2020 Subaru Outback

I am reporting defective windshield. I’ve had windshield replaced 3 times when just the tiniest pebble tinged. My daughter also has a Subaru Outback and 3 windshields replaced. There must be a defect. Now that we have replaced the windshield several times, State Farm insurance has dropped us because of the number of claims. Most definitely a danger when a tiny people shatters the glass and pieces of the glass hit your face and eyes. If there is another agency I should report this, kindly let me know. Regards, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

- Infotainment center freezes making controls inaccessible. I live in the desert where temps reach 120+ in the car and not being able to turn on the AC is dangerous. - Windows will not roll up once they are rolled down, especially after it has rained or after washing the car. - Driver side Door Sensor Switch broke. This would keep the interior lights and infotainment center from turning off.

I noticed when the weather is wet, closing the front windows is slow. This kept advancing and now it won't close at all. Today, 12/28/2023 it wouldn't even come up more than half an inch then goes back down. Done some online research, and lots of people are reporting this with several Subaru models and dealers only say it needs lubrication.

The contact owns a 2020 Subaru Outback Premium. The contact stated that while the vehicle was parked in the garage, the contact noticed the front windshield was fractured. The contact stated that the crack was in the middle of the windshield which was the same area that the previous windshield fracture had occurred. The contact stated that the front windshield had been replaced two times previously due to the same failure and this incident is the third occurrence. The vehicle was taken to the dealer and the contact was informed that the failure was due to the windshield glass being too thin. The vehicle was not repaired. The manufacturer was made aware of the failure and a case was filed. The failure mileage was approximately 39,000

On 12/6/2023, as I slowly turned right into a parking space, my car suddenly surged forward and accelerated without my input to the gas pedal. The brakes did not work, and there was no resistance from the brake pedal when I repeated to push it. The car continued to accelerate for about 80 ft as I focused on steering to avoid hitting other cars parked in the lot. The car ran over a curb, up a grassy area, and crashed into a row of trees. The airbag did not deploy. I sustained neck muscle strain/whiplash, and bruises to my chest and right knee. My safety was at risk, as well as anyone or anything that was in the car's path since I had no control over the acceleration or the brakes. The car is a 2020 Subaru Outback with about 44000 miles. It is in a body shop and they have not yet determined if it is safe to work on. So far, they have observed the engine race when the car was turned on. There were no warning signs prior to the acceleration. When I called the Subaru dealer service department, I was told that they never heard of this before and it had to have been my fault. They said I could bring it in after the body damage is repaired, and that I can pay for a diagnotic report. However, they expect that the report will not show anything.

Thermo Control Valve assembly has failed resulting in loss of use for the following: Rear Automatic Brake, Eye Sight lane keeping, loss of heat in cabin and failure of coolant to circulate within engine possibly leading to engine failure, loss of cruise control and check engine light coming on. Reference TSB [XXX] . Without cabin heat vehicle is not useable in current cold temperatures (Currently 22 degrees Fahrenheit in Ohio on December 14, 2023). Dealer has confirmed part failure. Issue must be addressed to continue operating vehicle so I paid $1185.87 out of pocket to repair. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

A well-known failure of the Thermal Control Valve (TCV) occurred, which disabled many or most of the safety features on the car in addition to crippling the heat output in the cabin. Additionally, depending on which way the valve sticks, it could overheat the car and ruin the engine, or worse. Car is under 4 years old and repair estimate is nearly $1900. There is a technical safety bulletin [XXX] that outlines a redesigned TCV. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)