Illustration2004 FORESTER XT STALLED, HAD LOSS OF POWER DURING ACCELERATION AND JERKED VIOLENTLY. *TS THE VEHICLE WAS TAKEN TO THE DEALER THREE TIMES BUT THEY WERE UNABLE TO DIAGNOSE AND REPAIR THE PROBLEM. *NM
2004 Subaru Forester
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2004 Subaru Forester do not stand out strongly from the model-year median of 131.
About this comparison →How this year compares
Owner complaints by model year
Compare all Forester years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
80–25K
1825–50K
3850–75K
3275–100K
62100–150K
30150K+
188 reports with mileage · 31 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Fuel/propulsion System. Review the 63 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel System, Gasoline. Review the 61 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Suspension. Review the 25 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
13 crash reports4 fire reports7 injury reports
Engine And Engine Cooling complaints
16 reportsWHEN OUTSIDE TEMPERATURE FALLS BELOW 10 DEGREES F., CAR WILL NOT START OR STARTS ONLY WITH GREATEST DIFFICULTY. LAST YEAR(2004), SAME SORT OF STARTING PROBLEM WAS ATTRIBUTED TO A CRACKED IGNITION COIL. THIS YEAR DEALERS SERVICE DEPARTMENT CAN NOT FIND A PROBLEM, ALSO CAN'T EXPLAIN THE PROBLEM. *JB
EXCESSIVE SULFUR DIOXIDE ODOR (ROTTEN EGG). COMPANY REFUSES TO FIX CONVERTER, BLAMES FUEL. CONVERTER SHOULD HANDLE THE SULFUR CONTENT OF FUEL, REGARDLESS. *JB
CAR PRODUCING NOXIOUS ODOR INSIDE. WHEN PARKING CAR IN GARAGE, ACCIDENTALLY STEPPED ON ACCELERATOR RATHER THAN BRAKE. HIT AND DESTROYED BACK WALL. COSMETIC DAMAGE TO CAR. DEALER CLAIMS LEAVES WERE SUCKED INTO THE ENGINE COMPARTMENT THROUGH TURBOCHARGE INTAKE. BUT, ODOR WAS OF BURNT RUBBER OR PLASTIC, NOT LEAVES. AND, THE CA…
Read full complaint
CAR PRODUCING NOXIOUS ODOR INSIDE. WHEN PARKING CAR IN GARAGE, ACCIDENTALLY STEPPED ON ACCELERATOR RATHER THAN BRAKE. HIT AND DESTROYED BACK WALL. COSMETIC DAMAGE TO CAR. DEALER CLAIMS LEAVES WERE SUCKED INTO THE ENGINE COMPARTMENT THROUGH TURBOCHARGE INTAKE. BUT, ODOR WAS OF BURNT RUBBER OR PLASTIC, NOT LEAVES. AND, THE CAR IS ALWAYS PARKED IN THE GARAGE. FINALLY, MOST LEAVES WERE DOWN SEVERAL WEEKS EARLIER THIS YEAR, I.E., BY END OF NOVEMBER. *NM
ENGINE COMPARTMENT FIRE, RESULTING FROM OIL LEAKING IN ENGINE COMPARTMENT. THERE WERE NO INJURIES AND BECAUSE OF PROXIMITY OF FIRE DEPARTMENT FIRE WAS EXTINGUISHED WITHIN 4-5 MINUTES. SUBARU OF AMERICA (SOA) MAINTAINS THAT OIL LEAKED FROM OIL FILTER AND THAT THIS IS NO FAULT OF THEIRS. GIVEN THE HISTORY OF RECALLS OF THIS TYP…
Read full complaint
ENGINE COMPARTMENT FIRE, RESULTING FROM OIL LEAKING IN ENGINE COMPARTMENT. THERE WERE NO INJURIES AND BECAUSE OF PROXIMITY OF FIRE DEPARTMENT FIRE WAS EXTINGUISHED WITHIN 4-5 MINUTES. SUBARU OF AMERICA (SOA) MAINTAINS THAT OIL LEAKED FROM OIL FILTER AND THAT THIS IS NO FAULT OF THEIRS. GIVEN THE HISTORY OF RECALLS OF THIS TYPE OF VEHICLE IN JAPAN FOR LEAKING OIL AND FIRES I AM NOT SURE THAT THIS POINT HAS BEEN DEMONSTRATED. SOA REFUSED TO FIX DAMAGE AND TOLD ME TO FILE AN INSURANCE CLAIM... WHICH I HAVE DONE. DAMAGE IS ESTIMATED TO BE $6-10K. MATTER WILL BE SUBROGATED TO INSURANCE COMPANY FOR SETTLEMENT.*AK
