IllustrationFRONT CRADLE ARMS AND REAR CROSS MEMBERS ARE RUSTED TO THE POINT WHERE THE VEHICLE IS UNSAFE TO DRIVE DUE TO POSSIBLE SNAPPING. *TR
2003 Subaru Forester
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2003 Subaru Forester do not stand out strongly from the model-year median of 131.
About this comparison →How this year compares
Owner complaints by model year
Compare all Forester years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
200–25K
1525–50K
2550–75K
2575–100K
42100–150K
24150K+
151 reports with mileage · 38 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Fuel System, Gasoline. Review the 31 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel/propulsion System. Review the 26 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 25 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
17 crash reports0 fire reports9 injury reports
Structure complaints
19 reports2003 FORESTER HAS EXTREMELY STRONG AROMAS OF FUEL WHEN STARTING & DRIVING IN COLD WEATHER. FUEL VAPORS ARE VERY DANGEROUS, HERE ARE SIDE EFFECTS OF INHALATION: INHALING GASOLINE FUMES BRINGS CONCENTRATED HYDROCARBONS INTO YOUR LUNGS AND BLOODSTREAM. SOME OF THE INGREDIENTS IN GASOLINE ARE EXTREMELY TOXIC AND ARE MUTAGENS. LIVER …
Read full complaint
2003 FORESTER HAS EXTREMELY STRONG AROMAS OF FUEL WHEN STARTING & DRIVING IN COLD WEATHER. FUEL VAPORS ARE VERY DANGEROUS, HERE ARE SIDE EFFECTS OF INHALATION: INHALING GASOLINE FUMES BRINGS CONCENTRATED HYDROCARBONS INTO YOUR LUNGS AND BLOODSTREAM. SOME OF THE INGREDIENTS IN GASOLINE ARE EXTREMELY TOXIC AND ARE MUTAGENS. LIVER DAMAGE AND PERMANENT BRAIN DAMAGE ARE POSSIBILITIES. THE SIDE EFFECTS CAUSED BY THE INHALATION OF GASOLINE CAN RANGE FROM CENTRAL NERVOUS SYSTEM (CNS) DEPRESSION, WHICH CAN INCLUDE: EYE AND THROAT IRRITATION, MILD OR PRONOUNCED DIZZINESS, HEADACHE, LACK OF APPETITE, DROWSINESS AND IN-COORDINATION. IN MORE SERIOUS CIRCUMSTANCES, IT CAN CAUSE UNCONSCIOUSNESS, PULMONARY EDEMA, AND DEATH. SUBARU SHOULD ISSUE A RECALL AND ADDRESS THE ISSUE, BECAUSE THEY INSTALLED A DEFECTIVE PRODUCT! *TR
MY 2003 FORESTER HAS RECENTLY BEEN EXPERIENCING EXTREMELY STRONG SMELLS OF FUEL WHEN DRIVING IN THE COLD WEATHER. INHALING FUEL VAPORS ARE VERY DANGEROUS, HERE ARE SIDE EFFECTS ASSOCIATED WITH INHALATION OF FUMES: INHALING GASOLINE FUMES BRINGS CONCENTRATED HYDROCARBONS INTO YOUR LUNGS AND BLOODSTREAM. SOME OF THE INGREDIENTS IN…
Read full complaint
