURE, AIRBAG CODE LIGHT IN DASH ALWAYS ON, CHEKED IN DEALER, AND THE NO PASSENGER INDICATOR LIGHT IN CONSOLE ALWAYS ON WITH A PASSENGER SIT ON THE SEAT. *TR
PREMATURE FAILURE OF THE PASSENGER RESTRAINT AIR BAG SYSTEM DUE TO FAILURE OF A PRESSURE SENSOR IN THE PASSENGER SEAT. SUZUKI REFUSES TO REPAIR IT AS THEY CONSIDER IT OUT OF WARRANTY AND THE DEALER WANTS $1,200.00 TO REPLACE THE SEAT. *TR
AT APX. 10000 MILES, THE AIR BAG LIGHT CAME ON WITH THE CAR, AND DID NOT GO OUT. TOOK THE VEHICLE TO THE DEALER; WAS INFORMED THAT THE DRIVER'S SIDE AIR BAG WEIGHT SENSOR HAD FAILED IN THE SEAT, AND WOULD BE REPLACED UNDER WARRANTY. AT APX. 25000 MILES, THE AIR BAG LIGHT AGAIN CAME ON. THE CAR WAS NOW OUT OF WARRANTY. I …
Read full complaint
AT APX. 10000 MILES, THE AIR BAG LIGHT CAME ON WITH THE CAR, AND DID NOT GO OUT. TOOK THE VEHICLE TO THE DEALER; WAS INFORMED THAT THE DRIVER'S SIDE AIR BAG WEIGHT SENSOR HAD FAILED IN THE SEAT, AND WOULD BE REPLACED UNDER WARRANTY. AT APX. 25000 MILES, THE AIR BAG LIGHT AGAIN CAME ON. THE CAR WAS NOW OUT OF WARRANTY. I TOOK THE CAR TO THE DEALER, AND WAS INFORMED THAT THE AIR BAG WEIGHT SENSOR IN THE SEAT HAD FAILED, AND NEEDED TO BE REPLACED. WHEN I INFORMED THE SERVICE MANAGER THAT THIS WAS THE SECOND TIME THAT THIS HAD HAPPENED, THEY OFFERED TO REPLACE THE SENSOR FOR $300 DOLLARS. WHICH I PAID FOR. AT APX. 52000 MILES, THE AIR BAG LIGHT CAME ON AGAIN. (IT WAS INTERMITTENT, AS IT WOULD SOMETIMES NOT BE ON) AFTER A FEW MONTHS, WE WERE INVOLVED IN A MINOR ACCIDENT, (STRUCK BY ANOTHER CAR ON REAR QUARTER) WHEN THE CAR WAS REPAIRED, I WAS ASKED ABOUT THE SEATBELT LIGHT; I WAS INFORMED THAT THE DIAGNOSTIC CODE INDICATED A FAILURE OF THE WEIGHT SENSOR. I INFORMED THE REPAIR SHOP AND INSURANCE THAT THE LIGHT WAS NOT DUE TO THE ACCIDENT. WHILE I WAS AT THE SHOP, THE ERROR LIGHT WENT OUT, BUT SUBSEQUENTLY (WITHIN 5 MILES) CAME BACK ON AGAIN. THE SHOP INFORMED ME THAT THE PROBLEM WAS <<<PROBABLY>>> IN THE WIRING HARNESS OR SENSOR CONNECTOR, RATHER THAN THE ACTUAL SENSOR (AS THE PROBLEM WAS INTERMITTENT.) THE CAR HAS NOT BEEN FIXED, AND THE AIR BAG LIGHT IS STILL ON. THAT IS THREE AIR BAG WEIGHT SENSOR RELATED PROBLEMS WITH THE SAME CAR. THIS IS A SAFETY ISSUE, AND IT SEEMS TO BE A PERVASIVE SAFETY ISSUE WITH THE 2006 GRAND VITARA... [IN ADDITION, THE CAR BLOWS THE LOW-BEAM (AND SOMETIMES HIGH BEAM) HEADLIGHTS QUITE OFTEN - MORE THAN ANY OTHER CAR I'VE DRIVEN IN NEARLY 40 YEARS OF DRIVING.] *TR
WE RECENTLY PURCHASED A 2006 SUZUKI GRAND VITARA FROM AN INDIVIDUAL. ON THE WAY HOME THE" PASSENGER SEAT BELT OFF" AND AIR BAG LIGHTS REMAINED ON. WHEN WE TOOK IT TO A SUZUKI DEALER FOR DIAGNOSIS THE RESULTS WAS THE PASSENGER SEAT SENSOR WAS NOT WORKING THEREFORE THE PASSENGER AIR BAGS WERE DISABLED. THE SERVICE MANAGER QUOTE…
Read full complaint
WE RECENTLY PURCHASED A 2006 SUZUKI GRAND VITARA FROM AN INDIVIDUAL. ON THE WAY HOME THE" PASSENGER SEAT BELT OFF" AND AIR BAG LIGHTS REMAINED ON. WHEN WE TOOK IT TO A SUZUKI DEALER FOR DIAGNOSIS THE RESULTS WAS THE PASSENGER SEAT SENSOR WAS NOT WORKING THEREFORE THE PASSENGER AIR BAGS WERE DISABLED. THE SERVICE MANAGER QUOTED $1800. TO $2000. FOR REPLACEMENT. WE ARE VERY DISAPPOINTED TO FIND THIS TO BE A COMMON PROBLEM WITH SUZUKI. *TR
