← New search

2004 Subaru Forester

Owner reports · Recalls · Investigations

Similar to other model years

Owner complaints for the 2004 Subaru Forester do not stand out strongly from the model-year median of 131.

About this comparison →

How this year compares

Owner complaints by model year

Other model years Selected year
Compare all Forester years →

Counts vary with age, sales and reporting. They are not failure rates.

What owners reported most

All reported categories

Tap a category to read its complaints. One report may name several components.

When problems were reported

Mileage at the reported incident

188 reports with mileage · 31 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Fuel/propulsion System. Review the 63 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Fuel System, Gasoline. Review the 61 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Suspension. Review the 25 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

13 crash reports4 fire reports7 injury reports

Fuel System, Gasoline complaints

61 reports
Clear category filter
56,402 miles · Feb 4, 2014
Fuel System, Gasoline

UPON STARTING CAR IN COLD WEATHER (APPROX. 25 DEGREES F OR COLDER), THERE IS A STRONG FUEL SMELL. CANNOT TURN HEAT ON AS FUEL SMELL FILLS CABIN AND MAKES PASSENGERS NAUSEOUS. HEADACHES HAVE ALSO OCCURRED. WHEN VEHICLE IS PARKED IN GARAGE AFTER DRIVING IN COLD WEATHER, FUMES ACCUMULATE IN GARBAGE AND LEAK INTO HOUSE AS WELL. APPA…

Read full complaint

UPON STARTING CAR IN COLD WEATHER (APPROX. 25 DEGREES F OR COLDER), THERE IS A STRONG FUEL SMELL. CANNOT TURN HEAT ON AS FUEL SMELL FILLS CABIN AND MAKES PASSENGERS NAUSEOUS. HEADACHES HAVE ALSO OCCURRED. WHEN VEHICLE IS PARKED IN GARAGE AFTER DRIVING IN COLD WEATHER, FUMES ACCUMULATE IN GARBAGE AND LEAK INTO HOUSE AS WELL. APPARENTLY FUEL LINES SHRINK IN COLD AND LEAK FUEL DIRECTLY ONTO ENGINE. THIS IS BOTH HEALTH AND FIRE HAZARD. *TR

NHTSA ODI #10562821

120,000 miles · Jan 31, 2014
EngineFuel System, Gasoline

VERY STRONG FUEL SMELL IN THE CAR WITH HEATER ON SO STRONG HAVE TO ROLL WINDOW DOWN. HAPPENS 2 TO 3 TIMES A WEEK ON COLD DAYS. STRONGEST WHEN ITS A COLD START. *TR

NHTSA ODI #10562421

130,000 miles · Jan 30, 2014
Engine And Engine CoolingFuel System, Gasoline

IN COLD WEATHER (BELOW 20 DEGREES OR SO) THE FUEL LINES IN THE ENGINE COMPARTMENT COME LOOSE AND LEAK RAW GASOLINE ONTO THE HOT ENGINE. OBVIOUSLY THERE IS A GOOD CHANCE OF AN ENGINE FIRE WITH POSSIBLE LOSS OF LIFE. THIS HAS BEEN REPORTED IN SEVERAL FORUMS, THERE IS A TSB OUT ON THIS FOR THE WRX (SAME ENGINE, SAME PART NUMBERS), …

Read full complaint

IN COLD WEATHER (BELOW 20 DEGREES OR SO) THE FUEL LINES IN THE ENGINE COMPARTMENT COME LOOSE AND LEAK RAW GASOLINE ONTO THE HOT ENGINE. OBVIOUSLY THERE IS A GOOD CHANCE OF AN ENGINE FIRE WITH POSSIBLE LOSS OF LIFE. THIS HAS BEEN REPORTED IN SEVERAL FORUMS, THERE IS A TSB OUT ON THIS FOR THE WRX (SAME ENGINE, SAME PART NUMBERS), AND MOST DEALERS (IN COLD STATES) KNOW OF THIS PROBLEM. *TR