MY 2003 FORESTER HAS RECENTLY BEEN EXPERIENCING EXTREMELY STRONG SMELLS OF FUEL WHEN DRIVING IN THE COLD WEATHER. INHALING FUEL VAPORS ARE VERY DANGEROUS, HERE ARE SIDE EFFECTS ASSOCIATED WITH INHALATION OF FUMES: INHALING GASOLINE FUMES BRINGS CONCENTRATED HYDROCARBONS INTO YOUR LUNGS AND BLOODSTREAM. SOME OF THE INGREDIENTS IN GASOLINE ARE EXTREMELY TOXIC AND ARE MUTAGENS. LIVER DAMAGE AND PERMANENT BRAIN DAMAGE ARE POSSIBILITIES. THE SIDE EFFECTS CAUSED BY THE INHALATION OF GASOLINE CAN RANGE FROM CENTRAL NERVOUS SYSTEM (CNS) DEPRESSION, WHICH CAN INCLUDE: EYE AND THROAT IRRITATION, MILD OR PRONOUNCED DIZZINESS, HEADACHE, LACK OF APPETITE, DROWSINESS AND IN-COORDINATION. IN MORE SERIOUS CIRCUMSTANCES, IT CAN CAUSE UNCONSCIOUSNESS, PULMONARY EDEMA, AND DEATH. SUBARU SHOULD ISSUE A RECALL AND ADDRESS THE ISSUE!! *TR
I HAD MY VEHICLE SERVICED AT RAMSEY SUBARU AND WAS TOLD THE FRONT SUB FRAME IS RUSTED AND NEEDS TO BE REPAIRED. IT SEEMS MORE LIKE THE THIN CHEAP METAL IS THE PROBLEM. THIS IS A BIG SAFETY PROBLEM AND THEY TOLD ME THE WARRANTY IS ONLY GOOD FOR 5 YEARS. *TR
TL* THE CONTACT OWNS A 2003 SUBARU FORESTER. THE CONTACT STATED THAT WHILE THE VEHICLE WAS BEING INSPECTED, IT WAS DISCOVERED THAT THE FRONT PASSENGER WHEEL ASSEMBLY WAS FOUND SEVERELY CORRODED. THE VEHICLE WAS REPAIRED. THE FRONT WHEEL ASSEMBLY WAS REPLACED. THE FAILURE MILEAGE WAS 180,000 AND THE CURRENT MILEAGE WAS 183,000. …
Read full complaint
TL* THE CONTACT OWNS A 2003 SUBARU FORESTER. THE CONTACT STATED THAT WHILE THE VEHICLE WAS BEING INSPECTED, IT WAS DISCOVERED THAT THE FRONT PASSENGER WHEEL ASSEMBLY WAS FOUND SEVERELY CORRODED. THE VEHICLE WAS REPAIRED. THE FRONT WHEEL ASSEMBLY WAS REPLACED. THE FAILURE MILEAGE WAS 180,000 AND THE CURRENT MILEAGE WAS 183,000. UPDATED 7/9/12 *CN THE RIGHT SIDE FRAME ASSEMBLY WAS RUSTED AND CORRODED. UPDATED 07/10/12
TL* THE CONTACT OWNS A 2003 SUBARU FORESTER.THE CONTACT STATED THAT THE VEHICLE WAS REPAIRED UNDER NHTSA CAMPAIGN ID NUMBER: 11V464000 (SUSPENSION: FRONT: CONTROL ARM: LOWER ARM) WHEN THE CONTACT WAS ADVISED THAT THE FRONT END OF THE SUB-FRAME WAS CORRODED. THE MANUFACTURER ADVISED THE CONTACT THAT THE FAILURE WAS NOT COVERED UN…
Read full complaint
TL* THE CONTACT OWNS A 2003 SUBARU FORESTER.THE CONTACT STATED THAT THE VEHICLE WAS REPAIRED UNDER NHTSA CAMPAIGN ID NUMBER: 11V464000 (SUSPENSION: FRONT: CONTROL ARM: LOWER ARM) WHEN THE CONTACT WAS ADVISED THAT THE FRONT END OF THE SUB-FRAME WAS CORRODED. THE MANUFACTURER ADVISED THE CONTACT THAT THE FAILURE WAS NOT COVERED UNDER THE RECALL. THE VEHICLE WAS NOT REPAIRED FOR THE FRAME ISSUE. THE FAILURE MILEAGE WAS 157,000 AND CURRENT MILEAGE WAS 160,000. UPDATED 05/08/12*LJ
WE TOOK OUR 2003 SUBARU FORESTER IN TO THE DEALERSHIP FOR AN OIL CHANGE AND WAS TOLD THAT THE FRAME OF THE CAR WAS IN "SERIOUS" CONDITION AND NEEDED TO BE REPLACED. A PHOTO WAS TAKEN AND SENT TO THE DISTRICT MANAGER FOR HIS REVIEW. WE REPLACED THE CONTROL ARMS ON OUR OWN IN DECEMBER 2011. TOOK THE CAR IN TO OUR DEALERSHIP…
