I am filing this complaint regarding multiple serious safety defects in my 2021 Subaru Outback purchased in July 2021, currently at 48000 miles THERMO CONTROL VALVE FAILURE (26,307 miles) While traveling in the center lane on [XXX] southbound in [XXX] the evening of 1/6/2024 my vehicle suddenly experienced a complete loss of…
Read full complaint
I am filing this complaint regarding multiple serious safety defects in my 2021 Subaru Outback purchased in July 2021, currently at 48000 miles THERMO CONTROL VALVE FAILURE (26,307 miles) While traveling in the center lane on [XXX] southbound in [XXX] the evening of 1/6/2024 my vehicle suddenly experienced a complete loss of control. It seemed that the car was accelerating and braking at the same time without driver input making it impossible to operate safely. It started shaking and several lights were illuminated on the dashboard, power steering was not working. The car coasted to the right shoulder and starlink was used to call for help. The car was towed to the dealership for repairs. The diagnosis was a failed thermo control valve and related sensor circuit. There were no dashboard lights before the incident that fore shadowed this event. This failure rendered the vehicle completely inoperable at highway speed and posed and extreme risk to the safety of the driver, passenger and other motorists. I am aware that Subaru has extended the warranty on the thermo controls valve to 15 years/150000 miles for 2020-2022 Outback’s which suggests that Subaru had knowledge of the defect. Since the incident several other premature “wear” defects have presented under 48000 miles on a 2021 vehicle: - 41,402 miles: driver side rear strut replaced - 41,402 miles: rear brake pads and rotors - 41,402 miles: driver side front window motor, regulator and run Chanel - 41808 miles: rear knuckle assembly, rear wheel bearing and backing plate replaced - 45,768 miles: front brake pads and and rotors replaced - 48,000 miles: complete exhaust system - 48,000 miles: passenger side front window motor, regulator and run chanel This vehicle has proven to be uncharacteristically unreliable for a Subaru Outback. The intended use for this vehicle is for my children to drive to college nearly 600 miles from home in the fall. This car is not appropriate for this purpose. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION
NHTSA ODI #11735647
Mileage unknown · Apr 11, 2024
SteeringSuspensionWheels
The car was built & sold new, with the rear suspension not aligned properly, and cannot be aligned to factory specifications. The car has been taken to 4 service stations, 3 Subaru dealer service repair shops, without being able to be aligned.after further investigation, I’ve found this to be a common problem for this vehicle t…
Read full complaint
The car was built & sold new, with the rear suspension not aligned properly, and cannot be aligned to factory specifications. The car has been taken to 4 service stations, 3 Subaru dealer service repair shops, without being able to be aligned.after further investigation, I’ve found this to be a common problem for this vehicle type. I consider this Safety related due to the unusual tire wear & risk of tire failure.
Subaru of America, Inc. (Subaru) is recalling certain 2020-2022 Outback and Legacy vehicles. A capacitor in the sensors for the Occupant Detection System (ODS) may crack and short circuit, which can prevent the front passenger air bag from deploying in a crash.
Consequence & remedy
Consequence: An air bag that does not deploy during a crash can increase the risk of injury.
Remedy: Dealers will replace the ODS sensors on the front passenger seat, free of charge. Owner notifications were mailed February 3, 2025. Owners may contact Subaru customer service at 1-844-373-6614. Subaru's number for this recall is WRA-24.
Subaru of America, Inc. is recalling certain model year 2021 Crosstrek, 2022 Forester, 2021-2023 Legacy, and Outback vehicles. An insufficient weld may allow water to enter the inhibitor switch, causing it to fail.
Consequence & remedy
Consequence: An inoperative inhibitor switch may prevent the reverse lights from illuminating and the rearview camera image from displaying, increasing the risk of a crash.
Remedy: Dealers will replace the inhibitor switch, free of charge. Owner notification letters were mailed January 8, 2024. Owners may contact Subaru customer service at 1-800-782-2783. Subaru's number for this recall is WRQ-23.
Subaru of America, Inc. (Subaru) is recalling certain 2020-2021 Outback and Legacy vehicles. A programming error in the Transmission Control Unit (TCU) may allow the clutch to engage before the drive chain is completely clamped.
Consequence & remedy
Consequence: An improperly secured drive chain may slip and break, causing a loss of drive power and increasing the risk of a crash.
Remedy: Dealers will reprogram the TCU, inspect TCU data for chain slip, and visually inspect the chain guide. If evidence of chain slippage or damage is found, the transmission will be replaced. Repairs will be performed free of charge. Owner notification letters are expected to be mailed August 24, 2022. Owners may contact Subaru's customer service at 1-844-373-6614. Subaru's number for this recall is WRK-22. This recall is an expansion of previous recall number 21V-955.
Additional source detail variants (2)
Power Train:driveline:chain/belt
Subaru of America, Inc. (Subaru) is recalling certain 2020-2021 Outback and Legacy vehicles. A programming error in the Transmission Control Unit (TCU) may allow the clutch to engage before the drive chain is completely clamped.
Consequence: An improperly secured drive chain may slip and break, causing a loss of drive power and increasing the risk of a crash.
Remedy: Dealers will reprogram the TCU, inspect TCU data for chain slip, and visually inspect the chain guide. If evidence of chain slippage or damage is found, the transmission will be replaced. Repairs will be performed free of charge. Owner notification letters are expected to be mailed August 24, 2022. Owners may contact Subaru's customer service at 1-844-373-6614. Subaru's number for this recall is WRK-22. This recall is an expansion of previous recall number 21V-955.
Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
Subaru of America, Inc. (Subaru) is recalling certain 2020-2021 Outback and Legacy vehicles. A programming error in the Transmission Control Unit (TCU) may allow the clutch to engage before the drive chain is completely clamped.
Consequence: An improperly secured drive chain may slip and break, causing a loss of drive power and increasing the risk of a crash.
Remedy: Dealers will reprogram the TCU, inspect TCU data for chain slip, and visually inspect the chain guide. If evidence of chain slippage or damage is found, the transmission will be replaced. Repairs will be performed free of charge. Owner notification letters are expected to be mailed August 24, 2022. Owners may contact Subaru's customer service at 1-844-373-6614. Subaru's number for this recall is WRK-22. This recall is an expansion of previous recall number 21V-955.
Subaru of America, Inc. (Subaru) is recalling certain 2021 Outback and Impreza vehicles. The continuously variable transmission (CVT) select lever cable nut may not have been tightened properly, allowing the nut to loosen.
Consequence & remedy
Consequence: A loose nut can lead to a lost of retention in the CVT select lever cable and the gear selector not functioning properly, increasing risk of crash.
Remedy: Subaru will notify owners, and dealers will inspect, and, if necessary, tighten the nut, free of charge. The recall began February 12, 2021. Owners may contact Subaru customer service at 1-844-373-6614. Subaru's number for this recall is WRA-21.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration