2003 Subaru Forester

TL* THE CONTACT OWNS A 2003 SUBARU FORESTER. THE CONTACT STATED THAT WHILE OPERATING THE VEHICLE DURING COLD WEATHER, AN ODOR OF FUEL WAS PRESENT INSIDE THE VEHICLE. THE FAILURE WOULD ONLY OCCUR IN TEMPERATURES BELOW 25 DEGREES. THE VEHICLE WAS TAKEN TO NEIL HUFFMAN SUBARU DEALER LOCATED AT 4916 DIXIE HWY, LOUISVILLE, KY 40216 WHO TIGHTEN AND RE-CLAMPED THE FUEL LINES BUT THE FAILURES CONTINUED TO OCCURRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 114,000. *TT *TR

IN VERY COLD TEMPERATURES THE INTERIOR OF MY VEHICLE IS OVERCOME WITH FUEL FUMES. IT HAPPENS AT IDLE AND LOW SPEEDS, DOES GO AWAY ONCE WE ARE DRIVING FOR A FEW MINUTES OVER 30 MPH. IT IS SO BAD WE HAD TO DRIVE WITH WINDOWS OPEN IN 5 DEGREE WEATHER. DEFINITELY COMING IN THROUGH THE HEAT VENTS, HOWEVER, SHUTTING THE HEAT OFF DID NOT ELIMINATE THE PROBLEM. THIS IS MY FIRST WINTER WITH THE CAR AND DIDN'T HAVE THIS HAPPEN UNTIL THE LAST FEW DAYS, WHEN THE TEMPS HAVE BEEN CONSISTENTLY BELOW 30 DEGREES F. I'VE READ NUMEROUS OTHER COMPLAINTS OF THIS, NOT SURE WHY THERE IS NO RECALL/SERVICE BULLETIN BUT WOULD LIKE TO KNOW THE SOLUTION TO THE ISSUE. IT CAN'T BE SAFE TO BREATHE THESE FUMES! WOULD LIKE TO KNOW THE SOLUTION TO THIS PROBLEM, AS WE OTHERWISE LOVE THIS VEHICLE! *TR

NOTICED THE SAME PROBLEM LAST YEAR ALSO AT ABOUT 134000 MILES. WHEN THE OUTSIDE TEMPERATURE DROPS BELOW 20 DEGREES WOULD BE MY BEST GUESS, THE WHOLE CAB OF THE CAR FILLS WITH GASOLINE FUMES. PRETTY POWERFUL SMELL. I NOTICE ONLINE IN MANY, MANY PLACES THAT SUBARU IS HAVING THIS ISSUE. THEY ARE ONLY FIXING WRX MODELS UNDER A RECALL. THAT IS MY UNDERSTANDING. UNFORTUNATELY, I DO NOT HAVE A WRX. I WILL PAY TO HAVE THIS FIXED, THOUGH SUBARU SHOULD STEP UP TO ALL MODELS WITH THIS VERY DETRIMENTAL ISSUE. THE DEALER IS ACTING A LITTLE SUSPICIOUS DENYING THEY KNOW ABOUT THE PROBLEM. SEEMS LIKE THEY SHOULD KNOW ABOUT ALL ISSUES THAT ARE SO PROMINENT ON THE INTERNET. MOST ARTICLES POINT TO FUEL LINES AT INTAKE MANIFOLD ARE FAILING. FAILING WOULD DEMAND TSB. *TR

DURING COLD WEATHER, (LATEST INCIDENT OCCURRED AT 15 DEGREES F), THERE IS A STRONG FUEL ODOR INSIDE THE VEHICLE WHILE THE VEHICLE IS RUNNING COMING FROM THE AIR VENTS INSIDE THE VEHICLE. AFTER STOPPING THE VEHICLE INSIDE OUR GARAGE THE STRONG FUEL ODOR CONTINUES UNTIL GRADUALLY LESSENING. A VISUAL INSPECTION DOES NOT REVEAL AN OBVIOUS FUEL LEAK. OTHER SUBARU MODELS WERE RECALLED FOR A SIMILAR PROBLEM AND AN ONLINE SEARCH SUGGESTS THIS IS NOT AN ISOLATED EVENT TO MY PARTICULAR VEHICLE. *TR

VERY STRONG ODOR OF GASOLINE IN THE CABIN RIGHT AFTER STARTUP AND THROUGHOUT SHORT TRIPS, ESPECIALLY WITH HEATER ON. SEEMS TO HAPPEN MOST OFTEN WHEN OUTSIDE TEMPERATURES ARE NEAR OR BELOW THE FREEZING MARK. DID NOT EXPERIENCE BEFORE THIS WINTER, NOW OCCURS DAILY. PLEASE INVESTIGATE THIS PROBLEM BEFORE SOMEONE GETS HURT OR KILLED! IF SUBARU KNOWS THAT THERE IS A SAFETY PROBLEM WITH THE FUEL SYSTEM, OWNERS SHOULD NOT HAVE TO PAY FOR REPAIRS. *TR