Read full complaint
WE TOOK OUR 2003 SUBARU FORESTER IN TO THE DEALERSHIP FOR AN OIL CHANGE AND WAS TOLD THAT THE FRAME OF THE CAR WAS IN "SERIOUS" CONDITION AND NEEDED TO BE REPLACED. A PHOTO WAS TAKEN AND SENT TO THE DISTRICT MANAGER FOR HIS REVIEW. WE REPLACED THE CONTROL ARMS ON OUR OWN IN DECEMBER 2011. TOOK THE CAR IN TO OUR DEALERSHIP IN JANUARY 2012 FOR RECALL OF CONTROL ARMS AND NOTHING WAS SAID ABOUT THE FRAME AT THAT TIME. MECHANIC STATED YOU CAN PUT YOUR FINGER INTO THE HOLE IN THE FRAME OF THE CAR. FORESTER WAS NEVER DRIVEN OFF-ROAD AND WAS DRIVEN SOLELY IN THE CITY. THE FRAME SHOULD NOT HAVE RUSTED OUT THROUGH NORMAL WEAR AND TEAR. WINTER THIS YEAR WAS VERY MILD. PLEASE INVESTIGATE THIS AS FRAMES ON CARS SHOULD NOT DEVELOP HOLES. *TR
TL* THE CONTACT OWNS A 2003 SUBARU FORESTER . THE CONTACT STATED THAT HE RECEIVED NOTIFICATION OF NHTSA CAMPAIGN ID NUMBER: 11V464000. (SUSPENSION: FRONT:CONTROL ARM:LOWER ARM) AND THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR REPAIRS. THE DEALER ADVISED THE CONTACT THAT THE REPAIR COULD NOT BE PERFORMED BECAUSE THE SUB FRAM…
Read full complaint
TL* THE CONTACT OWNS A 2003 SUBARU FORESTER . THE CONTACT STATED THAT HE RECEIVED NOTIFICATION OF NHTSA CAMPAIGN ID NUMBER: 11V464000. (SUSPENSION: FRONT:CONTROL ARM:LOWER ARM) AND THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR REPAIRS. THE DEALER ADVISED THE CONTACT THAT THE REPAIR COULD NOT BE PERFORMED BECAUSE THE SUB FRAME WAS RUSTED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND THE CURRENT MILEAGE WAS 69,000. UPDATED 03/28/12*LJ THE CONSUMER STATED AFTER CONTACTING SUBARU OF AMERICA, THEY AGREED TO COVER ALL COSTS ASSOCIATED WITH THE REPAIR, INCLUDING THE REPLACEMENT OF THE SUBFRAME. UPDATED 03/30/12*JB
TL*THE CONTACT OWNS A 2003 SUBARU FORESTER. WHILE DRIVING APPROXIMATELY 65 MPH, THE FRONT HOOD RELEASED UNEXPECTEDLY. THE CONTACT WAS ABLE TO CONTROL AND DIRECT THE VEHICLE TO THE SIDE OF THE ROAD. THE POLICE ARRIVED TO ESCORT THE VEHICLE OFF THE HIGHWAY, WHICH WAS A STATE REGULATION, AND FILED A REPORT. THE VEHICLE WAS TOWE…
Read full complaint
TL*THE CONTACT OWNS A 2003 SUBARU FORESTER. WHILE DRIVING APPROXIMATELY 65 MPH, THE FRONT HOOD RELEASED UNEXPECTEDLY. THE CONTACT WAS ABLE TO CONTROL AND DIRECT THE VEHICLE TO THE SIDE OF THE ROAD. THE POLICE ARRIVED TO ESCORT THE VEHICLE OFF THE HIGHWAY, WHICH WAS A STATE REGULATION, AND FILED A REPORT. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER FOR REPAIR. THE CONTACT STATED THAT THE FAILURE WAS RELATED TO THE TWO BOLTS THAT ATTACHED THE HOOD. THE FAILURE AND CURRENT MILEAGES WERE 130,000.