NHTSA ODI #10562155

87,000 miles · Jan 28, 2014
EngineFuel System, Gasoline

ON VERY COLD DAYS WHILE CAR IS WARMING UP, A STRONG SMELL OF FUEL IS COMING FROM UNDER THE INTAKE MANIFOLD. A CLOSER INSPECTION REVEALS A SMALL FUEL LEAK FROM THE FUEL SUPPLY LINES NEAR THE TURBO. A SUBARU IMPREZA ENTHUSIAST FORUM HAS A "RAW FUEL SMELL" LOG OF MORE THAN 131 PAGES AND 3,000 POSTS (HTTP://FORUMS.NASIOC.COM/FORUM…

Read full complaint

ON VERY COLD DAYS WHILE CAR IS WARMING UP, A STRONG SMELL OF FUEL IS COMING FROM UNDER THE INTAKE MANIFOLD. A CLOSER INSPECTION REVEALS A SMALL FUEL LEAK FROM THE FUEL SUPPLY LINES NEAR THE TURBO. A SUBARU IMPREZA ENTHUSIAST FORUM HAS A "RAW FUEL SMELL" LOG OF MORE THAN 131 PAGES AND 3,000 POSTS (HTTP://FORUMS.NASIOC.COM/FORUMS/SHOWTHREAD.PHP?T=131755). SUBARU ISSUED A TECHNICAL SERVICE BULLETIN (TSB) FOR CERTAIN SUBARU IMPREZAS, BUT THEY HAVE NOT INITIATED ANY TSBS FOR ANY OTHER CARS ALL USING THE SAME OR SIMILAR ENGINES. SEE TSB 01-170-09. AS LEAKING FUEL ONTO YOUR ENGINE IS A SAFETY HAZARD, I WOULD LIKE TO SEE SUBARU INITIATE SOME KIND OF TSB OR RECALL FOR ALL ENGINES EXPERIENCING THIS PROBLEM. I UNDERSTAND MANY SUBARU OWNERS HAVE COMPLAINED TO SUBARU AND NHTSA WITH NO RESULTS. *TR

NHTSA ODI #10561865

156,000 miles · Jan 24, 2014
Engine And Engine CoolingFuel System, Gasoline

FUEL AND EXHAUST LINE LEAKS IN COLD WEATHER. OVER THE INITIAL THREE DAY PERIOD - DAY ONE CHILDREN COMPLAINED OF HEADACHES, DAY TWO DRIVER EXPERIENCED SEVERE HEADACHE AND NAUSEA BUT DID NOT REALIZE IT WAS DUE TO FUEL LEAK. DAY THREE CABIN FILLED WITH OVERPOWERING FUMES COMING FROM HEATING VENT. HAD TO DRIVE WITH HEAT OFF AND…

Read full complaint

FUEL AND EXHAUST LINE LEAKS IN COLD WEATHER. OVER THE INITIAL THREE DAY PERIOD - DAY ONE CHILDREN COMPLAINED OF HEADACHES, DAY TWO DRIVER EXPERIENCED SEVERE HEADACHE AND NAUSEA BUT DID NOT REALIZE IT WAS DUE TO FUEL LEAK. DAY THREE CABIN FILLED WITH OVERPOWERING FUMES COMING FROM HEATING VENT. HAD TO DRIVE WITH HEAT OFF AND ALL WINDOWS OPEN IN ORDER TO BRING CAR IN FOR SERVICE. HAVE HAD TO BRING CAR IN TWICE THIS MONTH TO REPAIR ALL OF THE LEAKS AND RENT A CAR IN ORDER TO GET TO WORK APPOINTMENTS. CERTIFIED SUBARU SPECIALIST REPORTED THAT HE HAS SEEN QUITE A FEW INCIDENCES OF SAME ISSUE RECENTLY DUE TO EXTREME COLD WEATHER. THIS IS A DANGEROUS SAFETY ISSUE AND IS NOT ACCEPTABLE. 2002-2003 IMPREZA RECALLED DEC 2009 FOR SAME ISSUE. *TR