TL*THE CONTACT OWNS A 2006 SUZUKI GRAND VITARA. THE CONTACT STATED THAT WHENEVER A PERSON WAS SITTING IN THE PASSENGER SEAT, THE AIR BAG LIGHT ILLUMINATED. THE PASSENGER SEAT MODULE WAS DEFECTIVE. THE CONTACT HAD TO TURN THE VEHICLE OFF AND RESTART IT TO RESET IT. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHO STATED THAT THE…
Read full complaint
TL*THE CONTACT OWNS A 2006 SUZUKI GRAND VITARA. THE CONTACT STATED THAT WHENEVER A PERSON WAS SITTING IN THE PASSENGER SEAT, THE AIR BAG LIGHT ILLUMINATED. THE PASSENGER SEAT MODULE WAS DEFECTIVE. THE CONTACT HAD TO TURN THE VEHICLE OFF AND RESTART IT TO RESET IT. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHO STATED THAT THEY WOULD COVER 50% OF THE REPAIR COSTS TO REPLACE THE ENTIRE SEAT CUSHION. THE CONTACT CALLED THE MANUFACTURER WHO OFFERED NO ASSISTANCE. THE VIN WAS UNAVAILABLE. THE FAILURE MILEAGE WAS 35,700 AND THE CURRENT MILEAGE WAS 36,600. UPDATED 02/1/11*LJ UPDATED 04/14/11
2006 SUZUKI GRAND VITARA WITH SEVERAL PROBLEMS. CONSUMER STATES THAT THE PROBLEMS ARE: STEERING SHAFT, ENGINE MAKING A KNOCKING NOISE, ENGINE LIGHT ILLUMINATION, GASOLINE ODOR FROM ENGINE AND SEAT WARMER NOT WORKING. *KB THE ENGINE NOISE WAS DUE TO THE CAMSHAFT TIMING BELT WHICH NEEDED TO BE RE-TORQUED. THE PURGE VALVE WAS REP…
Read full complaint
2006 SUZUKI GRAND VITARA WITH SEVERAL PROBLEMS. CONSUMER STATES THAT THE PROBLEMS ARE: STEERING SHAFT, ENGINE MAKING A KNOCKING NOISE, ENGINE LIGHT ILLUMINATION, GASOLINE ODOR FROM ENGINE AND SEAT WARMER NOT WORKING. *KB THE ENGINE NOISE WAS DUE TO THE CAMSHAFT TIMING BELT WHICH NEEDED TO BE RE-TORQUED. THE PURGE VALVE WAS REPLACED DUE TO THE ENGINE LIGHT BEING ON. *JB
THIS HAPPENED DAY AFTER WE BOUGHT VEHICLE. VALVE TAPPING COMING FROM MOTOR AT IDLE. RATTLING NOISE FROM ENGINE AT 50 MPH. PASSENGER HEATED SEAT WORKS 10% OF THE TIME. TOOK VEHICLE TO DEALERSHIP GAVE BACK IN ONE HOUR. THE HELP TICKET STATES NEED TO ORDER PART TO HEAT SEAT AND THEY NEED TO CALL TECH SUPPORT TO RESOLVE TAPPING.…
Read full complaint
THIS HAPPENED DAY AFTER WE BOUGHT VEHICLE. VALVE TAPPING COMING FROM MOTOR AT IDLE. RATTLING NOISE FROM ENGINE AT 50 MPH. PASSENGER HEATED SEAT WORKS 10% OF THE TIME. TOOK VEHICLE TO DEALERSHIP GAVE BACK IN ONE HOUR. THE HELP TICKET STATES NEED TO ORDER PART TO HEAT SEAT AND THEY NEED TO CALL TECH SUPPORT TO RESOLVE TAPPING. I TOOK SUV TWO WEEKS AGO I CALL EVERY OTHER DAY. THEY SAY THEY ARE STILL WAITING FOR TECH SUPPORT AND THEY WANT TO FIX BOTH PROBLEMS AT ONCE. ARE THEY WAITING UNTIL THE MOTOR HAS SERIOUS DAMAGE BEFORE MOVING ON TO FIX IT? *JB
Official recalls
619V187000 · Air Bags:sensor:occupant Classification; Seats
Mar 7, 2019
Suzuki Motor of America, Inc. (Suzuki) is recalling certain 2010-2013 Kizashi and 2006-2013 Grand Vitara vehicles. The front passenger leather seat may shrink due to high humidity and high temperature. As a result, the occupant classification system (OCS) sensor mat may not accurately detect if an adult or child is occupying the seat.