Official recalls
311V464000 · Suspension:front:control Arm:lower Arm
Sep 6, 2011
SUBARU IS RECALLING CERTAIN MODEL YEAR 2002-2007 IMPREZA, MODEL YEAR 2003-2008 FORESTER, AND MODEL YEAR 2005-2006 SAAB 9-2X VEHICLES MANUFACTURED FROM SEPTEMBER 5, 2000 THROUGH NOVEMBER 26, 2007 ORIGINALLY SOLD, OR CURRENTLY REGISTERED IN, MASSACHUSETTS, MARYLAND, MICHIGAN, NEW HAMPSHIRE, NEW YORK, PENNSYLVANIA, VERMONT, WISCONSIN, CONNECTICUT, DELAWARE, IOWA, ILLINOIS, INDIANA, MAINE, MINNESOTA, MISSOURI, NEW JERSEY, OHIO, RHODE ISLAND, WEST VIRGINIA AND THE DISTRICT OF COLUMBIA. THE FRONT LOWER CONTROL ARMS MAY BREAK AT THE HANGER BRACKETS DUE TO CORROSION IF THE HANGER BRACKET IS EXPOSED TO SALTY AND HUMID ENVIRONMENTS SUCH AS ROADS CONTAINING SNOW MELTING AGENT.
Consequence & remedy
Consequence: A BROKEN CONTROL ARM CAN RESULT IN THE LOSS OF CONTROL OF THE VEHICLE, INCREASING THE RISK OF A CRASH.
Remedy: SUBARU WILL HANDLE THEIR VEHICLES AND SAAB WILL HANDLE THEIRS. DEALERS WILL INSPECT THE DEGREE OF CORROSION OF THE FRONT LOWER CONTROL ARMS, AND WILL EITHER RUSTPROOF OR REPLACE THEM. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING DECEMBER 2011. OWNERS MAY CONTACT SUBARU AT 1-800-782-2783. OWNERS MAY CONTACT SAAB AT 1-800-955-9007.
03V047000 · Seat Belts:front:buckle Assembly
Feb 20, 2003
CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES." THE LEFT AND RIGHT FRONT SEAT BELT BUCKLE/LATCH ASSEMBLIES WERE IMPROPERLY MANUFACTURED.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE FRONT SEAT BELTS COULD UNLATCH, WHICH COULD RESULT IN PERSONAL INJURY TO THE SEAT OCCUPANT.
Remedy: DEALERS WILL REPLACE THE LEFT AND RIGHT FRONT SEAT BELT BUCKLE/LATCH ASSEMBLIES. OWNER NOTIFICATION BEGAN FEBRUARY 19, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SUBARU AT 1-800-782-2783.
02V282000 · Power Train:automatic Transmission
Oct 30, 2002
CERTAIN SPORT UTILITY AND PASSENGER VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS WERE PRODUCED WITH AN IMPROPERLY MANUFACTURED TRANSMISSION PARKING ROD. WHEN THE TRANSMISSION SELECTOR LEVER IS PLACED IN THE "P" (PARK) POSITION, THE TRANSMISSION PARK MECHANISM, THAT IS INTENDED TO HOLD YOUR VEHICLE, MAY NOT ENGAGE.
Consequence & remedy
Consequence: THE VEHICLE COULD THEN MOVE/ROLL WITHOUT PRIOR WARNING, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE AUTOMATIC TRANSMISSION PARKING ROD ASSEMBLY. OWNER NOTIFICATION JANUARY 8, 2003. AN INTERIM OWNER NOTIFICATION WILL BE SENT DURING NOVEMBER 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SUBARU AT 1-800-782-2783.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE11011 · Front Suspension Control Arm Failure
Opened Apr 7, 2011 · Closed Sep 23, 2011
Status: closed (inferred from source dates) · Suspension; Suspension:front; Suspension:front:control Arm; Suspension:front:control Arm:lower Arm
On September 6, 2011, Fuji Heavy Industries USA, Inc, on behalf of Subaru of America, Inc notified the Office of Defects Investigation (ODI) it would be conducting a safety recall of certain model year (MY) 2002 through 2007 Subaru Impreza, MY 2003 through 2008 Subaru Forester, and MY 2005 through 2006 Saab 9-2X vehicles originally sold or currently registered in one the salt belt states including the District of Columbia (DC). For the purpose of this investigation, salt belt states include Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin and DC.ODI's analysis of consumer complaint data identified 11 reports alleging failure of either the right or left lower control arm due to excessive corrosion. All of these complaints were associated with vehicles currently registered or originally sold in a salt belt state. Through a similar analysis of complaint and warranty data submitted to ODI by Subaru, ODI identified 18 consumer complaints and 6 warranty claims associated with failure of the left or right front lower control arm due to excessive corrosion. All of these consumer complaints associated with vehicles either currently registered of originally sold in a salt belt state.Accordingly, this investigation is closed.