NHTSA ODI #10561352

122,765 miles · Jan 24, 2014
Fuel System, Gasoline

A STRONG FUEL SMELL WHEN I STARTED MY CAR. *TR

NHTSA ODI #10561335

65,000 miles · Jan 23, 2014
Fuel System, Gasoline

THIS 2004 SUBARU FORESTER 2.5 XT AWD 4-SPD AUTOMATIC TRANSMISSION WITH MULTI-PURPOSE FUEL INJECTION TURBO (FEEDBACK FUEL SYSTEM) HAS BEEN PRODUCING A STRONG FUEL SMELL THAT FILLS THE ENTIRE VEHICLE CABIN. I'VE BEEN TOLD BY THE DEALER THAT THIS IS TO BE EXPECTED FROM THIS TYPE OF ENGINE AND THAT THERE IS NOTHING MUCH THAT THEY C…

Read full complaint

THIS 2004 SUBARU FORESTER 2.5 XT AWD 4-SPD AUTOMATIC TRANSMISSION WITH MULTI-PURPOSE FUEL INJECTION TURBO (FEEDBACK FUEL SYSTEM) HAS BEEN PRODUCING A STRONG FUEL SMELL THAT FILLS THE ENTIRE VEHICLE CABIN. I'VE BEEN TOLD BY THE DEALER THAT THIS IS TO BE EXPECTED FROM THIS TYPE OF ENGINE AND THAT THERE IS NOTHING MUCH THAT THEY CAN DO ABOUT IT AND TO LEARN TO LIVE WITH IT. THE DEALER ALSO INDICATES THAT THIS PROBLEM IS BASICALLY CAUSED BY EXTREME COLD WEATHER AND/OR TEMPERATURE CHANGE. I HAVE RESEARCHED THIS ISSUE AND FOUND THAT THERE WAS A SIMILAR PROBLEM WITH THE SUBARU IMPREZA AND THAT SUBARU ISSUED A RECALL. NO VEHICLE, SUBARU OR OTHERWISE, SHOULD PRODUCE A PROBLEM LIKE THIS ONE THAT IS "UNFIXABLE." THE CONSUMER SHOULD BE PROTECTED FROM THIS POTENTIALLY HAZARDOUS SITUATION. THIS CONSUMER IS PUTTING SUBARU ON NOTICE. *TR

NHTSA ODI #10561154

117,000 miles · Jan 23, 2014
EngineFuel System, Gasoline

TL* THE CONTACT OWNS A 2004 SUBARU FORESTER. THE CONTACT STATED WHEN THE TEMPERATURE DROPPED, FUEL FUMES WERE EMITTED IN AND AROUND THE VEHICLE. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR INSPECTION. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 117,000. T…

Read full complaint

TL* THE CONTACT OWNS A 2004 SUBARU FORESTER. THE CONTACT STATED WHEN THE TEMPERATURE DROPPED, FUEL FUMES WERE EMITTED IN AND AROUND THE VEHICLE. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR INSPECTION. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 117,000. THE INTAKE MANIFOLD WAS REPLACED. UPDATED 03/12/14 UPDATED 3/12/14*CN THE FUEL LINES, CLAMPS AND UPPER INTAKE GASKETS WERE REPLACED. THE FUEL LINES WERE CRACKED. UPDATED 04/01/14

NHTSA ODI #10561131

72,000 miles · Jan 22, 2014
Fuel System, Gasoline

SMELL OF RAW GAS INSIDE OF VEHICLE WHILE DRIVING. IT DOESN'T HAPPEN ALL THE TIME ONLY ON EXTREMELY COLD DAYS. *TR

NHTSA ODI #10561084

133,000 miles · Jan 21, 2014
Fuel System, Gasoline

IMMEDIATELY UPON STARTING THE ENGINE A STRONG SMELL OF GASOLINE FILLED THE ENTIRE PASSENGER CABIN. COLD WEATHER TEMPERATURE WAS WELL BELOW FREEZING. HAS HAPPENED PREVIOUSLY, AND IS CORRECTED BY TIGHTENING THE FUEL LINE CONNECTIONS. *TR