Consequence & remedy
Consequence: In the event of a crash necessitating airbag deployment, an incorrect classification may result in the passenger frontal air bag deploying even if there is a child in the front passenger seat, increasing their risk of injury.
Remedy: Suzuki will notify owners, and dealers will replace the seat bottom cushion, free of charge. Interim owner notification letters were mailed on May 3, 2019. All second letters notifying owners of the remedy were mailed by April 10, 2020. Owners may contact Suzuki customer service at 1-800-934-0934. Suzuki's numbers for this recall are 4011 and 4012.
Additional source detail variants (2)
Air Bags:sensor:occupant Classification
Suzuki Motor of America, Inc. (Suzuki) is recalling certain 2010-2013 Kizashi and 2006-2013 Grand Vitara vehicles. The front passenger leather seat may shrink due to high humidity and high temperature. As a result, the occupant classification system (OCS) sensor mat may not accurately detect if an adult or child is occupying the seat.
Consequence: In the event of a crash necessitating airbag deployment, an incorrect classification may result in the passenger frontal air bag deploying even if there is a child in the front passenger seat, increasing their risk of injury.
Remedy: Suzuki will notify owners, and dealers will replace the seat bottom cushion, free of charge. Interim owner notification letters were mailed on May 3, 2019. All second letters notifying owners of the remedy were mailed by April 10, 2020. Owners may contact Suzuki customer service at 1-800-934-0934. Suzuki's numbers for this recall are 4011 and 4012.
Seats
Suzuki Motor of America, Inc. (Suzuki) is recalling certain 2010-2013 Kizashi and 2006-2013 Grand Vitara vehicles. The front passenger leather seat may shrink due to high humidity and high temperature. As a result, the occupant classification system (OCS) sensor mat may not accurately detect if an adult or child is occupying the seat.
Consequence: In the event of a crash necessitating airbag deployment, an incorrect classification may result in the passenger frontal air bag deploying even if there is a child in the front passenger seat, increasing their risk of injury.
Remedy: Suzuki will notify owners, and dealers will replace the seat bottom cushion, free of charge. Interim owner notification letters were mailed on May 3, 2019. All second letters notifying owners of the remedy were mailed by April 10, 2020. Owners may contact Suzuki customer service at 1-800-934-0934. Suzuki's numbers for this recall are 4011 and 4012.
18V667000 · Steering:hydraulic Power Assist System
Sep 25, 2018
Suzuki Motor of America, Inc. (Suzuki) is recalling certain 2006 Suzuki Grand Vitara vehicles. The power steering pump belt tension adjuster pulley has an outer portion that is made of plastic. Repeated heat stress can cause the plastic material to deteriorate, causing pieces of the pulley to break off.
