2020 Subaru Outback

The windshield has cracked every year since I purchased the vehicle in May 2020. I fortunately bought the insurance but that only covers the windshield once a year. The windshield cracks within a month or two of replacing every single year. The cracks generally start from the edge of the windshield and there is no indication that it was hit be a rock as the start of the crack is clean. There have been two incidents where I heard a pop prior to the start of the crack. I am currently on my fourth windshield.

This vehicle is equipped with a driver monitoring system. This system will flash warnings and activate audible alarms directing the driver to keep his/her eyes on the road. At times this system malfunctions and blares warning after warning non-stop to keep eyes on the road when in fact the driver is absolutely looking straight ahead giving the road and traffic full attention. This erroneous non-stop alarm is distracting to the driver and will continue non-stop. Mostly the alarm can be ended by stopping the vehicle and shutting it off and then restarting the vehicle. The distracting nature to the driver is not the only issue. Is that false driver attention alarm being recorded to some black box to be recovered by any investigator, law enforcement or otherwise? If I should be in an accident while the vehicle erroneously has recorded that the driver was not attentive, then in fact I was, how could I prove otherwise? After all, the computer said otherwise. Once, the alarm begins, there is no way to safely stop the vehicle on the interstate, rush hour beltways and such. There is no way to safely stop the vehicle and turn off the ignition. My vehicle electronic system has been updated several times under the warranty period, yet this erroneous distracting safety alarm persists on an intermittent basis. I never know when. it is going to happen. There is reference in the manual to turning the system off, however I question whether just the alarm is turned off and the false data is till being recorded for anyone to find and place me in jeopardy should an accident occur. This is a known problem discussed in multiple forums and discussion groups. This has been and intermittent problem since 2020.

This was December2023Clicking noise when turning. "Rear swaybar bushing replaced (have gap in them when loaded)" also replaced 2 front Axle/CV Boots. Said they were worn. Additionally today, 5/3/2024 got in my car and there is a crack in my windshield that occurred overnight. Crack comes from bottom corning on drivers side up about 12 inches.

Windshield developed crack without impact. Crack runs from the bottom of windshield in front of steering wheel up to the middle of the windshield, impairing visibility. This is the fourth failed windshield on this vehicle within 4 years and 60,000 miles. Average lifespan of windshield on this car is less than 12 months. Previous windshields cracked with minor hits from pebbles at highway speeds. Windshield has not been inspected by manufacturer, police, or insurance representatives, but is available for inspection.

Have had to replace front windshield 4 times in less than two (2) years due to windshield being cracked by small debris from other vehicles passing by. These have been very minor rocks that have hit the windshield with three of the times it occurred at less than 40 mph. One occurred when I was driving in a residential area at 20 mph. One event occurred spontaneously overnight with the car sitting inside an enclosed garage. Took a picture of the latest event. Concerned that if the window cracks that easy, what would happen if I am in an accident. Subaru is aware of the problem. Windshields have not been inspected by others. No warning lamps, messages, et cetera are related to these events. Review of web comments reveal that it is not an isolated event. Seems to be a design issue and how their Eyesight system affects the windshield design.

Thermostat Replacement: THERMO CONTROL VALVE IS NOT OPERATING. FLUID IS LEAKING FROM ASSEMBLY. The thermostat is a valve that keeps coolant circulating in the engine until it reaches normal running temperature. When this happens, the thermostat opens and allows coolant to flow to the radiator. There were no warnings before this occurred and my car could have overheated. After talking to multiple subaru outback owners, this issue seems to be predominant and am surprised it is not covered by Subaru or that the NTSHA has been warned of this issue.

The contact owns a 2020 Subaru Outback. The contact stated while driving at an undisclosed speed, the contact became aware that there was a large crack on the windshield going across the front windshield. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 59,000.

Later today I am getting my 4th windshield, maybe my 5th, I don’t remember. There is something wrong With these windshields. Nothing more than a small pebble has hit the windshield to cause the cracks and honestly that was only one incident. All the rest happened for no apparent reason. Again, my fourth or fifth windshield. This is ridiculous.