2021 Subaru Outback

I am reporting a serious and intermittent steering safety issue with my 2021 Subaru Outback. On two separate occasions, the vehicle suddenly lost what appeared to be power-steering assistance while the vehicle was in motion, causing the steering wheel to become extremely difficult to turn. The first incident occurred while I was driving on the highway and going down a ramp. The steering suddenly became extremely difficult to operate and a warning symbol illuminated on the dashboard. I was able to maintain enough control of the vehicle to safely pull over to the side of the road. I turned the vehicle off and restarted it, and the warning light disappeared and normal steering operation returned. The second incident occurred while I was making a turn into a neighbor. The same problem occurred: the steering suddenly became extremely difficult to turn and a warning light appeared on the dashboard. After turning the vehicle off and restarting it, the steering returned to normal. The intermittent nature of this problem is concerning because restarting the vehicle temporarily restores normal steering, but the failure has now occurred more than once without warning. One of the incidents occurred while traveling on the highway, creating a significant risk of loss of vehicle control and a collision. I am concerned that this may involve the vehicle’s electric power-steering system or related electrical components. I am reporting this to NHTSA because a sudden loss of steering assistance while a vehicle is moving presents a serious safety risk, particularly while turning or traveling at highway speeds. I am requesting that NHTSA document this complaint and evaluate whether similar steering failures have been reported by other owners of 2021 Subaru Outback vehicles.

My 2021 Subaru Outback suffered a failure of the Oil Control Valve (OCV), a sealed Subaru component with no maintenance interval, no inspection procedure, and no preventative service. This failure allowed engine oil to migrate into multiple wiring harnesses and modules, causing extensive electrical contamination. This is not normal wear and tear. It is a latent defect in a Subaru component. Due to the failure of this sealed component the Subaru dealership and a second independant shop have recommended replacing the entire electrical wiring harness at over and estimated $15,000. Even if the entire harness is repalaced the extensive contamination may find its way into electrical connectors even after replacement of the harness. The fact that this contamination was so wide spread, and there were absolutly no warnings that indicated the widespread contamination is alarming. I guess the thought is that different electrical components could just stop working. This seems like a serious safety concern. It is impossible to know how long the contamination was spreading through the car since there are no errors or warnings that indicated an issue.

First battery drain in car. Bought a new battery and it drained again for the second time. Called Suburu to ask about a parasitic drain from the DCM and they said it was likely that and told me to call Suburu America. Did that but they wanted me to take it to a Suburu dealer to get the problem verified. I don’t have the $ to do that. I notice there is a class action in court right now for this exact problem.

We are VERY concerned about the failure of some very important safety features of our 2021 Subaru Outback Touring Edition. We were involved in a bad car accident caused by a person under the influence who was in handcuffs when we were taken away by ambulance. As you can see by the photos, there was MAJOR damage to the other car and significant damage to ours. What is most concerning is the fact that NONE of the airbags deployed and the safety and security plan also failed - it did not call 911. I had to find my phone on the floorboard and call 911 myself. I am not sure if the insurance company will call it a total loss but I really don't think I want the car back BECAUSE of the failures of these very important safety features. I truly feel like Subaru has some explaining to do on this.

I am filing this complaint regarding multiple serious safety defects in my 2021 Subaru Outback purchased in July 2021, currently at 48000 miles THERMO CONTROL VALVE FAILURE (26,307 miles) While traveling in the center lane on [XXX] southbound in [XXX] the evening of 1/6/2024 my vehicle suddenly experienced a complete loss of control. It seemed that the car was accelerating and braking at the same time without driver input making it impossible to operate safely. It started shaking and several lights were illuminated on the dashboard, power steering was not working. The car coasted to the right shoulder and starlink was used to call for help. The car was towed to the dealership for repairs. The diagnosis was a failed thermo control valve and related sensor circuit. There were no dashboard lights before the incident that fore shadowed this event. This failure rendered the vehicle completely inoperable at highway speed and posed and extreme risk to the safety of the driver, passenger and other motorists. I am aware that Subaru has extended the warranty on the thermo controls valve to 15 years/150000 miles for 2020-2022 Outback’s which suggests that Subaru had knowledge of the defect. Since the incident several other premature “wear” defects have presented under 48000 miles on a 2021 vehicle: - 41,402 miles: driver side rear strut replaced - 41,402 miles: rear brake pads and rotors - 41,402 miles: driver side front window motor, regulator and run Chanel - 41808 miles: rear knuckle assembly, rear wheel bearing and backing plate replaced - 45,768 miles: front brake pads and and rotors replaced - 48,000 miles: complete exhaust system - 48,000 miles: passenger side front window motor, regulator and run chanel This vehicle has proven to be uncharacteristically unreliable for a Subaru Outback. The intended use for this vehicle is for my children to drive to college nearly 600 miles from home in the fall. This car is not appropriate for this purpose. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION

This 021' outback XXX purchased in 023'/ 24k Mi Freehold subaru. freehold NJ 'if purchased new would've been on the desk of a local lemon law attorney by now. Over the few years the lock unlock function of key fobs stubbornly, randomly & repeadedly dont work. Freehold subaru saw no problem. Front passenger window months ago wouldn't go up. Freehold subaru supposed repaired at a cost to me. Recent cold weather with a brand new battery of 6 Mos old rendered the car unable to start or boost. Vehicle towed to Freehold tire center st freehold NJ, replaced a $400 battery. brought the 6 mo. old battery back to auto zone who load tested and advised nothing Wrong w battery? Not to mention the sub standard BS feature of coming to a stop, foot on brake & engine stopping-starting when proceeding? this is something of concern of being rolled over by an approaching truck in the rear of this 021' outback because 3 times when stopping at a red light the engine shut off and when proceeding, foot off the brake the engine wouldn't re-start & all the indicators on instrument cluster lit up, had to restart the car. Recent event where my wife, [XXX] old legally disabled- primary driver comes out of a store, starts the outback, puts in reverse to back out of a spot and the car dies. This vehicle is being brought into Freehold subaru south st. Freehold NJ Tues morning Apr. 21st 026' south st and is not being picked up due to it being unsafe to operate. Until all the issues are corrected. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

On 10/29/25 the car lost power once it got to 3500rpm. Multiple warning lights came on. On 11/06/2025, the Thermo Control Valve, high pressure fuel line, and gaskets for intake manifold and EGR were replaced. On 11/24/25, when backing up slowly in a small parking lot, the rear camera detection picked up a raised cement walkway with metal railing. The brake was applied by the driver, however the car accelerated quickly and slammed into the railing and cement. The vehicle was placed into drive after the collision and continued normally. The brake was on once the warning light beeped and prior to the collision. The foot was not removed from the brake pedal until it was in drive. It could not have been placed into drive without the brake pedal being pressed. I asked the dealership if they could pull data from the car at the time of the incident, and was told they weren't sure they would get any information. It has not been inspected by a dealership or insurance. There was no damage done to the cement and railing was already bent. Only the car sustained damage.

Sunroof exploded driving home in 90 degree sunny and clear weather. It sounded like a gun went off right over my head. It scared me so bad I jerked my steering wheel into the other lane. Thank God no one was in that lane. I had to get it replaced at Mid State Glass company. according to what I found on the internet this happens rather frequently. No notification by Subaru that this was even a possibility. I have the receipt the replaced sunroof and photos of the sunroof after it exploded.