Engine And Engine Cooling. Review the 10 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Air Bags. Review the 8 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 5 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

12 crash reports1 fire reports6 injury reports

Suspension complaints

4 reports

Clear category filter

169,000 miles · Jun 1, 2006

Suspension

Read full complaint

ACCORDING TO SUBARU IN NHTSA RECALL NO. 01V-216, THE PROTECTIVE PAINT WAS APPLIED INCORRECTLY TO '96 SUBARU LEGACY OUTBACK SPRINGS WHICH LEADS THEM TO RUST AND BREAK. SUBARU WILL REPLACE THE FRONT SPRINGS BUT WILL NOT REPLACE THE REAR SPRINGS, EVEN THOUGH THE SAME PROBLEM OCCURS ON BOTH FRONT AND REAR SPRINGS. BOTH OF MY FRONT SPRINGS BROKE, ONE OF MY REAR SPRINGS BROKE, AND THE OTHER REAR SPRING IS CRACKED AND BREAKING. WHEN THE REAR SPRINGS BREAK THERE IS THE SAME SAFETY ISSUE AS WHEN THE FRONT SPRINGS BREAK, THAT BEING THAT THE CAR MAY BECOME UNCONTROLLABLE WHICH COULD BE FATAL AT HIGHWAY SPEEDS. PLEASE PROMPT SUBARU TO RECALL THE REAR SPRINGS AS WELL AS THE FRONT TO MITIGATE THIS SAFETY ISSUE. THANKS. *JB

NHTSA ODI #10158744

Mileage unknown · Jun 18, 2002

Suspension

ON SEVRAL OCCASIONS, THE LEFT AND RIGHT BEARINGS FAILED CAUSING DAMAGE TO THE AXLE ASSEMBLY. BEARINGS HAD TO BE REPLACED TWICE. DEALER NOTIFIED. *TT

NHTSA ODI #566110

Mileage unknown · Apr 23, 2001

Suspension

AT VERY LOW SPEED SPRING OF LEFT FRONT STRUT BROKE AND WENT THROUGH TIRE.*AK *SLC

NHTSA ODI #886415

Mileage unknown · Feb 4, 1997

SuspensionCrash

WAS DRIVING HIT AN ICY SPOT, LOST CONTROL AND THE TRUCK ROLLED OVER AND HIT A DITCH. *AK

NHTSA ODI #808602

Official recalls

01V216000 · Suspension:front:springs:coil Springs

Jun 25, 2001

VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH FRONT COIL SPRINGS ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW YORK, NEW JERSEY, NEW HAMPSHIRE, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, VIRGINIA, WEST VIRGINIA, AND WISCONSIN, AND IN THE DISTRICT OF COLUMBIA. THE FRONT COIL SPRINGS WERE PRODUCED WITH POOR PAINT QUALITY WHICH, AFTER CONTINUED EXPOSURE TO CORROSIVE SALT, CAN RESULT IN BREAKAGE OF THE SPRING.

Consequence & remedy

Consequence: DEPENDING ON THE LOCATION OF THE FRACTURE, A BROKEN SPRING COULD MOVE PAST THE SPRING SEAT AND CONTACT A FRONT TIRE. SOME TIRES HAVE DEFLATED DUE TO CONTACT WITH A BROKEN SPRING.

Remedy: DEALERS WILL NOTIFIY CUSTOMERS TO BRING THEIR VEHICLE TO AN AUTHORIZE DEALERSHIP TO HAVE A SPRING GUARD INSTALLED ON BOTH FRONT STRUTS TO PREVENT TIRE PUNCTURE AND REPLACE ANY BROKEN SPRINGS FREE OF CHARGE. OWNER NOTIFICATION BEGAN SEPTEMBER 18, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SUBARU AT 1-800-782-2783.

98V091000 · Suspension:front:springs:leaf Spring Assembly:hanger,bracket

May 4, 1998

VEHICLE DESCRIPTION: PASSENGER STATION WAGON, SEDAN AND SPORT UTILITY VEHICLES. DUE TO IMPROPER WELDING, FRACTURES CAN OCCUR ON THE SUPPORT BRACKET OF THE FRONT TRANSVERSE LINK.

Consequence & remedy

Consequence: SUCH FRACTURES CAN RESULT IN PARTIAL OR COMPLETE SEPARATION OF THE BRACKET CAUSING A FAILURE OF THE LOWER SUSPENSION MOUNTING, LEADING TO A LOSS OF VEHICLE CONTROL.

Remedy: DEALERS WILL INSPECT AND REPLACE IF NECESSARY THE FRONT SUSPENSION SUPPORT BRACKETS.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

No exact-year investigations in this snapshot.

Go deeper into Subaru Outback problems

Subaru Outback transmission problems →Subaru Outback electrical problems →