THE VEHICLE'S TRANSMISSION MADE NOISE WHILE DRIVING. THE VEHICLE WAS INSPECTED AND IT WAS DETERMINED THAT HE VEHICLE WAS OPERATING AS DESIGNED. THE CONSUMER WOULD LIKE TO RETURN THE VEHICLE AND RECEIVE A REFUND FOR THE PURCHASE PRICE. *NM THE CONSUMER STATED THAT THE ENGINE IS MAKING A HIGH PITCH WHINING NOISE. THE CONSUMER …
Read full complaint
THE VEHICLE'S TRANSMISSION MADE NOISE WHILE DRIVING. THE VEHICLE WAS INSPECTED AND IT WAS DETERMINED THAT HE VEHICLE WAS OPERATING AS DESIGNED. THE CONSUMER WOULD LIKE TO RETURN THE VEHICLE AND RECEIVE A REFUND FOR THE PURCHASE PRICE. *NM THE CONSUMER STATED THAT THE ENGINE IS MAKING A HIGH PITCH WHINING NOISE. THE CONSUMER WAS TOLD THAT THE NOISE IS FROM THE REDUCTION GEAR TEETH TRANSMISSION AND WAS NORMAL. THE CONSUMER ALSO EXPERIENCED PROBLEMS WITH HER 1998 SUBARU FORRESTER THE CONSUMER EXPERIENCED OVERHEATING AND ENGINE DAMAGE. A FAULTY THERMOSTAT CAUSED THE OVERHEATING. AN INITIAL TEST SHOW CARBON MONOXIDE INDICATING PROBABLE DAMAGE TO THE SLEEVES BETWEEN THE PISTONS AND CYLINDERS, WHICH WOULD REQUIRE REPLACEMENT OF THE SHORT BLOCK. OVERHEATED CAMS ARE WARPED DUE TO THE HEAT.
Official recalls
211V464000 · Suspension:front:control Arm:lower Arm
Sep 6, 2011
SUBARU IS RECALLING CERTAIN MODEL YEAR 2002-2007 IMPREZA, MODEL YEAR 2003-2008 FORESTER, AND MODEL YEAR 2005-2006 SAAB 9-2X VEHICLES MANUFACTURED FROM SEPTEMBER 5, 2000 THROUGH NOVEMBER 26, 2007 ORIGINALLY SOLD, OR CURRENTLY REGISTERED IN, MASSACHUSETTS, MARYLAND, MICHIGAN, NEW HAMPSHIRE, NEW YORK, PENNSYLVANIA, VERMONT, WISCONSIN, CONNECTICUT, DELAWARE, IOWA, ILLINOIS, INDIANA, MAINE, MINNESOTA, MISSOURI, NEW JERSEY, OHIO, RHODE ISLAND, WEST VIRGINIA AND THE DISTRICT OF COLUMBIA. THE FRONT LOWER CONTROL ARMS MAY BREAK AT THE HANGER BRACKETS DUE TO CORROSION IF THE HANGER BRACKET IS EXPOSED TO SALTY AND HUMID ENVIRONMENTS SUCH AS ROADS CONTAINING SNOW MELTING AGENT.
Consequence & remedy
Consequence: A BROKEN CONTROL ARM CAN RESULT IN THE LOSS OF CONTROL OF THE VEHICLE, INCREASING THE RISK OF A CRASH.
Remedy: SUBARU WILL HANDLE THEIR VEHICLES AND SAAB WILL HANDLE THEIRS. DEALERS WILL INSPECT THE DEGREE OF CORROSION OF THE FRONT LOWER CONTROL ARMS, AND WILL EITHER RUSTPROOF OR REPLACE THEM. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING DECEMBER 2011. OWNERS MAY CONTACT SUBARU AT 1-800-782-2783. OWNERS MAY CONTACT SAAB AT 1-800-955-9007.
04V473000 · Engine And Engine Cooling
Oct 1, 2004
ON CERTAIN PASSENGER AND SPORT UTILITY VEHICLES, THE COVER BOLTS FOR THE ENGINE OIL CONTROL VALVE MAY NOT BE SUFFICIENTLY TIGHTENED, ALLOWING OIL TO LEAK FROM AROUND THE COVER GASKET.
Consequence & remedy
Consequence: IF LEAKING OIL CONTACTS COMPONENTS OPERATING AT HIGH TEMPERATURES, A FIRE COULD RESULT IN THE ENGINE COMPARTMENT.
