IllustrationDT*: THE CONTACT STATED THE REAR TIRE ON THE VEHICLE HAD ABNORMAL WEAR. THE CONTACT NOTICED THE TIRE HAD WORN THROUGH TO THE CORD ON THE LEFT SIDE. THE TIRE HAS NOT BEEN SEEN BY A MECHANIC, IT WAS REMOVED FROM THE VEHICLE.
2003 Suzuki AN650 Burgman
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all AN650 Burgman years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 5 of 5 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Power Train. Review the 3 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel/propulsion System. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports0 fire reports0 injury reports
Tires complaints
1 reportsOfficial recalls
105V372000 · Electrical System:ignition:switch
Aug 29, 2005
ON CERTAIN SCOOTERS, IF THE IGNITION SWITCH IS NOT FULLY TURNED FROM THE 'OFF' TO THE 'ON' POSITION, THERE MAY BE UNSTABLE CONTACT BETWEEN THE IGNITION SWITCH CONTACTS. THIS CAN CAUSE ARCING IN THE IGNITION SWITCH.
Consequence & remedy
Consequence: HEAT FROM THE ARCING CAN MELT THE INTERNAL SWITCH BASE PLATE. IF THE SCOOTER IS RIDDEN IN THIS CONDITION, THE IGNITION SWITCH MAY FAIL. IF THIS HAPPENS, THE ENGINE WILL STALL, THE LIGHTS WILL GO OUT, AND THE OPERATOR MAY BE UNABLE TO RESTART THE SCOOTER. THIS COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE IGNITION SWITCH TERMINAL CASE ASSEMBLY FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 7, 2005. OWNERS MAY CONTACT SUZUKI AT 1-800-255-2550.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.