NHTSA ODI #10560830

Official recalls

2

11V464000 · Suspension:front:control Arm:lower Arm

Sep 6, 2011

SUBARU IS RECALLING CERTAIN MODEL YEAR 2002-2007 IMPREZA, MODEL YEAR 2003-2008 FORESTER, AND MODEL YEAR 2005-2006 SAAB 9-2X VEHICLES MANUFACTURED FROM SEPTEMBER 5, 2000 THROUGH NOVEMBER 26, 2007 ORIGINALLY SOLD, OR CURRENTLY REGISTERED IN, MASSACHUSETTS, MARYLAND, MICHIGAN, NEW HAMPSHIRE, NEW YORK, PENNSYLVANIA, VERMONT, WISCONSIN, CONNECTICUT, DELAWARE, IOWA, ILLINOIS, INDIANA, MAINE, MINNESOTA, MISSOURI, NEW JERSEY, OHIO, RHODE ISLAND, WEST VIRGINIA AND THE DISTRICT OF COLUMBIA. THE FRONT LOWER CONTROL ARMS MAY BREAK AT THE HANGER BRACKETS DUE TO CORROSION IF THE HANGER BRACKET IS EXPOSED TO SALTY AND HUMID ENVIRONMENTS SUCH AS ROADS CONTAINING SNOW MELTING AGENT.

Consequence & remedy

Consequence: A BROKEN CONTROL ARM CAN RESULT IN THE LOSS OF CONTROL OF THE VEHICLE, INCREASING THE RISK OF A CRASH.

Remedy: SUBARU WILL HANDLE THEIR VEHICLES AND SAAB WILL HANDLE THEIRS. DEALERS WILL INSPECT THE DEGREE OF CORROSION OF THE FRONT LOWER CONTROL ARMS, AND WILL EITHER RUSTPROOF OR REPLACE THEM. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING DECEMBER 2011. OWNERS MAY CONTACT SUBARU AT 1-800-782-2783. OWNERS MAY CONTACT SAAB AT 1-800-955-9007.

04V473000 · Engine And Engine Cooling

Oct 1, 2004

ON CERTAIN PASSENGER AND SPORT UTILITY VEHICLES, THE COVER BOLTS FOR THE ENGINE OIL CONTROL VALVE MAY NOT BE SUFFICIENTLY TIGHTENED, ALLOWING OIL TO LEAK FROM AROUND THE COVER GASKET.

Consequence & remedy

Consequence: IF LEAKING OIL CONTACTS COMPONENTS OPERATING AT HIGH TEMPERATURES, A FIRE COULD RESULT IN THE ENGINE COMPARTMENT.

Remedy: DEALERS WILL INSPECT AND RETIGHTEN THE OIL-FLOW CONTROL VALVE COVER BOLTS. THE RECALL BEGAN ON OCTOBER 8, 2004. OWNERS SHOULD CONTACT SUBARU AT 1-800-782-2783.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

1

PE11011 · Front Suspension Control Arm Failure

Opened Apr 7, 2011 · Closed Sep 23, 2011

Status: closed (inferred from source dates) · Suspension; Suspension:front; Suspension:front:control Arm; Suspension:front:control Arm:lower Arm

On September 6, 2011, Fuji Heavy Industries USA, Inc, on behalf of Subaru of America, Inc notified the Office of Defects Investigation (ODI) it would be conducting a safety recall of certain model year (MY) 2002 through 2007 Subaru Impreza, MY 2003 through 2008 Subaru Forester, and MY 2005 through 2006 Saab 9-2X vehicles originally sold or currently registered in one the salt belt states including the District of Columbia (DC). For the purpose of this investigation, salt belt states include Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin and DC.ODI's analysis of consumer complaint data identified 11 reports alleging failure of either the right or left lower control arm due to excessive corrosion. All of these complaints were associated with vehicles currently registered or originally sold in a salt belt state. Through a similar analysis of complaint and warranty data submitted to ODI by Subaru, ODI identified 18 consumer complaints and 6 warranty claims associated with failure of the left or right front lower control arm due to excessive corrosion. All of these consumer complaints associated with vehicles either currently registered of originally sold in a salt belt state.Accordingly, this investigation is closed.

