IllustrationBAD RAW FUEL ODOR IN CABIN IN COLD WEATHER, HAS BEEN HAPPENING FOR WEEKS. WENT ONLINE, FOUND TONS OF SIMILAR COMPLAINTS, SUBARU OF AMERICA HAS NOT ISSUED A RECALL FOR THE 2003 FORESTER, EVEN THOUGH THIS IS A VERY COMMON AND DANGEROUS SAFETY PROBLEM. *JS
2003 Subaru Forester
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2003 Subaru Forester do not stand out strongly from the model-year median of 131.
About this comparison →How this year compares
Owner complaints by model year
Compare all Forester years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
200–25K
1525–50K
2550–75K
2575–100K
42100–150K
24150K+
151 reports with mileage · 38 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Fuel System, Gasoline. Review the 31 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel/propulsion System. Review the 26 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 25 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
17 crash reports0 fire reports9 injury reports
What owners actually said
189 reports2003 - SUBARU - FORESTER - BODY HARDWARE, FENDER, STRUCTURAL COMPONENTS & RAILS, LOWER FRAME LEFT IS COMPLETELY ROTTED THROUGH. THERE WAS A RECALL ON THE SUPPORT STRUT BESIDE IT BUT NONE ON THIS. THIS IS A MAJOR CRASH PROTECTION COMPONENT AS IT CONNECTS THE BUMPER TO THE FRAME. I TALKED TO THE DEALER ABOUT IT AND THEY SAID TH…
Read full complaint
2003 - SUBARU - FORESTER - BODY HARDWARE, FENDER, STRUCTURAL COMPONENTS & RAILS, LOWER FRAME LEFT IS COMPLETELY ROTTED THROUGH. THERE WAS A RECALL ON THE SUPPORT STRUT BESIDE IT BUT NONE ON THIS. THIS IS A MAJOR CRASH PROTECTION COMPONENT AS IT CONNECTS THE BUMPER TO THE FRAME. I TALKED TO THE DEALER ABOUT IT AND THEY SAID THERE IS NO RECALL SO IT IS MY PROBLEM. CLEARLY THE STEEL THAT WAS USED WAS SUBJECT TO EXCESSIVE CORROSION IN SALTY/HUMID ROAD CONDITIONS AND SHOULD HAVE BEEN INCLUDED AS PART OF THE ORIGINAL RECALL ON THE STRUT. THE OTHER SIDE (RIGHT) IS IN GOOD CONDITION, INDICATING DEFECTIVE MATERIALS IN THIS PART. *TR
THE TWO FRONT SUB FRAMES HAVE TO BE REPLACED DUE TO RUST AND THIN METAL. *TR
IN VERY COLD TEMPERATURES THE INTERIOR OF MY VEHICLE IS OVERCOME WITH FUEL FUMES. IT HAPPENS AT IDLE AND LOW SPEEDS, DOES GO AWAY ONCE WE ARE DRIVING FOR A FEW MINUTES OVER 30 MPH. IT IS SO BAD WE HAD TO DRIVE WITH WINDOWS OPEN IN 5 DEGREE WEATHER. DEFINITELY COMING IN THROUGH THE HEAT VENTS, HOWEVER, SHUTTING THE HEAT OFF DI…
Read full complaint
IN VERY COLD TEMPERATURES THE INTERIOR OF MY VEHICLE IS OVERCOME WITH FUEL FUMES. IT HAPPENS AT IDLE AND LOW SPEEDS, DOES GO AWAY ONCE WE ARE DRIVING FOR A FEW MINUTES OVER 30 MPH. IT IS SO BAD WE HAD TO DRIVE WITH WINDOWS OPEN IN 5 DEGREE WEATHER. DEFINITELY COMING IN THROUGH THE HEAT VENTS, HOWEVER, SHUTTING THE HEAT OFF DID NOT ELIMINATE THE PROBLEM. THIS IS MY FIRST WINTER WITH THE CAR AND DIDN'T HAVE THIS HAPPEN UNTIL THE LAST FEW DAYS, WHEN THE TEMPS HAVE BEEN CONSISTENTLY BELOW 30 DEGREES F. I'VE READ NUMEROUS OTHER COMPLAINTS OF THIS, NOT SURE WHY THERE IS NO RECALL/SERVICE BULLETIN BUT WOULD LIKE TO KNOW THE SOLUTION TO THE ISSUE. IT CAN'T BE SAFE TO BREATHE THESE FUMES! WOULD LIKE TO KNOW THE SOLUTION TO THIS PROBLEM, AS WE OTHERWISE LOVE THIS VEHICLE! *TR