Consequence & remedy
Consequence: Broken pieces of the pulley can get caught between the pulley and the drive belt, causing the drive belt to come off, resulting in a sudden loss of power steering assist, increasing the risk of a crash.
Remedy: Suzuki will notify owners, and dealers will replace the power steering pump drive belt tension adjuster pulley, free of charge. The recall began November 9, 2018. Owners may contact Suzuki customer service at 1-800-934-0934. Suzuki's number for this recall is 4009. Note: The vehicles included in this recall were not previously recalled under 10V-250.
13V405000 · Air Bags
Sep 6, 2013
Suzuki Motor of America, Inc. (Suzuki) is recalling certain model year 2006-2011 Grand Vitara and 2007-2011 SX4 vehicles. In the affected vehicles, over time, the OCS sensor mat installed in the front passenger seat may fail due to repeated flexing of the mat from use of the seat. As a result, during a crash necessitating deployment, the air bag will deploy regardless of whether the front seat occupant is an adult or a child.
Consequence & remedy
Consequence: Air bag deployment with a child in the front passenger side seat increases the risk of injury to that child.
Remedy: Suzuki will notify owners and dealers will replace the front passenger seat cushion assembly (which includes the OCS sensor mat) free of charge. Sufficient quantities of parts are not currently available to fix all of the affected vehicles. Owners will be notified of the recall in October 2013 and will receive a second notification when parts are available to have their vehicle repaired. The recall began on May 23, 2014. Owners may contact Suzuki at 1-800-934-0934. Suzuki's recall campaign number is VD.
10V250000 · Steering:hydraulic Power Assist:pump
Jun 9, 2010
SUZUKI IS RECALLING CERTAIN MODEL YEAR MODEL YEAR 2006 GRAND VITARA AND MODEL YEAR 2005-2006 XL-7 VEHICLES. THE TENSION ADJUSTER PULLEY FOR THE DRIVE BELT THAT OPERATES THE POWER STEERING PUMP AND AIR CONDITIONER COMPRESSOR (IF EQUIPPED) HAS AN OUTER PORTION THAT IS MADE OF PLASTIC. REPEATED HEAT STRESS CAN CAUSE THE PLASTIC MATERIAL TO DETERIORATE AND PIECES OF THE PULLEY CAN BREAK OFF.
Consequence & remedy
Consequence: BROKEN PIECES OF THE PULLEY CAN GET CAUGHT BETWEEN THE PULLEY AND THE DRIVE BELT, CAUSING THE DRIVE BELT TO COME OFF AND RESULTING IN THE DRIVER NEEDING INCREASED EFFORT TO STEER THE VEHICLE INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE POWER STEERING PUMP DRIVE BELT TENSION ADJUSTER PULLEY FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JUNE 28, 2010. OWNERS MAY CONTACT SUZUKI AT 1-800-934-0934.
07V554000 · Power Train:automatic Transmission:lever And Linkage:column Shift
Dec 7, 2007
CERTAIN VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 114, 'THEFT PROTECTION. ' THE AUTOMATIC TRANSMISSION SELECTOR LEVER "PARK" LOCK FUNCTION MAY BE INOPERATIVE DUE TO A STICKING SHIFT LOCK ARM. THE SHIFT LEVER MAY BE ABLE TO BE SHIFTED OUT OF "PARK" WITH THE KEY REMOVED AND WITHOUT DEPRESSING THE BRAKE PEDAL.
Consequence & remedy
Consequence: THIS CAN GIVE RISE TO INCREASED INCIDENTS OF CRASHES RESULTING FROM THE ROLLAWAY OF PARKED VEHICLES AS A RESULT OF INADVERTENTLY MOVING THE SHIFT LEVER FROM THE "PARK" POSITION WHEN THE PARKING BRAKE IS NOT FULLY ENGAGED.
Remedy: DEALERS WILL REPLACE THE SHIFT LOCK MODULE FREE OF CHARGE. THE RECALL BEGAN ON JANUARY 7, 2008. OWNERS MAY CONTACT SUZUKI AT 1-800-934-0934.
