2021 Subaru Outback

The component that has failed twice is the windshield. They current windshield is available for inspection but not the first. In fact, I am taking it my Subaru dealer tomorrow so they can look at it. This is the second windshield in 13 months that has failed. The first one became heavily pitted across the entire windshield. This one has a crack starting from the passenger side, 2/3 of the way up and then continues 1/3 of the way towards the driver. I do not recall any impact on the windshield prior to the crack occurring. I am concerned about the frequency of this model's windshield issues and whether it can stay intact. As noted above, this problem has happened twice for me. I posted my concerns on Reddit to see if other owners of this vehicle are having issues and I have received numerous responses that others are also having quality issues and those issues are similar to mine. There was no warning prior to the issues with my windshield. It is interesting to note that Subaru had a class action lawsuit against them just a few years ago related to this very same issue with the windshields. I am concerned that the windshield issues have not been adequately addressed.

The contact owns a 2021 Subaru Outback. The contact stated that there was a crack on the windshield. There was no impact to the windshield that could have caused the crack. The vehicle was taken to the dealer and diagnosed that a rock chipped the windshield. The dealer informed the contact that the windshield crack was not covered under warranty. The manufacturer was made aware of the failure but denied the claim for the windshield replacement. The vehicle was not repaired. The failure mileage was approximately 19,000.

Front Windshield crack so easily that I have to replace it two times already. The first time the windshield crack from using the defrost in the snow, and the second time was a small rock while I was driving on the highway. I've driven many cars in the past and have had rocks strike my windshield all the time and never experienced anything like this. I'm surprised the windshield recall isn't extended to the 2021 model Outback yet.

While driving down the interstate, no other vehicles in sight, heard a pop and immediately a crack formed in the windshield (at the bottom in the exact middle of the glass) which spread vertically and has since branched out horizontally. A matter of seconds before this happened, I engaged the defrost button. This is the SECOND windshield to crack spontaneously since I purchased the vehicle in December 2020. The first replacement was proven to not installed properly and Subaru paid for the replacement. As the crack continues to grow, I feel my safety could be affected if the EyeSight features fail as a result of this issue not being addressed.

The front windshield on the passenger side cracked for not apparent reason. The vehicle had been parked in my carport all was fine. Next morning upon entering the vehicle I noticed the crack. Within 2 days the longest crack had grown from about 2 inches towards the drivers side to about 10 inches. I called Subaru of America customer service with a complaint. They suggested taking it to the dealer for inspection and a determination if it’s covered under the new car warranty. I have had the vehicle for about a year and it has less than 15000 miles on the odometer.

The passenger air bag alert on the dashboard indicates the air bag is off when my wife who is elderly and weighs approximately 95 pounds is seated in the front passenger seat .Sometimes it changes to " air bag on" during our journey but other times it remains off .I am concerned the air bag won't deploy in the event of a crash potentially causing serious injury .I have e mailed sales representative who sold us the car at Maple Hill Auto Group Kalamazoo ,MI in March 2021 who responded that seat sensor was designed to alert "off " at 65 pounds or less .Two subsequent e mails to Subaru Customer Service about this issue have not been acknowledged or generated any response which concerns me . At this point car has not been tested by technician as my wife is frail and not in position to go to dealer for demo . Not sure what next steps to take since Subaru Customer Service is not responding to my concerns .

The Subaru Eyesight system malfunctioned while I was driving. All Eyesight components were enabled at the time of the incident, including pre collision braking and forward collision warning. I had been stopped at a red light at a four way intersection. I was the first car waiting at the red light, with other cars behind me and to each side. The intersection had multiple lanes in each direction. There were four lanes going the direction I was driving, and I was in the second from the right. When the traffic light turned green, I took my foot off the brake and onto the gas to begin accelerating. I accelerated through the large intersection reaching approximately 20 miles per hour. The speed limit is 25 or 30 there so I was continuing to accelerate to that speed and was just about through the intersection when the pre collision braking suddenly engaged with no warning at all. My foot was still on the gas trying to accelerate when this happened. All of the lights that show on the windshield seemed to light up red, and it showed that the pre collision braking had engaged on the dashboard screen behind the steering wheel. The car came to an immediate stop in the middle of the road and would not move forward. I took my foot off the gas and my car would still not move. My dashboard said something along the lines of “firmly press brake to hold stop.” I hit the brake, then everything returned to normal and I could move forward. I moved forward, safely switched to the right lane and pulled into the nearest driveway to get off the road and park. I then disabled all Eyesight features and called my Subaru dealership who said they will “diagnose and recalibrate” the system on 1/14/2022. My car and windshield were clean and my windshield is the same from the factory with no defects. No cars were in front of my- the road ahead was wide open, clear, flat, and straight. No one turned in front of me or anything. Fortunately I was not rear ended but it was very scary and dangerous.

The contact owns a 2021 Subaru Outback. The contact stated while driving 50 MPH approaching a traffic light, the contact heard an abnormal cracking sound coming from the front windshield. The contact noticed a small crack on the driver’s side of the windshield that spread to the middle of the windshield. The contact took the vehicle to a local dealer who stated that the failure was related to a thinner OEM breakable glass on the vehicle that needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 6,400.

Fragile windshield. I’m just under a year of ownership and I replaced the windshield twice so far so I’m on my third one. First time was about a month in, no visible strike mark. Started on the Driver side halfway up and spread daily horizontally towards the passenger side and within a day or two was half the windshield. Second one was nine or 10 months out. Tiny strike basically did the same spread. In traffic a tiny rock got tossed up at low speed and I have a Starbust right now. Hopefully it won’t spread overnight before I can get it epoxied because then I will be on my fourth windshield before one year of ownership. Decades of other models and cars and same driving locations and I’ve never had to replace a windshield or repair one. Currently at 16K miles.