Additional source detail variants (4)

Suspension:front:control Arm:lower Arm

On September 6, 2011, Fuji Heavy Industries USA, Inc, on behalf of Subaru of America, Inc notified the Office of Defects Investigation (ODI) it would be conducting a safety recall of certain model year (MY) 2002 through 2007 Subaru Impreza, MY 2003 through 2008 Subaru Forester, and MY 2005 through 2006 Saab 9-2X vehicles originally sold or currently registered in one the salt belt states including the District of Columbia (DC). For the purpose of this investigation, salt belt states include Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin and DC.ODI's analysis of consumer complaint data identified 11 reports alleging failure of either the right or left lower control arm due to excessive corrosion. All of these complaints were associated with vehicles currently registered or originally sold in a salt belt state. Through a similar analysis of complaint and warranty data submitted to ODI by Subaru, ODI identified 18 consumer complaints and 6 warranty claims associated with failure of the left or right front lower control arm due to excessive corrosion. All of these consumer complaints associated with vehicles either currently registered of originally sold in a salt belt state.Accordingly, this investigation is closed.

Suspension:front:control Arm

On September 6, 2011, Fuji Heavy Industries USA, Inc, on behalf of Subaru of America, Inc notified the Office of Defects Investigation (ODI) it would be conducting a safety recall of certain model year (MY) 2002 through 2007 Subaru Impreza, MY 2003 through 2008 Subaru Forester, and MY 2005 through 2006 Saab 9-2X vehicles originally sold or currently registered in one the salt belt states including the District of Columbia (DC). For the purpose of this investigation, salt belt states include Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin and DC.ODI's analysis of consumer complaint data identified 11 reports alleging failure of either the right or left lower control arm due to excessive corrosion. All of these complaints were associated with vehicles currently registered or originally sold in a salt belt state. Through a similar analysis of complaint and warranty data submitted to ODI by Subaru, ODI identified 18 consumer complaints and 6 warranty claims associated with failure of the left or right front lower control arm due to excessive corrosion. All of these consumer complaints associated with vehicles either currently registered of originally sold in a salt belt state.Accordingly, this investigation is closed.

Suspension:front

On September 6, 2011, Fuji Heavy Industries USA, Inc, on behalf of Subaru of America, Inc notified the Office of Defects Investigation (ODI) it would be conducting a safety recall of certain model year (MY) 2002 through 2007 Subaru Impreza, MY 2003 through 2008 Subaru Forester, and MY 2005 through 2006 Saab 9-2X vehicles originally sold or currently registered in one the salt belt states including the District of Columbia (DC). For the purpose of this investigation, salt belt states include Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin and DC.ODI's analysis of consumer complaint data identified 11 reports alleging failure of either the right or left lower control arm due to excessive corrosion. All of these complaints were associated with vehicles currently registered or originally sold in a salt belt state. Through a similar analysis of complaint and warranty data submitted to ODI by Subaru, ODI identified 18 consumer complaints and 6 warranty claims associated with failure of the left or right front lower control arm due to excessive corrosion. All of these consumer complaints associated with vehicles either currently registered of originally sold in a salt belt state.Accordingly, this investigation is closed.

Suspension

On September 6, 2011, Fuji Heavy Industries USA, Inc, on behalf of Subaru of America, Inc notified the Office of Defects Investigation (ODI) it would be conducting a safety recall of certain model year (MY) 2002 through 2007 Subaru Impreza, MY 2003 through 2008 Subaru Forester, and MY 2005 through 2006 Saab 9-2X vehicles originally sold or currently registered in one the salt belt states including the District of Columbia (DC). For the purpose of this investigation, salt belt states include Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin and DC.ODI's analysis of consumer complaint data identified 11 reports alleging failure of either the right or left lower control arm due to excessive corrosion. All of these complaints were associated with vehicles currently registered or originally sold in a salt belt state. Through a similar analysis of complaint and warranty data submitted to ODI by Subaru, ODI identified 18 consumer complaints and 6 warranty claims associated with failure of the left or right front lower control arm due to excessive corrosion. All of these consumer complaints associated with vehicles either currently registered of originally sold in a salt belt state.Accordingly, this investigation is closed.

Go deeper into Subaru Forester problems