IllustrationTL* THE CONTACT OWNS A 1991 SUBARU LEGACY. WHILE THE VEHICLE WAS PARKED, THE CONTACT'S ELBOW WAS CUT SEVERAL TIMES ON THE DOOR JAM WHILE ATTEMPTING TO EXIT. THE LOCAL DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS 56,000.
1991 Subaru Legacy
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 1991 Subaru Legacy do not stand out strongly from the model-year median of 77.
About this comparison →How this year compares
Owner complaints by model year
Compare all Legacy years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 4 of 78 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Seat Belts. Review the 19 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 16 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Latches/locks/linkages. Review the 14 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
3 crash reports0 fire reports3 injury reports
What owners actually said
78 reportsDRIVERS SIDE AUTOMATIC SEAT BELT DRIVE CABLE SLIPS OUT OF TRACK MAKING SEAT BELT USELESS AND DANGEROUS.
TL* THE CONTACT OWNS A 1991 SUBARU LEGACY. THE CONTACT WAS SITTING AT A TRAFFIC STOP WHEN HE ATTEMPTED TO SHIFT INTO DRIVE AND THE GEAR SHIFTER DETACHED FROM THE VEHICLE. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR INSPECTION OR REPAIRS. THE MANUFACTURER WAS CONTACTED AND INFORMED THE CONTACT TO TAKE THE VEHICLE TO THE DEALER F…
Read full complaint
TL* THE CONTACT OWNS A 1991 SUBARU LEGACY. THE CONTACT WAS SITTING AT A TRAFFIC STOP WHEN HE ATTEMPTED TO SHIFT INTO DRIVE AND THE GEAR SHIFTER DETACHED FROM THE VEHICLE. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR INSPECTION OR REPAIRS. THE MANUFACTURER WAS CONTACTED AND INFORMED THE CONTACT TO TAKE THE VEHICLE TO THE DEALER FOR INSPECTION OF THE FAILURE. THE FAILURE AND THE CURRENT MILEAGE WAS 123,259.
TL*THE CONTACT OWNS A 1991 SUBARU LEGACY. THE CONTACT STATED WHEN DRIVING 50 MPH AND FASTER, THE VEHICLE WOULD STALL WITHOUT WARNING. THE CHECK ENGINE LIGHT WOULD BRIEFLY ILLUMINATE AFTER THE VEHICLE HAD STALLED. THE CONTACT WAS ADVISED BY AN INDEPENDENT MECHANIC THAT THE FAILURE COULD POTENTIALLY BE CAUSED BY A DEFECTIVE THROTT…
Read full complaint
TL*THE CONTACT OWNS A 1991 SUBARU LEGACY. THE CONTACT STATED WHEN DRIVING 50 MPH AND FASTER, THE VEHICLE WOULD STALL WITHOUT WARNING. THE CHECK ENGINE LIGHT WOULD BRIEFLY ILLUMINATE AFTER THE VEHICLE HAD STALLED. THE CONTACT WAS ADVISED BY AN INDEPENDENT MECHANIC THAT THE FAILURE COULD POTENTIALLY BE CAUSED BY A DEFECTIVE THROTTLE SENSOR. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER DID NOT OFFER ANY ASSISTANCE. THE FAILURE MILEAGE WAS 193,100 AND THE CURRENT MILEAGE WAS 193,250.
TL*THE CONTACT OWNS A 1991 SUBARU LEGACY. THE CONTACT STATED THAT THE ELECTRIC SEAT BELT JAMS IN THE MIDDLE AND RENDERS THE SEAT BELT INOPERABLE. THE DEALER WILL NOT REPAIR THE VEHICLE FREE OF CHARGE. THE CURRENT AND FAILURE MILEAGES WERE 176,000. THE CONSUMER STATED THE SEAT BELT WAS REPLACED AND ON AUGUST 10, 2007 IT FA…
Read full complaint
TL*THE CONTACT OWNS A 1991 SUBARU LEGACY. THE CONTACT STATED THAT THE ELECTRIC SEAT BELT JAMS IN THE MIDDLE AND RENDERS THE SEAT BELT INOPERABLE. THE DEALER WILL NOT REPAIR THE VEHICLE FREE OF CHARGE. THE CURRENT AND FAILURE MILEAGES WERE 176,000. THE CONSUMER STATED THE SEAT BELT WAS REPLACED AND ON AUGUST 10, 2007 IT FAILED AGAIN. THE SEAT BELT WAS REPLACED AGAIN ON SEPTEMBER 9, 2007. UPDATED 09/27/07. *JB
CONSUMER NOTICED THAT DRIVER SIDE SEAT BELT WEBBING WAS SEPARATING. VEHICLE WAS TAKEN TO THE DEALER, AND DEALER INFORMED CONSUMER THAT VEHICLE WAS NOT UNDER WARRANTY, AND THAT CONSUMER HAD TO PAY FOR REPAIRS. *AK
THE MULTI-FUNCTION SWITCH THAT CONTROLS HEADLIGHTS AND TURN SIGNAL MALFUNCTIONED. DRIVER TRIED TO USE THE TURN SIGNAL AND HEADLIGHTS TURNED OFF WITHOUT ANY WARNING. WHILE DRIVING APPROXIMATELY 35 MPH CONSUMER'S VEHICLE WAS INVOLVED IN A COLLISION DUE TO ANOTHER VEHICLE NOT SEEING THE HEADLIGHTS. DRIVER SUSTAINED CHEST AND S…
Read full complaint
THE MULTI-FUNCTION SWITCH THAT CONTROLS HEADLIGHTS AND TURN SIGNAL MALFUNCTIONED. DRIVER TRIED TO USE THE TURN SIGNAL AND HEADLIGHTS TURNED OFF WITHOUT ANY WARNING. WHILE DRIVING APPROXIMATELY 35 MPH CONSUMER'S VEHICLE WAS INVOLVED IN A COLLISION DUE TO ANOTHER VEHICLE NOT SEEING THE HEADLIGHTS. DRIVER SUSTAINED CHEST AND STERNUM INJURIES. *AK
AFTER STARTING VEHICLE DRIVER PUT SHIFTER IN DRIVE AND VEHICLE TOOK OFF, DRIVER HAD NO CONTROL. AS A RESULT, VEHICLE HIT A BRICK WALL BEFORE COMING TO A STOP. UPON IMPACT, NONE OF THE AIRBAGS DEPLOYED. *AK
WITHIN ONE WEEK BOTH SEAT BELTS CAME APART. DEALER SAID IT WOULD COST $975.00 TO REPLACE THEM. DO I HAVE ANY OTHER RECOURSE? THANK YOU.
