Starcraft Bus (Starcraft) is recalling certain model year 2002-2007 Allstar, Starquest, Starlite, and Ultrastar commercial buses manufactured January 1, 2002, to September 30, 2007. The affected vehicles, when loaded with passengers and fuel, may exceed the gross vehicle weight rating (GVWR). As such, these vehicles fail to comply with the requirements of 49 CFR Part 567, "Certification."
Consequence & remedy
Consequence: If the buses are loaded beyond the GVWR rating on the certification label, the vehicle could have poor handling, tire or suspension failure, increasing the risk of a vehicle crash.
Remedy: Starcraft will notify owners, and dealers will install a revised certification label based on corrected axle and wheel calculations or dealers will remove seats from buses that cannot support additional weight beyond the GVWR on the existing label. This work will be done free of charge. The recall began on September 8, 2015. Owners may contact Starcraft customer service at 1-800-348-7440. Starcraft's number for this recall is 05-06242015-0058.
STARCRAFT IS RECALLING CERTAIN MODEL YEAR 2006-2010 BUSES EQUIPPED WITH BRAUN CENTURY-2 AND/OR VISTA-2 WHEELCHAIR LIFTS. OVER TIME AND WITH FREQUENT USE, THE ROLL STOP LATCHES ON THE OUTER BARRIER MAY BECOME BENT OR MISALIGNED.
Consequence & remedy
Consequence: A WHEELCHAIR OCCUPANT MAY DEFEAT OR RIDE OVER THE INSUFFICIENTLY LATCHED ROLL STOP. IF THIS OCCURS WHEN THE LIFT PLATFORM IS IN AN ELEVATED POSITION, THE WHEELCHAIRS OCCUPANT COULD FALL AND SUSTAIN INJURY.
Remedy: STARCRAFT WILL NOTIFY OWNERS, AND THE REPAIRS WILL BE PERFORMED BY AUTHORIZED BRAUN DEALERS FREE OF CHARGE. OWNERS MAY CONTACT STARCRAFT BUS AT 1-800-347-7440.
STARCRAFT IS RECALLING CERTAIN MODEL YEAR 2006 AND 2007 TRANSIT BUSES BUILT ON FORD AND FREIGHTLINER CHASSIS AND EQUIPPED WITH CARRIER GENV EM-1 EVAPORATOR UNITS. DUE TO TIME, TEMPERATURE, AND/OR VIBRATION, THE FUSE MAY LOOSEN IN THE FUSE HOLDER RESULTING IN HIGH RESISTANCE AND ARCING.
Consequence & remedy
Consequence: IF SUFFICIENT ARCING OCCURS, THE FUSE HOLDER MAY MELT, AND A VEHICLE FIRE MAY OCCUR.
Remedy: STARCRAFT WILL NOTIFY OWNERS AND PROVIDE INFORMATION ON HOW TO OBTAIN THE RETROFIT KIT FROM CARRIER ALONG WITH REPAIR INSTRUCTIONS. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE RECALL BEGAN IN NOVEMBER 2011. (SEE CARRIER'S RECALL CAMPAIGN 11E-003.) OWNERS MAY CONTACT CARRIER AT 1-800-348-7440.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2007 Starcraft Ultrastar Problems, Complaints & Recalls | Skip That Year
Illustration