05V548000 · Power Train:driveline:driveshaft
Dec 1, 2005
ON CERTAIN PASSENGER VEHICLES, THE LEFT SIDE OF THE RETAINER REAR DRIVE SHAFT MAY CRACK AND THE GEARS MAY GET STUCK DUE TO OIL LEAKAGE BY THE RETAINER.
Consequence & remedy
Consequence: THIS CAN LEAD TO THE REAR DIFFERENTIAL GEARS LOCKING UP AND THE VEHICLE MAY BECOME DISABLED INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT AND REPLACE THE LEFT SIDE OF THE RETAINER REAR DRIVE SHAFT. SUZUKI WILL CALL OWNERS ON OR ABOUT DECEMBER 15, 2005. FOLLOWUP LETTERS TO OWNERS WERE MAILED ON FEBRUARY 13, 2006. OWNERS MAY CONTACT SUZUKI AT 1-800-934-0934.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE13021 · Occupant Classification System Failure
Opened Jun 14, 2013 · Closed Sep 30, 2013
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:sensor/control MODULE-INACTIVE
Suzuki Motor of America is conducting a safety recall to remedy the occupant classification system's (OCS) sensor mats in approximately 193,936 model year 2006-2011 Suzuki Grand Vitara and 2007-2011 Suzuki SX4 vehicles (see NHTSA recall 13V-405 for more details).The sensor mat installed in the front passenger seat can develop an electrical circuit disconnection as a result of repeated flexing of the seat from use of the seat.According to Suzuki, when the failure occurs, the OCS system, by design, will not suppress the frontal passenger air bag for a seated child or small-stature adult.A deploying passenger air bag can cause serious injury to such an occupant.The recall population excludes those vehicles that previously had proper remedies under the special coverage campaign for this issue (~11,600) that began in July 2012.The recall remedy will be to install a new front passenger seat cushion assembly that includes an improved OCS sensor mat and an OCS control module with updated algorithms designed to properly identify the type/size of the seated occupant.Consequently, this recall action will address various OCS related problems, including a programming error (associated with diagnostic trouble code B1318) related to detecting a change or shifting in load on the front passenger seat in the model year 2009 Grand Vitara and SX4 vehicles.This Preliminary Evaluation is closed.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10178750, 10185778, 10200217, 10200123, 10206368, 10217021, 10250561, 10254251, 10263756, 10283309, 10285166, 10294320, 10316125, 10323718, 10324530, 10326910, 10332645, 10347204, 10348957, 10349038, 10350237, 10353604, 10354901, 10355400, 10364190, 10367631, 10369777, 10371056, 10373558, 10375165, 10375789, 10376071, 10376621, 10378154, 10380794, 10382860, 10392447, 10392434, 10392599, 10393975, 10395430, 10395602, 10395821, 10395983, 10398172, 10400092, 10400035, 10401106, 10401424, 10404772, 10405359, 10406459, 10407500, 10409412, 10409993, 10413235, 10418162, 10419237, 10419578, 10425035, 10425212, 10426703, 10434905, 10435090, 10435091, 10437600, 10437892, 10437994, 10438100, 10438501, 10438613, 10439357, 10439979, 10440088, 10442968, 10442759, 10442883, 10443173, 10443592, 10443594, 10444434, 10445034, 10445447, 10446215, 10446580, 10447689, 10448161, 10448446, 10448499, 10448554, 10449238, 10450746, 10451260, 10452961, 10453168, 10453403, 10453376, 10454445, 10454978, 10455231, 10455529, 10456043, 10456367, 10456407, 10459063, 10460417, 10460510, 10462016, 10463337, 10464941, 10464693, 10467988, 10468641, 10479583, 10479929, 10481120, 10484053, 10484863, 10486369, 10486729, 10487379, 10491755, 10499622, 10506034, 10508282, 10511057, 10511439, 10512962, 10521656, 10521779, 10523512, 10523931, 10524266, 10526435, 10533196, 10535513, 10537314, 10537619, 10543672, 10544287.
