ON CERTAIN TRAILERS EQUIPPED WITH BENDIX EC-30T ELECTRONIC CONTROL UNITS (ECU). IF THE TRAILER-MOUNTED ABS WARNING LAMP CIRCUIT EXPERIENCES AN ELECTRICAL SHORT AND THE SHORT IS NOT REPAIRED, THE HIGH SIDE POWER SWITCH INSIDE THE ECU THAT CONTROLS THE ILLUMINATION OF THE TRAILER-MOUNTED ABS WARNING LAMP MAY EVENTUALLY BECOME THERMALLY STRESSED AND EXPERIENCE AN ELECTRICAL SHORT.
Consequence & remedy
Consequence: IF THE POWER SWITCH SHORTS, IT CAN RESULT IN AN OVER-CURRENT CONDITION IN THE ECU AND LEAD TO EXCESSIVE HEAT, SMOKE, AND POSSIBLE FIRE.
Remedy: BENDIX WILL PROVIDE A REMEDY KIT AND DETAILED INSTRUCTIONS AND ALSO PROVIDE A LABOR ALLOWANCE FOR THE REPAIR. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BENDIX AT 1-800-478-1793 OR STRICK AT 1-215-949-3600.
ON CERTAIN TRAILERS EQUIPPED WITH BENDIX SR-2, SR-4, AND SR-5 TRAILER SPRING BRAKE VALVE ASSEMBLIES, THE MOLDED RUBBER FACE OF THE INLET/EXHAUST VALVE (I/E VALVE) COMPONENT OF THE AFFECTED VALVES CAN SEPARATE FROM THE VALVE'S METAL INSERT. AIR CAN BE TRAPPED BY A SEPARATED I/E VALVE CAUSING IT TO BALLOON AND BLOCK THE EXHAUST PASSAGE OF THE TRAILER SPRING BRAKE CIRCUIT.
Consequence & remedy
Consequence: THIS CONDITION CAN RESULT IN THE AFFECTED VEHICLES BEING UNABLE TO APPLY THE TRAILER PARKING/EMERGENCY SPRING BRAKES DURING PARKING IN THE EVENT OF A TRAILER SUPPLY LINE FAILURE. UNINTENDED ROLLAWAY COULD OCCUR, POSSIBLY RESULTING IN PERSONAL INJURY OR DEATH TO THE VEHICLE OCCUPANT OR ANY BYSTANDERS.
Remedy: BENDIX WILL NOTIFY CUSTOMERS AND PROVIDE A REPAIR KIT AND INSTALLATION INSTRUCTIONS FREE OF CHARGE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BENDIX AT 440-329-9000 OR STRICK AT 704-436-2441.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTED OR CONTINUES TO EXIST.FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE AGENCY WILL CONTINUE TO MONITOR THIS PROBLEM CLOSELY AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED TECHNICAL REPORT FOR FULL DETAILS.
Additional source detail variants (3)
Suspension:multiple Axle
THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTED OR CONTINUES TO EXIST.FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE AGENCY WILL CONTINUE TO MONITOR THIS PROBLEM CLOSELY AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED TECHNICAL REPORT FOR FULL DETAILS.
SUSPENSION:REAR:AXLE:NON-POWERED Axle Assembly
THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTED OR CONTINUES TO EXIST.FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE AGENCY WILL CONTINUE TO MONITOR THIS PROBLEM CLOSELY AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED TECHNICAL REPORT FOR FULL DETAILS.
Wheels:hub
THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTED OR CONTINUES TO EXIST.FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE AGENCY WILL CONTINUE TO MONITOR THIS PROBLEM CLOSELY AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED TECHNICAL REPORT FOR FULL DETAILS.
ODI OPENED THIS INVESTIGATION BASED ON A FLEET COMPLAINT WHERE INFORMATION WAS FURNISHED INDICATING THAT WHEEL BEARINGS WERE FAILING AT AN UNUSUALLY HIGH RATE.IN 29 CASES THESE FAILURES ALLEGEDLY RESULTED IN A WHEEL END FIRE OR A WHEEL SEPARATION.DURING THE INVESTIGATION IT WAS DETERMINED THAT THE SUBJECT VEHICLES WERE BUILT WITH LOW MAINTENANCE WHEEL ENDS.DOCUMENTS OBTAINED BY ODI INDICATE THAT WIDESPREAD CONFUSION EXISTED IN THIS INDUSTRY CONCERNING MAINTENANCE REQUIREMENTS.THE ISSUES WERE:FREQUENCY OF MAINTENANCE, AMOUNT OF GREASE TO BE USED, AND PROPER METHOD OF INSPECTION.SEVERAL MEETINGS WERE HELD INVOLVING THE AXLE MANUFACTURER, (ARVINMERITOR), LUBRICATION MANUFACTURER (MOBIL), SEVERAL TRAILER MANUFACTURERS AND FLEETS.CURRENTLY ODI HAS DATA WHICH INDICATES THAT 255 TRAILERS FROM A CERTAIN BUILD PERIOD HAVE WHEEL ENDS FAILING AT A HIGHER RATE THAN PEER TRAILERS WITH THE SAME WHEEL ENDS.ODI IS UPGRADING THIS INVESTIGATION TO DETERMINE WHY THE ONE GROUP IS FAILING AT A HIGHER RATE THAN OTHERS WITH THE SAME WHEEL ENDS.IN ORDER TO RESOLVE THIS MATTER, ODI WILL BE CONTACTING THE AXLE MANUFACTURER, THE BEARING AND GREASE MANUFACTURERS, FLEETS AND WILL FURTHER INVESTIGATE THE ISSUE WITH STRICK DIRECTLY.
Additional source detail variants (3)
Suspension:multiple Axle
ODI OPENED THIS INVESTIGATION BASED ON A FLEET COMPLAINT WHERE INFORMATION WAS FURNISHED INDICATING THAT WHEEL BEARINGS WERE FAILING AT AN UNUSUALLY HIGH RATE.IN 29 CASES THESE FAILURES ALLEGEDLY RESULTED IN A WHEEL END FIRE OR A WHEEL SEPARATION.DURING THE INVESTIGATION IT WAS DETERMINED THAT THE SUBJECT VEHICLES WERE BUILT WITH LOW MAINTENANCE WHEEL ENDS.DOCUMENTS OBTAINED BY ODI INDICATE THAT WIDESPREAD CONFUSION EXISTED IN THIS INDUSTRY CONCERNING MAINTENANCE REQUIREMENTS.THE ISSUES WERE:FREQUENCY OF MAINTENANCE, AMOUNT OF GREASE TO BE USED, AND PROPER METHOD OF INSPECTION.SEVERAL MEETINGS WERE HELD INVOLVING THE AXLE MANUFACTURER, (ARVINMERITOR), LUBRICATION MANUFACTURER (MOBIL), SEVERAL TRAILER MANUFACTURERS AND FLEETS.CURRENTLY ODI HAS DATA WHICH INDICATES THAT 255 TRAILERS FROM A CERTAIN BUILD PERIOD HAVE WHEEL ENDS FAILING AT A HIGHER RATE THAN PEER TRAILERS WITH THE SAME WHEEL ENDS.ODI IS UPGRADING THIS INVESTIGATION TO DETERMINE WHY THE ONE GROUP IS FAILING AT A HIGHER RATE THAN OTHERS WITH THE SAME WHEEL ENDS.IN ORDER TO RESOLVE THIS MATTER, ODI WILL BE CONTACTING THE AXLE MANUFACTURER, THE BEARING AND GREASE MANUFACTURERS, FLEETS AND WILL FURTHER INVESTIGATE THE ISSUE WITH STRICK DIRECTLY.