Remedy: DEALERS WILL INSPECT AND RETIGHTEN THE OIL-FLOW CONTROL VALVE COVER BOLTS. THE RECALL BEGAN ON OCTOBER 8, 2004. OWNERS SHOULD CONTACT SUBARU AT 1-800-782-2783.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE11011 · Front Suspension Control Arm Failure
Opened Apr 7, 2011 · Closed Sep 23, 2011
Status: closed (inferred from source dates) · Suspension; Suspension:front; Suspension:front:control Arm; Suspension:front:control Arm:lower Arm
On September 6, 2011, Fuji Heavy Industries USA, Inc, on behalf of Subaru of America, Inc notified the Office of Defects Investigation (ODI) it would be conducting a safety recall of certain model year (MY) 2002 through 2007 Subaru Impreza, MY 2003 through 2008 Subaru Forester, and MY 2005 through 2006 Saab 9-2X vehicles originally sold or currently registered in one the salt belt states including the District of Columbia (DC). For the purpose of this investigation, salt belt states include Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin and DC.ODI's analysis of consumer complaint data identified 11 reports alleging failure of either the right or left lower control arm due to excessive corrosion. All of these complaints were associated with vehicles currently registered or originally sold in a salt belt state. Through a similar analysis of complaint and warranty data submitted to ODI by Subaru, ODI identified 18 consumer complaints and 6 warranty claims associated with failure of the left or right front lower control arm due to excessive corrosion. All of these consumer complaints associated with vehicles either currently registered of originally sold in a salt belt state.Accordingly, this investigation is closed.
Additional source detail variants (4)
Suspension:front:control Arm:lower Arm
On September 6, 2011, Fuji Heavy Industries USA, Inc, on behalf of Subaru of America, Inc notified the Office of Defects Investigation (ODI) it would be conducting a safety recall of certain model year (MY) 2002 through 2007 Subaru Impreza, MY 2003 through 2008 Subaru Forester, and MY 2005 through 2006 Saab 9-2X vehicles originally sold or currently registered in one the salt belt states including the District of Columbia (DC). For the purpose of this investigation, salt belt states include Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin and DC.ODI's analysis of consumer complaint data identified 11 reports alleging failure of either the right or left lower control arm due to excessive corrosion. All of these complaints were associated with vehicles currently registered or originally sold in a salt belt state. Through a similar analysis of complaint and warranty data submitted to ODI by Subaru, ODI identified 18 consumer complaints and 6 warranty claims associated with failure of the left or right front lower control arm due to excessive corrosion. All of these consumer complaints associated with vehicles either currently registered of originally sold in a salt belt state.Accordingly, this investigation is closed.
Suspension:front:control Arm
On September 6, 2011, Fuji Heavy Industries USA, Inc, on behalf of Subaru of America, Inc notified the Office of Defects Investigation (ODI) it would be conducting a safety recall of certain model year (MY) 2002 through 2007 Subaru Impreza, MY 2003 through 2008 Subaru Forester, and MY 2005 through 2006 Saab 9-2X vehicles originally sold or currently registered in one the salt belt states including the District of Columbia (DC). For the purpose of this investigation, salt belt states include Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin and DC.ODI's analysis of consumer complaint data identified 11 reports alleging failure of either the right or left lower control arm due to excessive corrosion. All of these complaints were associated with vehicles currently registered or originally sold in a salt belt state. Through a similar analysis of complaint and warranty data submitted to ODI by Subaru, ODI identified 18 consumer complaints and 6 warranty claims associated with failure of the left or right front lower control arm due to excessive corrosion. All of these consumer complaints associated with vehicles either currently registered of originally sold in a salt belt state.Accordingly, this investigation is closed.
Suspension:front
On September 6, 2011, Fuji Heavy Industries USA, Inc, on behalf of Subaru of America, Inc notified the Office of Defects Investigation (ODI) it would be conducting a safety recall of certain model year (MY) 2002 through 2007 Subaru Impreza, MY 2003 through 2008 Subaru Forester, and MY 2005 through 2006 Saab 9-2X vehicles originally sold or currently registered in one the salt belt states including the District of Columbia (DC). For the purpose of this investigation, salt belt states include Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin and DC.ODI's analysis of consumer complaint data identified 11 reports alleging failure of either the right or left lower control arm due to excessive corrosion. All of these complaints were associated with vehicles currently registered or originally sold in a salt belt state. Through a similar analysis of complaint and warranty data submitted to ODI by Subaru, ODI identified 18 consumer complaints and 6 warranty claims associated with failure of the left or right front lower control arm due to excessive corrosion. All of these consumer complaints associated with vehicles either currently registered of originally sold in a salt belt state.Accordingly, this investigation is closed.
Suspension
On September 6, 2011, Fuji Heavy Industries USA, Inc, on behalf of Subaru of America, Inc notified the Office of Defects Investigation (ODI) it would be conducting a safety recall of certain model year (MY) 2002 through 2007 Subaru Impreza, MY 2003 through 2008 Subaru Forester, and MY 2005 through 2006 Saab 9-2X vehicles originally sold or currently registered in one the salt belt states including the District of Columbia (DC). For the purpose of this investigation, salt belt states include Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin and DC.ODI's analysis of consumer complaint data identified 11 reports alleging failure of either the right or left lower control arm due to excessive corrosion. All of these complaints were associated with vehicles currently registered or originally sold in a salt belt state. Through a similar analysis of complaint and warranty data submitted to ODI by Subaru, ODI identified 18 consumer complaints and 6 warranty claims associated with failure of the left or right front lower control arm due to excessive corrosion. All of these consumer complaints associated with vehicles either currently registered of originally sold in a salt belt state.Accordingly, this investigation is closed.