STRONG SMELL OF GASOLINE UNDER HOOD WHEN STARTING CAR COLD. AUTO REPAIR CENTER FOUND LEAKING FUEL LINE. TIGHTENED CLAMPS. THEN THE FOLLOWING WINTER, 1.24.14 AGAIN SMELLED RAW FUEL SMELL WHEN STARTED ENGINE COLD. AUTO REPAIR DID A PRESSURE TEST OF FUEL SYSTEM AND TRACED LEAKS TO FUEL RAIL ON TOP OF ENGINE/ LEFT CYLINDER HEAD INJECTOR RAIL. AUTO CENTER OWNER SAID HE HAD 7 SUBARU OWNERS WITH THE SAME ISSUE IN THE LAST FEW DAYS WITH THE EXTREME COLD TEMPERATURES. *TR

THIS PAST WEEK, WITH THE TEMPERATURES HERE IN NEW JERSEY DIPPING INTO THE TEENS, I SMELLED THE DISTINCT ODOR OF GASOLINE IN MY 2003 SUBARU FORESTER IN MY DRIVEWAY BEFORE I HIT THE ROAD. THE SMELL WAS SO STRONG, I HAD TO TURN BACK HOME AS MY CHILDREN WERE NOT FEELING WELL FROM THE SMELL. THIS HAD HAPPENED BEFORE, BUT NEVER TO THIS DEGREE. I WENT TO THE SUBARU SERVICE DEPARTMENT AND WAS TOLD THAT THEY HAD RECEIVED MANY CALLS ABOUT THIS SAME ISSUE. HE INDICATED THAT THE COLD WEATHER CAUSED THE LINES TO CONTRACT AND ALLOWED GASOLINE TO LEAK ONTO THE ENGINE. HE SAID THAT THE AS THE WEATHER WARMED UP, THE LINES WOULD EXPAND AGAIN, THUS MINIMIZING THE PROBLEM. HOWEVER, HE SAID THAT THE ONLY WAY TO CORRECT THE PROBLEM WAS TO HAVE THE LINES CHANGED. WHEN I ASKED IF IT WAS A HAZARD TO CONTINUE DRIVING THE VEHICLE UNTIL I COULD HAVE THE LINES REPLACED, HE SUGGESTED THAT I LIMIT MY DRIVING SINCE GASOLINE DRIPPING ONTO A HOT ENGINE WAS DANGEROUS. I ASKED IF THERE WAS A RECALL FOR THE LINES, AND HE STATED NO. SINCE THIS IS A DANGEROUS SITUATION AND NOT EVIDENT IN LATER MODELS OF SUBARU, I THINK THAT OTHER OWNERS SHOULD BE MADE AWARE. *TR

WHEN I START MY 2003 SUBARU FORESTER IN VERY COLD WEATHER THERE IS A STRONG FUEL SMELL IN THE CABIN OF THE CAR COMING THROUGH THE VENTS. I KNOW THAT NHTSA ISSUED A TSB ON 2002-2004 SUBARU WXT MODELS BUT DID NOT INCLUDE THE FORESTER, OUTBACK, AND LEGACY OF THOSE YEARS, WHY? IT IS THE SAME FUEL PROPULSION LAYOUT AND THE RUBBER HOSE CONNECTION AT THE STEEL LINE IS WHERE THE LEAK HAPPENS IN COLD WEATHER. I HAVE HAD THIS PROBLEM SERVICED 4 OF THE 5 PAST YEARS AND HAD INJECTORS REPLACED WHEN NOW I KNOW IT IS ACTUALLY THE RUBBER HOSE SHRINKS BACK IN COLD WEATHER THUS THE GAS DRIPS AND POOLS ON THE MANIFOLD. THE WHOLE FUEL LINE SYSTEM NEEDS TO BE REPLACED. I STRONGLY BELIEVE THAT YOU SHOULD HAVE A TSB FOR ALL 2002 - 2004 SUBARU MODELS THAT USE THE SAME FUEL PROPULSION LAYOUT AS THE 2002 - 2004 WXT DID. IF YOU GOOGLE '2003 SUBARU FORESTER GAS SMELL' YOU WILL SEE HUNDREDS OF COMPLAINTS AND QUESTIONS ABOUT THIS ISSUE, I AND ALL THE OTHER OWNERS OF THESE 2002 ' 2004 MODEL SUBARU'S SHOULD NOT HAVE TO PAY CONTINUOUSLY FOR REPAIRS THAT WILL KEEP ON HAPPENING EVERY WINTER UNTIL THE LINES ARE REPLACED. WHEN WILL THE RECALL HAPPEN? ARE YOU GOING TO WAIT UNTIL A CHILD / FAMILY DIES FROM A CAR EXPLOSION OF AN UNKNOWING FAMILY DRIVING DOWN THE ROAD WHEN THE CAR CATCHES FIRE OR EXPLODES BECAUSE OF THIS PROBLEM? IF YOU LIVED IN A HOUSE WITH A GAS LEAK YOU WOULD GET IT FIXED RIGHT AWAY, WOULDN'T THIS BE THE SAME ABOUT YOUR CAR? THIS NEEDS TO BE DONE A.S.A.P. *TR