SUSPENSION:REAR:AXLE:NON-POWERED Axle Assembly
ODI OPENED THIS INVESTIGATION BASED ON A FLEET COMPLAINT WHERE INFORMATION WAS FURNISHED INDICATING THAT WHEEL BEARINGS WERE FAILING AT AN UNUSUALLY HIGH RATE.IN 29 CASES THESE FAILURES ALLEGEDLY RESULTED IN A WHEEL END FIRE OR A WHEEL SEPARATION.DURING THE INVESTIGATION IT WAS DETERMINED THAT THE SUBJECT VEHICLES WERE BUILT WITH LOW MAINTENANCE WHEEL ENDS.DOCUMENTS OBTAINED BY ODI INDICATE THAT WIDESPREAD CONFUSION EXISTED IN THIS INDUSTRY CONCERNING MAINTENANCE REQUIREMENTS.THE ISSUES WERE:FREQUENCY OF MAINTENANCE, AMOUNT OF GREASE TO BE USED, AND PROPER METHOD OF INSPECTION.SEVERAL MEETINGS WERE HELD INVOLVING THE AXLE MANUFACTURER, (ARVINMERITOR), LUBRICATION MANUFACTURER (MOBIL), SEVERAL TRAILER MANUFACTURERS AND FLEETS.CURRENTLY ODI HAS DATA WHICH INDICATES THAT 255 TRAILERS FROM A CERTAIN BUILD PERIOD HAVE WHEEL ENDS FAILING AT A HIGHER RATE THAN PEER TRAILERS WITH THE SAME WHEEL ENDS.ODI IS UPGRADING THIS INVESTIGATION TO DETERMINE WHY THE ONE GROUP IS FAILING AT A HIGHER RATE THAN OTHERS WITH THE SAME WHEEL ENDS.IN ORDER TO RESOLVE THIS MATTER, ODI WILL BE CONTACTING THE AXLE MANUFACTURER, THE BEARING AND GREASE MANUFACTURERS, FLEETS AND WILL FURTHER INVESTIGATE THE ISSUE WITH STRICK DIRECTLY.
Wheels:hub
ODI OPENED THIS INVESTIGATION BASED ON A FLEET COMPLAINT WHERE INFORMATION WAS FURNISHED INDICATING THAT WHEEL BEARINGS WERE FAILING AT AN UNUSUALLY HIGH RATE.IN 29 CASES THESE FAILURES ALLEGEDLY RESULTED IN A WHEEL END FIRE OR A WHEEL SEPARATION.DURING THE INVESTIGATION IT WAS DETERMINED THAT THE SUBJECT VEHICLES WERE BUILT WITH LOW MAINTENANCE WHEEL ENDS.DOCUMENTS OBTAINED BY ODI INDICATE THAT WIDESPREAD CONFUSION EXISTED IN THIS INDUSTRY CONCERNING MAINTENANCE REQUIREMENTS.THE ISSUES WERE:FREQUENCY OF MAINTENANCE, AMOUNT OF GREASE TO BE USED, AND PROPER METHOD OF INSPECTION.SEVERAL MEETINGS WERE HELD INVOLVING THE AXLE MANUFACTURER, (ARVINMERITOR), LUBRICATION MANUFACTURER (MOBIL), SEVERAL TRAILER MANUFACTURERS AND FLEETS.CURRENTLY ODI HAS DATA WHICH INDICATES THAT 255 TRAILERS FROM A CERTAIN BUILD PERIOD HAVE WHEEL ENDS FAILING AT A HIGHER RATE THAN PEER TRAILERS WITH THE SAME WHEEL ENDS.ODI IS UPGRADING THIS INVESTIGATION TO DETERMINE WHY THE ONE GROUP IS FAILING AT A HIGHER RATE THAN OTHERS WITH THE SAME WHEEL ENDS.IN ORDER TO RESOLVE THIS MATTER, ODI WILL BE CONTACTING THE AXLE MANUFACTURER, THE BEARING AND GREASE MANUFACTURERS, FLEETS AND WILL FURTHER INVESTIGATE THE ISSUE WITH STRICK DIRECTLY.
2000 Strick Trailer Problems, Complaints & Recalls | Skip That Year
Illustration