Additional source detail variants (3)
Air Bags:frontal:sensor/control MODULE-INACTIVE
Suzuki Motor of America is conducting a safety recall to remedy the occupant classification system's (OCS) sensor mats in approximately 193,936 model year 2006-2011 Suzuki Grand Vitara and 2007-2011 Suzuki SX4 vehicles (see NHTSA recall 13V-405 for more details).The sensor mat installed in the front passenger seat can develop an electrical circuit disconnection as a result of repeated flexing of the seat from use of the seat.According to Suzuki, when the failure occurs, the OCS system, by design, will not suppress the frontal passenger air bag for a seated child or small-stature adult.A deploying passenger air bag can cause serious injury to such an occupant.The recall population excludes those vehicles that previously had proper remedies under the special coverage campaign for this issue (~11,600) that began in July 2012.The recall remedy will be to install a new front passenger seat cushion assembly that includes an improved OCS sensor mat and an OCS control module with updated algorithms designed to properly identify the type/size of the seated occupant.Consequently, this recall action will address various OCS related problems, including a programming error (associated with diagnostic trouble code B1318) related to detecting a change or shifting in load on the front passenger seat in the model year 2009 Grand Vitara and SX4 vehicles.This Preliminary Evaluation is closed.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10178750, 10185778, 10200217, 10200123, 10206368, 10217021, 10250561, 10254251, 10263756, 10283309, 10285166, 10294320, 10316125, 10323718, 10324530, 10326910, 10332645, 10347204, 10348957, 10349038, 10350237, 10353604, 10354901, 10355400, 10364190, 10367631, 10369777, 10371056, 10373558, 10375165, 10375789, 10376071, 10376621, 10378154, 10380794, 10382860, 10392447, 10392434, 10392599, 10393975, 10395430, 10395602, 10395821, 10395983, 10398172, 10400092, 10400035, 10401106, 10401424, 10404772, 10405359, 10406459, 10407500, 10409412, 10409993, 10413235, 10418162, 10419237, 10419578, 10425035, 10425212, 10426703, 10434905, 10435090, 10435091, 10437600, 10437892, 10437994, 10438100, 10438501, 10438613, 10439357, 10439979, 10440088, 10442968, 10442759, 10442883, 10443173, 10443592, 10443594, 10444434, 10445034, 10445447, 10446215, 10446580, 10447689, 10448161, 10448446, 10448499, 10448554, 10449238, 10450746, 10451260, 10452961, 10453168, 10453403, 10453376, 10454445, 10454978, 10455231, 10455529, 10456043, 10456367, 10456407, 10459063, 10460417, 10460510, 10462016, 10463337, 10464941, 10464693, 10467988, 10468641, 10479583, 10479929, 10481120, 10484053, 10484863, 10486369, 10486729, 10487379, 10491755, 10499622, 10506034, 10508282, 10511057, 10511439, 10512962, 10521656, 10521779, 10523512, 10523931, 10524266, 10526435, 10533196, 10535513, 10537314, 10537619, 10543672, 10544287.
Air Bags:frontal
Suzuki Motor of America is conducting a safety recall to remedy the occupant classification system's (OCS) sensor mats in approximately 193,936 model year 2006-2011 Suzuki Grand Vitara and 2007-2011 Suzuki SX4 vehicles (see NHTSA recall 13V-405 for more details).The sensor mat installed in the front passenger seat can develop an electrical circuit disconnection as a result of repeated flexing of the seat from use of the seat.According to Suzuki, when the failure occurs, the OCS system, by design, will not suppress the frontal passenger air bag for a seated child or small-stature adult.A deploying passenger air bag can cause serious injury to such an occupant.The recall population excludes those vehicles that previously had proper remedies under the special coverage campaign for this issue (~11,600) that began in July 2012.The recall remedy will be to install a new front passenger seat cushion assembly that includes an improved OCS sensor mat and an OCS control module with updated algorithms designed to properly identify the type/size of the seated occupant.Consequently, this recall action will address various OCS related problems, including a programming error (associated with diagnostic trouble code B1318) related to detecting a change or shifting in load on the front passenger seat in the model year 2009 Grand Vitara and SX4 vehicles.This Preliminary Evaluation is closed.