Additional source detail variants (4)
Suspension:front:control Arm:lower Arm
On September 6, 2011, Fuji Heavy Industries USA, Inc, on behalf of Subaru of America, Inc notified the Office of Defects Investigation (ODI) it would be conducting a safety recall of certain model year (MY) 2002 through 2007 Subaru Impreza, MY 2003 through 2008 Subaru Forester, and MY 2005 through 2006 Saab 9-2X vehicles originally sold or currently registered in one the salt belt states including the District of Columbia (DC). For the purpose of this investigation, salt belt states include Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin and DC.ODI's analysis of consumer complaint data identified 11 reports alleging failure of either the right or left lower control arm due to excessive corrosion. All of these complaints were associated with vehicles currently registered or originally sold in a salt belt state. Through a similar analysis of complaint and warranty data submitted to ODI by Subaru, ODI identified 18 consumer complaints and 6 warranty claims associated with failure of the left or right front lower control arm due to excessive corrosion. All of these consumer complaints associated with vehicles either currently registered of originally sold in a salt belt state.Accordingly, this investigation is closed.
Suspension:front:control Arm
On September 6, 2011, Fuji Heavy Industries USA, Inc, on behalf of Subaru of America, Inc notified the Office of Defects Investigation (ODI) it would be conducting a safety recall of certain model year (MY) 2002 through 2007 Subaru Impreza, MY 2003 through 2008 Subaru Forester, and MY 2005 through 2006 Saab 9-2X vehicles originally sold or currently registered in one the salt belt states including the District of Columbia (DC). For the purpose of this investigation, salt belt states include Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin and DC.ODI's analysis of consumer complaint data identified 11 reports alleging failure of either the right or left lower control arm due to excessive corrosion. All of these complaints were associated with vehicles currently registered or originally sold in a salt belt state. Through a similar analysis of complaint and warranty data submitted to ODI by Subaru, ODI identified 18 consumer complaints and 6 warranty claims associated with failure of the left or right front lower control arm due to excessive corrosion. All of these consumer complaints associated with vehicles either currently registered of originally sold in a salt belt state.Accordingly, this investigation is closed.
Suspension:front
On September 6, 2011, Fuji Heavy Industries USA, Inc, on behalf of Subaru of America, Inc notified the Office of Defects Investigation (ODI) it would be conducting a safety recall of certain model year (MY) 2002 through 2007 Subaru Impreza, MY 2003 through 2008 Subaru Forester, and MY 2005 through 2006 Saab 9-2X vehicles originally sold or currently registered in one the salt belt states including the District of Columbia (DC). For the purpose of this investigation, salt belt states include Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin and DC.ODI's analysis of consumer complaint data identified 11 reports alleging failure of either the right or left lower control arm due to excessive corrosion. All of these complaints were associated with vehicles currently registered or originally sold in a salt belt state. Through a similar analysis of complaint and warranty data submitted to ODI by Subaru, ODI identified 18 consumer complaints and 6 warranty claims associated with failure of the left or right front lower control arm due to excessive corrosion. All of these consumer complaints associated with vehicles either currently registered of originally sold in a salt belt state.Accordingly, this investigation is closed.
Suspension
On September 6, 2011, Fuji Heavy Industries USA, Inc, on behalf of Subaru of America, Inc notified the Office of Defects Investigation (ODI) it would be conducting a safety recall of certain model year (MY) 2002 through 2007 Subaru Impreza, MY 2003 through 2008 Subaru Forester, and MY 2005 through 2006 Saab 9-2X vehicles originally sold or currently registered in one the salt belt states including the District of Columbia (DC). For the purpose of this investigation, salt belt states include Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin and DC.ODI's analysis of consumer complaint data identified 11 reports alleging failure of either the right or left lower control arm due to excessive corrosion. All of these complaints were associated with vehicles currently registered or originally sold in a salt belt state. Through a similar analysis of complaint and warranty data submitted to ODI by Subaru, ODI identified 18 consumer complaints and 6 warranty claims associated with failure of the left or right front lower control arm due to excessive corrosion. All of these consumer complaints associated with vehicles either currently registered of originally sold in a salt belt state.Accordingly, this investigation is closed.