WHEN TEMPERATURE DROPS TO LOW DOUBLE DIGITS (TEENS OR BELOW) THE CAB OF THE CAR BEGINS TO SMELL OF GASOLINE. I HAVE HAD IT INSPECTED BY A MECHANIC AND THEY CANNOT FIND A LEAK ANYWHERE IN THE FUEL LINE. IT GOES AWAY WHEN THE TEMPERATURE MOVES BACK TO WARMER TEMPERATURES. *TR
MY SON WAS DRIVING FROM NEW JERSEY. SUDDENLY THE FRONT HOOD OPENED AND CRASHED INTO THE WINDSHIELD. HE WAS ABLE TO MOVE OVER THREE LANES TO STOP THE CAR. THE WINDSHIELD WAS CRACKED. THIS WAS A HOOD REPLACEMENT DONE LAST SPRING AFTER A DEER RAN ACROSS THE VEHICLE. THE LATCH HAS NOT BEEN A PROBLEM UNTIL THIS TRIP. ON THE WAY…
Read full complaint
MY SON WAS DRIVING FROM NEW JERSEY. SUDDENLY THE FRONT HOOD OPENED AND CRASHED INTO THE WINDSHIELD. HE WAS ABLE TO MOVE OVER THREE LANES TO STOP THE CAR. THE WINDSHIELD WAS CRACKED. THIS WAS A HOOD REPLACEMENT DONE LAST SPRING AFTER A DEER RAN ACROSS THE VEHICLE. THE LATCH HAS NOT BEEN A PROBLEM UNTIL THIS TRIP. ON THE WAY TO NEW JERSEY, MY SON NOTICED THAT THE HOOD PARTIALLY OPENED. HE STOPPED THE CAR AND MADE SURE THAT THE HOOD WAS TIGHTLY SHUT. THE SAME REPAIR SHOP IS INSTALLING ANOTHER HOOD AND REPLACING THE WINDSHIELD. THERE IS NO COLLISION INSURANCE ON THE VEHICLE (SUBARU FORESTER 2003). MY TWO GRANDSONS WERE PASSENGERS IN THE BACK SEAT. MY SON'S FIANCEE WAS A PASSENGER IN THE FRONT SEAT. THE ONLY CRASH WAS THE BREAKING OF THE WINDSHIELD FROM THE HOOD. *TR
A RUBBER HOSE CONNECTING TWO METAL GAS LINES HAS STARTED TO LEAK. THIS IS DUE TO THE COLD WEATHER. SUBARU ISSUED A RECALL FOR THIS ON THE WRX MODELS OF THE SAME YEAR. THIS ENGINE IS THE SAME ENGINE AS IN THE WRX. IT IS THE 2.5 N/A. WHY ARE OUR MOTORS NOT BEING FIXED AS WELL? THIS IS A MAJOR FIRE HAZARD. IT IS NEAR THE IGNITION S…
Read full complaint
A RUBBER HOSE CONNECTING TWO METAL GAS LINES HAS STARTED TO LEAK. THIS IS DUE TO THE COLD WEATHER. SUBARU ISSUED A RECALL FOR THIS ON THE WRX MODELS OF THE SAME YEAR. THIS ENGINE IS THE SAME ENGINE AS IN THE WRX. IT IS THE 2.5 N/A. WHY ARE OUR MOTORS NOT BEING FIXED AS WELL? THIS IS A MAJOR FIRE HAZARD. IT IS NEAR THE IGNITION SYSTEM AND ABOVE THE EXHAUST PIPE. *JS
VERY STRONG FUEL SMELL WHEN COLD WEATHER. *JS
IN FREEZING WEATHER A VERY STRONG SMELL OF GASOLINE FILLS THE CAR. I HAVE YOUNG CHILDREN THAT RIDE IN THIS VEHICLE AND IT'S A HEALTH AND SAFETY HAZARD. *TR
WHEN TEMPERATURE IS LESS THAN 32, THE INSIDE OF THE CAR SMELLS LIKE GAS. IT GETS WORSE WHEN THE HEAT IS TURNED ON. FUMES ARE OVERWHELMING. *TR
Official recalls
311V464000 · Suspension:front:control Arm:lower Arm
Sep 6, 2011
SUBARU IS RECALLING CERTAIN MODEL YEAR 2002-2007 IMPREZA, MODEL YEAR 2003-2008 FORESTER, AND MODEL YEAR 2005-2006 SAAB 9-2X VEHICLES MANUFACTURED FROM SEPTEMBER 5, 2000 THROUGH NOVEMBER 26, 2007 ORIGINALLY SOLD, OR CURRENTLY REGISTERED IN, MASSACHUSETTS, MARYLAND, MICHIGAN, NEW HAMPSHIRE, NEW YORK, PENNSYLVANIA, VERMONT, WISCONSIN, CONNECTICUT, DELAWARE, IOWA, ILLINOIS, INDIANA, MAINE, MINNESOTA, MISSOURI, NEW JERSEY, OHIO, RHODE ISLAND, WEST VIRGINIA AND THE DISTRICT OF COLUMBIA. THE FRONT LOWER CONTROL ARMS MAY BREAK AT THE HANGER BRACKETS DUE TO CORROSION IF THE HANGER BRACKET IS EXPOSED TO SALTY AND HUMID ENVIRONMENTS SUCH AS ROADS CONTAINING SNOW MELTING AGENT.