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10178750, 10185778, 10200217, 10200123, 10206368, 10217021, 10250561, 10254251, 10263756, 10283309, 10285166, 10294320, 10316125, 10323718, 10324530, 10326910, 10332645, 10347204, 10348957, 10349038, 10350237, 10353604, 10354901, 10355400, 10364190, 10367631, 10369777, 10371056, 10373558, 10375165, 10375789, 10376071, 10376621, 10378154, 10380794, 10382860, 10392447, 10392434, 10392599, 10393975, 10395430, 10395602, 10395821, 10395983, 10398172, 10400092, 10400035, 10401106, 10401424, 10404772, 10405359, 10406459, 10407500, 10409412, 10409993, 10413235, 10418162, 10419237, 10419578, 10425035, 10425212, 10426703, 10434905, 10435090, 10435091, 10437600, 10437892, 10437994, 10438100, 10438501, 10438613, 10439357, 10439979, 10440088, 10442968, 10442759, 10442883, 10443173, 10443592, 10443594, 10444434, 10445034, 10445447, 10446215, 10446580, 10447689, 10448161, 10448446, 10448499, 10448554, 10449238, 10450746, 10451260, 10452961, 10453168, 10453403, 10453376, 10454445, 10454978, 10455231, 10455529, 10456043, 10456367, 10456407, 10459063, 10460417, 10460510, 10462016, 10463337, 10464941, 10464693, 10467988, 10468641, 10479583, 10479929, 10481120, 10484053, 10484863, 10486369, 10486729, 10487379, 10491755, 10499622, 10506034, 10508282, 10511057, 10511439, 10512962, 10521656, 10521779, 10523512, 10523931, 10524266, 10526435, 10533196, 10535513, 10537314, 10537619, 10543672, 10544287.
Air Bags
Suzuki Motor of America is conducting a safety recall to remedy the occupant classification system's (OCS) sensor mats in approximately 193,936 model year 2006-2011 Suzuki Grand Vitara and 2007-2011 Suzuki SX4 vehicles (see NHTSA recall 13V-405 for more details).The sensor mat installed in the front passenger seat can develop an electrical circuit disconnection as a result of repeated flexing of the seat from use of the seat.According to Suzuki, when the failure occurs, the OCS system, by design, will not suppress the frontal passenger air bag for a seated child or small-stature adult.A deploying passenger air bag can cause serious injury to such an occupant.The recall population excludes those vehicles that previously had proper remedies under the special coverage campaign for this issue (~11,600) that began in July 2012.The recall remedy will be to install a new front passenger seat cushion assembly that includes an improved OCS sensor mat and an OCS control module with updated algorithms designed to properly identify the type/size of the seated occupant.Consequently, this recall action will address various OCS related problems, including a programming error (associated with diagnostic trouble code B1318) related to detecting a change or shifting in load on the front passenger seat in the model year 2009 Grand Vitara and SX4 vehicles.This Preliminary Evaluation is closed.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10178750, 10185778, 10200217, 10200123, 10206368, 10217021, 10250561, 10254251, 10263756, 10283309, 10285166, 10294320, 10316125, 10323718, 10324530, 10326910, 10332645, 10347204, 10348957, 10349038, 10350237, 10353604, 10354901, 10355400, 10364190, 10367631, 10369777, 10371056, 10373558, 10375165, 10375789, 10376071, 10376621, 10378154, 10380794, 10382860, 10392447, 10392434, 10392599, 10393975, 10395430, 10395602, 10395821, 10395983, 10398172, 10400092, 10400035, 10401106, 10401424, 10404772, 10405359, 10406459, 10407500, 10409412, 10409993, 10413235, 10418162, 10419237, 10419578, 10425035, 10425212, 10426703, 10434905, 10435090, 10435091, 10437600, 10437892, 10437994, 10438100, 10438501, 10438613, 10439357, 10439979, 10440088, 10442968, 10442759, 10442883, 10443173, 10443592, 10443594, 10444434, 10445034, 10445447, 10446215, 10446580, 10447689, 10448161, 10448446, 10448499, 10448554, 10449238, 10450746, 10451260, 10452961, 10453168, 10453403, 10453376, 10454445, 10454978, 10455231, 10455529, 10456043, 10456367, 10456407, 10459063, 10460417, 10460510, 10462016, 10463337, 10464941, 10464693, 10467988, 10468641, 10479583, 10479929, 10481120, 10484053, 10484863, 10486369, 10486729, 10487379, 10491755, 10499622, 10506034, 10508282, 10511057, 10511439, 10512962, 10521656, 10521779, 10523512, 10523931, 10524266, 10526435, 10533196, 10535513, 10537314, 10537619, 10543672, 10544287.