Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 15 of 46 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Engine And Engine Cooling. Review the 10 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Air Bags. Review the 8 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 5 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
12 crash reports1 fire reports6 injury reports
What owners actually said
46 reports
903,086 miles · Jul 19, 2005
Fuel System, Gasoline
DT: 1996 SUBARU OUTBACK CALLER COMPLAINED ABOUT THE FUEL INJECTION .SYSTEM. WHEN STARTING THE CAR IT SHUT OFF AGAIN. WHEN DRIVING IT DIDN'T HAVE ANY SPEED, THE SPEED ODOMETER WAS 60 MPH WHEN GOING 40 MPH. SOMETIMES IT WILL PICK UP SPEED AND SOMETIMES IT WON'T. TOOK VEHICLE TO DEALER AND HE WOULD NOT WORK ON THIS …
Read full complaint
DT: 1996 SUBARU OUTBACK CALLER COMPLAINED ABOUT THE FUEL INJECTION .SYSTEM. WHEN STARTING THE CAR IT SHUT OFF AGAIN. WHEN DRIVING IT DIDN'T HAVE ANY SPEED, THE SPEED ODOMETER WAS 60 MPH WHEN GOING 40 MPH. SOMETIMES IT WILL PICK UP SPEED AND SOMETIMES IT WON'T. TOOK VEHICLE TO DEALER AND HE WOULD NOT WORK ON THIS CAR. THE CAR WILL NOT ACCELERATE, AND HE WOULD NOT LISTEN . THE CAR WAS PARKED ON THE ROAD SIDE NOW AND IT WILL NOT RUN. THE CAR VIBRATED WHEN TRYING TO START THE CAR TODAY. AND THE CAR WILL NOT START. THIS HAS BEEN HAPPENING FOR THE LAST TWO WEEKS AND TODAY THE CAR JUST DIED. *AK
NHTSA ODI #10129375
Mileage unknown · Mar 22, 2005
Air BagsCrash
WHILE SITTING AT A INTERSECTION WAITING FOR THE LIGHT TO CHANGE THE AIR BAGS WENT OFF INADVERTENTLY. DRIVER WAS NOT INJURED, AND THE VEHICLE WAS TOWED TO THE DEALER. A CAUSE COULD NOT BE DETERMINED AT THIS TIME. *AK
NHTSA ODI #10115555
80,000 miles · Mar 10, 2005
Exterior Lighting
A PERMANENT HAZING OF THE HEADLIGHT LENSES HAS BEEN PROGRESSIVELY GETTING WORSE, AND CANNOT BE REMOVED. THIS HAS CAUSED SAFE NIGHT DRIVING ILLUMINATION TO DROP DRAMATICALLY.*AK
NHTSA ODI #10113879
97,600 miles · Dec 6, 2004
Engine And Engine Cooling
CAR STARTED AND RAN NORMALLY FOR 5 TO 10 MINUTES ALONG A COUNTRY ROAD AT ABOUT 45 MPH, VEHICLE SUDDENLY ACCELERATED TO FULL THROTTLE. POKED ACCELERATOR PEDAL A FEW TIMES WITH NO RESULT, AND PEDAL DID NOT APPEAR TO BE STUCK DOWN. HELD SPEED OF VEHICLE DOWN WITH BOTH FEET HARD ON BRAKE PEDAL. VEHICLE RETURNED TO NEAR NORMAL OP…
Read full complaint
CAR STARTED AND RAN NORMALLY FOR 5 TO 10 MINUTES ALONG A COUNTRY ROAD AT ABOUT 45 MPH, VEHICLE SUDDENLY ACCELERATED TO FULL THROTTLE. POKED ACCELERATOR PEDAL A FEW TIMES WITH NO RESULT, AND PEDAL DID NOT APPEAR TO BE STUCK DOWN. HELD SPEED OF VEHICLE DOWN WITH BOTH FEET HARD ON BRAKE PEDAL. VEHICLE RETURNED TO NEAR NORMAL OPERATING CONDITION ON ITS OWN AFTER ABOUT 30 SEC TO 1 MIN, ALTHOUGH VEHICLE COULD MAINTAIN 30-40 MPH WHEN NOT TOUCHING EITHER ACCELERATOR OR BRAKE. RETURNED TO FULLY NORMAL OPERATING CONDITION AFTER A FEW MINUTES. THIS WAS THE SECOND OCCURRENCE IN LESS THAN TWO WEEKS. IN THE FIRST OCCURRENCE, VEHICLE WAS HARD TO START FOR SEVERAL SECONDS, THEN WHEN DID START RACED TO EXTREMELY HIGH IDLE FOR SEVERAL MINUTES. POKING ACCELERATOR PEDAL HAD NO EFFECT. VEHICLE RETURNED TO NORMAL OPERATING CONDITION AFTER BEING TURNED OFF AND RE-STARTED. VEHICLE WAS BROUGHT TO DEALER, BUT TECHNICIANS COULD NOT DUPLICATE PROBLEM, AND ALL DIAGNOSTIC CHECKS WERE NEGATIVE. PROBLEM IS STILL UNRESOLVED.*AK