WHEN OPENING THE DOOR USING THE INSIDE HANDLE, UPON RELEASE OF THE DOOR HANDLE THE LOCKING MECHANISM IS TRIGGERED WHICH CAUSES ALL OF THE DOORS TO LOCK AND THE DRIVER'S DOOR LOCK IS JAMMED IN THE LOCKED POSITION. THE DRIVER'S DOOR IS ONLY SUPPOSED TO LOCK UPON CLOSING WHEN THE OUTER DOOR HANDLE IS ENGAGED *AND* THE DOOR HAS BEE…
Read full complaint
WHEN OPENING THE DOOR USING THE INSIDE HANDLE, UPON RELEASE OF THE DOOR HANDLE THE LOCKING MECHANISM IS TRIGGERED WHICH CAUSES ALL OF THE DOORS TO LOCK AND THE DRIVER'S DOOR LOCK IS JAMMED IN THE LOCKED POSITION. THE DRIVER'S DOOR IS ONLY SUPPOSED TO LOCK UPON CLOSING WHEN THE OUTER DOOR HANDLE IS ENGAGED *AND* THE DOOR HAS BEEN LOCKED. WHEN THE DOOR LOCK IS JAMMED IT REMAINS LOCKED UPON CLOSING WITHOUT ENGAGING THE OUTER DOOR HANDLE.*AK
Official recalls
394V052000 · Power Train:manual Transmission
Mar 23, 1994
WHEN THE VEHICLE IS DRIVEN CONTINUOUSLY UNDER EXTREMELY COLD TEMPERATURES (-22 DEGREES F.) AND HIGH HUMIDITY WEATHER CONDITIONS, THE TRANSMISSION BREATHING (AIR) VENT CAN BE BLOCKED DUE TO MOISTURE FREEZING AT THE OIL LEVEL GAUGE. IF THIS OCCURS, PRESSURE INSIDE THE TRANSMISSION CASE WILL INCREASE AND PUSH OUT THE REAR OIL SEAL, CAUSING TRANSMISSION OIL LEAKAGE. THE LACK OF LUBRICATION CAN BURN THE INTERNAL COMPONENTS OF THE TRANSMISSION, CAUSE THE TRANSMISSION TO SEIZE AND THE VEHICLE TO COME TO A SUDDEN STOP.
Consequence & remedy
Consequence: SUDDEN STOPS WITHOUT PRIOR WARNING CAN CAUSE VEHICLE OCCUPANTS TO BE THROWN AROUND THE VEHICLE AND CAUSE LOSS OF VEHICLE CONTROL WHICH CAN RESULT IN AN ACCIDENT.
Remedy: DEALERS WILL MODIFY THE OIL GAUGE PIPE AND MODIFY THE OIL LEVEL GAUGE (DIPSTICK) OR REPLACE IT, DEPENDING ON THE TYPE OF DIPSTICK IN THE VEHICLE.
91V082000 · Power Train:automatic Transmission
May 30, 1991
UNDER CERTAIN LOAD CONDITIONS, THE PARK GEAR MAY NOT DISENGAGE IMMEDIATELY WHEN THE TRANSMISSION LEVER IS MOVED FROM PARK TO REVERSE.
Consequence & remedy
Consequence: DELAYED RELEASE OF TRANSMISSION FROM PARK CAUSES DELAYEDAND POSSIBLY ABRUPT VEHICLE MOVEMENT THAT COULD RESULT IN LOSS OF VEHICLECONTROL AND AN ACCIDENT.
Remedy: INSTALL A MODIFIED PARKING BRAKE PAWL TO PREVENT DELAYED RELEASE INTO REVERSE GEAR.
90V184000 · Latches/locks/linkages:doors:latch
Oct 16, 1990
TORQUE OF LATCH SCREWS ON FRONT DOORS MAY LOOSEN OVER TIME DUE TO A GAP BETWEEN THE LATCH BASE PLATE AND INNER DOOR PANEL UNDER THE SCREW HEAD.
Consequence & remedy
Consequence: THE AFFECTED DOOR MAY NOT BE OPENED FROM INSIDE,PREVENTING EXIT FROM THAT DOOR.
Remedy: REPLACE FRONT DOOR LATCH SCREWS WITH "LOCK-TIGHT" SCREWS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE94051 · Hood Latch Failure
Opened Jun 29, 1994 · Closed Oct 31, 1994
Status: closed (inferred from source dates) · Structure
There is no summary currently available