Consequence & remedy
Consequence: A BROKEN CONTROL ARM CAN RESULT IN THE LOSS OF CONTROL OF THE VEHICLE, INCREASING THE RISK OF A CRASH.
Remedy: SUBARU WILL HANDLE THEIR VEHICLES AND SAAB WILL HANDLE THEIRS. DEALERS WILL INSPECT THE DEGREE OF CORROSION OF THE FRONT LOWER CONTROL ARMS, AND WILL EITHER RUSTPROOF OR REPLACE THEM. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING DECEMBER 2011. OWNERS MAY CONTACT SUBARU AT 1-800-782-2783. OWNERS MAY CONTACT SAAB AT 1-800-955-9007.
03V047000 · Seat Belts:front:buckle Assembly
Feb 20, 2003
CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES." THE LEFT AND RIGHT FRONT SEAT BELT BUCKLE/LATCH ASSEMBLIES WERE IMPROPERLY MANUFACTURED.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE FRONT SEAT BELTS COULD UNLATCH, WHICH COULD RESULT IN PERSONAL INJURY TO THE SEAT OCCUPANT.
Remedy: DEALERS WILL REPLACE THE LEFT AND RIGHT FRONT SEAT BELT BUCKLE/LATCH ASSEMBLIES. OWNER NOTIFICATION BEGAN FEBRUARY 19, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SUBARU AT 1-800-782-2783.
02V282000 · Power Train:automatic Transmission
Oct 30, 2002
CERTAIN SPORT UTILITY AND PASSENGER VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS WERE PRODUCED WITH AN IMPROPERLY MANUFACTURED TRANSMISSION PARKING ROD. WHEN THE TRANSMISSION SELECTOR LEVER IS PLACED IN THE "P" (PARK) POSITION, THE TRANSMISSION PARK MECHANISM, THAT IS INTENDED TO HOLD YOUR VEHICLE, MAY NOT ENGAGE.
Consequence & remedy
Consequence: THE VEHICLE COULD THEN MOVE/ROLL WITHOUT PRIOR WARNING, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE AUTOMATIC TRANSMISSION PARKING ROD ASSEMBLY. OWNER NOTIFICATION JANUARY 8, 2003. AN INTERIM OWNER NOTIFICATION WILL BE SENT DURING NOVEMBER 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SUBARU AT 1-800-782-2783.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE11011 · Front Suspension Control Arm Failure
Opened Apr 7, 2011 · Closed Sep 23, 2011
Status: closed (inferred from source dates) · Suspension; Suspension:front; Suspension:front:control Arm; Suspension:front:control Arm:lower Arm
On September 6, 2011, Fuji Heavy Industries USA, Inc, on behalf of Subaru of America, Inc notified the Office of Defects Investigation (ODI) it would be conducting a safety recall of certain model year (MY) 2002 through 2007 Subaru Impreza, MY 2003 through 2008 Subaru Forester, and MY 2005 through 2006 Saab 9-2X vehicles originally sold or currently registered in one the salt belt states including the District of Columbia (DC). For the purpose of this investigation, salt belt states include Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin and DC.ODI's analysis of consumer complaint data identified 11 reports alleging failure of either the right or left lower control arm due to excessive corrosion. All of these complaints were associated with vehicles currently registered or originally sold in a salt belt state. Through a similar analysis of complaint and warranty data submitted to ODI by Subaru, ODI identified 18 consumer complaints and 6 warranty claims associated with failure of the left or right front lower control arm due to excessive corrosion. All of these consumer complaints associated with vehicles either currently registered of originally sold in a salt belt state.Accordingly, this investigation is closed.
Additional source detail variants (4)
Suspension:front:control Arm:lower Arm
On September 6, 2011, Fuji Heavy Industries USA, Inc, on behalf of Subaru of America, Inc notified the Office of Defects Investigation (ODI) it would be conducting a safety recall of certain model year (MY) 2002 through 2007 Subaru Impreza, MY 2003 through 2008 Subaru Forester, and MY 2005 through 2006 Saab 9-2X vehicles originally sold or currently registered in one the salt belt states including the District of Columbia (DC). For the purpose of this investigation, salt belt states include Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin and DC.ODI's analysis of consumer complaint data identified 11 reports alleging failure of either the right or left lower control arm due to excessive corrosion. All of these complaints were associated with vehicles currently registered or originally sold in a salt belt state. Through a similar analysis of complaint and warranty data submitted to ODI by Subaru, ODI identified 18 consumer complaints and 6 warranty claims associated with failure of the left or right front lower control arm due to excessive corrosion. All of these consumer complaints associated with vehicles either currently registered of originally sold in a salt belt state.Accordingly, this investigation is closed.
Suspension:front:control Arm
On September 6, 2011, Fuji Heavy Industries USA, Inc, on behalf of Subaru of America, Inc notified the Office of Defects Investigation (ODI) it would be conducting a safety recall of certain model year (MY) 2002 through 2007 Subaru Impreza, MY 2003 through 2008 Subaru Forester, and MY 2005 through 2006 Saab 9-2X vehicles originally sold or currently registered in one the salt belt states including the District of Columbia (DC). For the purpose of this investigation, salt belt states include Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin and DC.ODI's analysis of consumer complaint data identified 11 reports alleging failure of either the right or left lower control arm due to excessive corrosion. All of these complaints were associated with vehicles currently registered or originally sold in a salt belt state. Through a similar analysis of complaint and warranty data submitted to ODI by Subaru, ODI identified 18 consumer complaints and 6 warranty claims associated with failure of the left or right front lower control arm due to excessive corrosion. All of these consumer complaints associated with vehicles either currently registered of originally sold in a salt belt state.Accordingly, this investigation is closed.
Suspension:front
On September 6, 2011, Fuji Heavy Industries USA, Inc, on behalf of Subaru of America, Inc notified the Office of Defects Investigation (ODI) it would be conducting a safety recall of certain model year (MY) 2002 through 2007 Subaru Impreza, MY 2003 through 2008 Subaru Forester, and MY 2005 through 2006 Saab 9-2X vehicles originally sold or currently registered in one the salt belt states including the District of Columbia (DC). For the purpose of this investigation, salt belt states include Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin and DC.ODI's analysis of consumer complaint data identified 11 reports alleging failure of either the right or left lower control arm due to excessive corrosion. All of these complaints were associated with vehicles currently registered or originally sold in a salt belt state. Through a similar analysis of complaint and warranty data submitted to ODI by Subaru, ODI identified 18 consumer complaints and 6 warranty claims associated with failure of the left or right front lower control arm due to excessive corrosion. All of these consumer complaints associated with vehicles either currently registered of originally sold in a salt belt state.Accordingly, this investigation is closed.
Suspension
On September 6, 2011, Fuji Heavy Industries USA, Inc, on behalf of Subaru of America, Inc notified the Office of Defects Investigation (ODI) it would be conducting a safety recall of certain model year (MY) 2002 through 2007 Subaru Impreza, MY 2003 through 2008 Subaru Forester, and MY 2005 through 2006 Saab 9-2X vehicles originally sold or currently registered in one the salt belt states including the District of Columbia (DC). For the purpose of this investigation, salt belt states include Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin and DC.ODI's analysis of consumer complaint data identified 11 reports alleging failure of either the right or left lower control arm due to excessive corrosion. All of these complaints were associated with vehicles currently registered or originally sold in a salt belt state. Through a similar analysis of complaint and warranty data submitted to ODI by Subaru, ODI identified 18 consumer complaints and 6 warranty claims associated with failure of the left or right front lower control arm due to excessive corrosion. All of these consumer complaints associated with vehicles either currently registered of originally sold in a salt belt state.Accordingly, this investigation is closed.