NHTSA ODI #10102225
Mileage unknown · Nov 18, 2004
Power Train
I DRIVE A 1996 OUTBACK WITH 116,000 MILES ON IT. I'VE READ ABOUT POSSIBLE RECALLS PERTAINING TO THE TRANSMISSIONS BINDING IN TURNS, WHICH IS WHAT I'M EXPEREINCING NOW. I'VE BEEN TOLD THAT IF IT GETS TOO BAD, IT MAY BREAK AN AXLE OR SOMETHING. IF IT IS A RECOGNIZED PROBLEM/MISTAKE, I'D REALLY LIKE TO SEE A RECALL.*AK
NHTSA ODI #10100137
115,000 miles · Jan 15, 2004
Engine And Engine Cooling
BLEW A HEAD GASKET WHICH LEAKED ANTIFREEZE THROUGHOUT THE ENGINE CAUSING MANY OTHER PARTS FAILURES. FOR EXAMPLE, O2 SENSORS. TOTAL COST OF REPAIRING VEHICLE - $4,800
NHTSA ODI #10069547
115,000 miles · Apr 27, 2003
Engine And Engine Cooling
BLEW A HEAD GASKET WHILE TRAVELING WITH TWO CHILDREN. BROKE DOWN AND HAD TO WAIT ON SIDE OF BUSY ROAD WITH ONE YEAR OLD AND TWO YEAR OLD. THE CAR,A 1996 OUTBACK ONLY HAD 115,000 MILES ON IT. REAL LOW FOR THIS TYPE OF INCIDENT. *NLM
NHTSA ODI #10016569
Mileage unknown · Apr 7, 2003
Tires
COMPLETE SEPARATION OF TREAD FROM BODY AND SIDEWALL OF RIGHT FRONT MICHELIN HARMONY TIRE. TIRES IN SERVICE FOR THREE MONTHS ON A SUBARU LEGACY WAGON. *JB
NHTSA ODI #10014056
Mileage unknown · Sep 24, 2002
Wheels
CONSUMER STATES WHEELS ARE OXDIZING/CORRODING AND AIR IS LEAKING IN ALL TIRES. CHECKED BY DEALER WHO OXIDIZED THE TIRES.*JB
NHTSA ODI #8019292
Mileage unknown · Jun 18, 2002
Suspension
ON SEVRAL OCCASIONS, THE LEFT AND RIGHT BEARINGS FAILED CAUSING DAMAGE TO THE AXLE ASSEMBLY. BEARINGS HAD TO BE REPLACED TWICE. DEALER NOTIFIED. *TT
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH FRONT COIL SPRINGS ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW YORK, NEW JERSEY, NEW HAMPSHIRE, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, VIRGINIA, WEST VIRGINIA, AND WISCONSIN, AND IN THE DISTRICT OF COLUMBIA. THE FRONT COIL SPRINGS WERE PRODUCED WITH POOR PAINT QUALITY WHICH, AFTER CONTINUED EXPOSURE TO CORROSIVE SALT, CAN RESULT IN BREAKAGE OF THE SPRING.
Consequence & remedy
Consequence: DEPENDING ON THE LOCATION OF THE FRACTURE, A BROKEN SPRING COULD MOVE PAST THE SPRING SEAT AND CONTACT A FRONT TIRE. SOME TIRES HAVE DEFLATED DUE TO CONTACT WITH A BROKEN SPRING.
Remedy: DEALERS WILL NOTIFIY CUSTOMERS TO BRING THEIR VEHICLE TO AN AUTHORIZE DEALERSHIP TO HAVE A SPRING GUARD INSTALLED ON BOTH FRONT STRUTS TO PREVENT TIRE PUNCTURE AND REPLACE ANY BROKEN SPRINGS FREE OF CHARGE. OWNER NOTIFICATION BEGAN SEPTEMBER 18, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SUBARU AT 1-800-782-2783.
VEHICLE DESCRIPTION: PASSENGER STATION WAGON, SEDAN AND SPORT UTILITY VEHICLES. DUE TO IMPROPER WELDING, FRACTURES CAN OCCUR ON THE SUPPORT BRACKET OF THE FRONT TRANSVERSE LINK.
Consequence & remedy
Consequence: SUCH FRACTURES CAN RESULT IN PARTIAL OR COMPLETE SEPARATION OF THE BRACKET CAUSING A FAILURE OF THE LOWER SUSPENSION MOUNTING, LEADING TO A LOSS OF VEHICLE CONTROL.
Remedy: DEALERS WILL INSPECT AND REPLACE IF NECESSARY THE FRONT SUSPENSION SUPPORT BRACKETS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration