WHILE DRIVING ON A HIGHWAY, THE MOON-ROOF/SUN-ROOF SHATTERED SPONTANEOUSLY. THE DAMAGE DOES NOT APPEAR TO BE CAUSED BY ANY OBJECT STRIKING THE GLASS. I HAVE DASHCAM FOOTAGE OF THE INCIDENT, IN WHICH TWO DISTINCT POPS CAN BE HEARD WHEN THE GLASS SHATTERS. ADDITIONALLY, THE EXTENSION MECHANISM (TWO SUPPORTS ON THE SIDES OF THE GLA…
Read full complaint
WHILE DRIVING ON A HIGHWAY, THE MOON-ROOF/SUN-ROOF SHATTERED SPONTANEOUSLY. THE DAMAGE DOES NOT APPEAR TO BE CAUSED BY ANY OBJECT STRIKING THE GLASS. I HAVE DASHCAM FOOTAGE OF THE INCIDENT, IN WHICH TWO DISTINCT POPS CAN BE HEARD WHEN THE GLASS SHATTERS. ADDITIONALLY, THE EXTENSION MECHANISM (TWO SUPPORTS ON THE SIDES OF THE GLASS) WERE FULLY EXTENDED. IT IS MY ASSUMPTION THAT ONE OF THE SUPPORTS FAILED AND FULLY EXTENDED, FORCING THE GLASS TO BEND AND ULTIMATELY PUT ENOUGH STRESS ON THE GLASS TO FAIL, AT WHICH POINT THE OTHER SUPPORT FULLY EXTENDED. PLEASE SEE ATTACHED PICTURES. IT APPEARS VIDEOS ARE NOT ABLE TO BE UPLOADED, BUT PLEASE CONTACT ME IF YOU WOULD LIKE THIS INFORMATION.
NHTSA ODI #11208529
139,433 miles · Oct 13, 2017
Unknown Or Other
I WAS DRIVING DOWN HIGHWAY GOING 55-60MPH WHEN MY MOONROOF EXPLODED! IT LITERALLY SOUNDED LIKE A BOMB OR GUNSHOT OVERHEAD. THE DEALERSHIP SAYS THERE IS NO RECALL AND THIS IS NOT A MANUFACTURER ISSUE... I'D HAVE TO DISAGREE AS I'M NOT THE ONLY ONE WITH THIS ISSUE.
NHTSA ODI #11033240
180,000 miles · Jul 8, 2017
Unknown Or Other
I WAS ON MY WAY HOME AND AS I WAS TURNING ON THE STREET TO PULL INTO MY APARTMENT COMPLEX I HEARD GUNSHOT SOUND BUT NO ONE WAS AROUND AND NO ONE WAS ON THE STREET I PULLED INTO MY APARTMENT COMPLEX AND PARK MY CAR AS I WAS GETTING OUT OF MY CAR GLASS STARTED TO FALL ON MY FACE I REALIZED THAT MY SUNROOF HAD SHATTERED.
NHTSA ODI #11003770
131,000 miles · May 27, 2017
Unknown Or OtherInjury
THE WIND DEFELETOR SHADDERED AS I WAS DRIVING DOWN THE FREEWAY AT 8:30 PM DOING 60MPG. IT HAD BEEN OPEN ALL DAY,
NHTSA ODI #10991906
Mileage unknown · Dec 18, 2016
Air BagsUnknown Or Other
TAKADA RECALL AIRBAGS - WAS MY CAR AFFECTED BY THIS RECALL?
NHTSA ODI #10936041
155 miles · Apr 30, 2016
Power TrainUnknown Or Other
CAR DOES NOT SHIFT WELL I REPLACED CLUTCH AND OTHER PARTS RELATED TO CLUTCH N CAR STILL CANT SHIFT GOOD I CANT DRIVE CAR
NHTSA ODI #10862300
90,000 miles · Apr 6, 2016
Unknown Or Other
DRIVING SPEED LIMIT DOWN FREEWAY WHEN I HEARD A LOUD POP, ALMOST AS IF A GUN SHOT. MY SUNROOF HAD COMPLETELY SHATTERED. I HAD IT REPLACED AND LESS THAN 3 MONTHS LATER THE SAME THING HAPPENED.
NHTSA ODI #10853909
137,562 miles · Mar 7, 2016
Unknown Or Other
AT HIGHWAY SPEED, DRIVERS SIDE REAR TIRE FAILED. CAUSED THE VEHICLE TO BECOME UNSTABLE AND DANGEROUS. SUMITOMO IS THE MANUFACTURER, AND THE TIRES THEMSELVES STILL HAD APPRX. 12,000 MILES LEFT ON THE LIFE OF THE WARRANTY. GOING TO HAVE ALL OTHERS CHECKED, AND REPLACING THE AFFECTED TIRE.
NHTSA ODI #10840212
45,000 miles · Sep 18, 2011
Unknown Or Other
FAILURE TO HIT UNLOCK MULTIPLE TIMES ON KEYLESS REMOTE WHEN ACCESSING REAR HATCHBACK TRUNK WILL PUT UNDUE STRESS ON THE POORLY DESIGNED ENTRY POINT. EVEN WITH USING THE UNLOCK FEATURE WHEN THE FRONT PASSENGER AND DRIVER DOORS ARE UNLOCKED THE TRUNK LID REMAINS LOCKED. SINCE THIS IS SUCH A POOR DESIGN IT HAS BROKEN AND THE ONLY W…
Read full complaint
FAILURE TO HIT UNLOCK MULTIPLE TIMES ON KEYLESS REMOTE WHEN ACCESSING REAR HATCHBACK TRUNK WILL PUT UNDUE STRESS ON THE POORLY DESIGNED ENTRY POINT. EVEN WITH USING THE UNLOCK FEATURE WHEN THE FRONT PASSENGER AND DRIVER DOORS ARE UNLOCKED THE TRUNK LID REMAINS LOCKED. SINCE THIS IS SUCH A POOR DESIGN IT HAS BROKEN AND THE ONLY WAY TO REPLACE IS 800 REPAIR BILL FOR NEW PART AND HAVE IT PAINTED. I HAVE TO POINT OUT THAT THE HATCHBACK IS OPENED AND ACCESED BY AN ELECTRIC PRESSURE POINT WITH KEYLESS ENTRY ONLY, SINCE THIS IS A PLASTIC PART AND IS VERY WEAK, IT ONLY TAKES A FEW VISITS TO THE CAR WASH OR DEALER TO HAVE SOMEONE ATTEMPT TO OPEN THE HATCHBACK WITH THE CAR UNLOCKED TO WRENCH ON THIS PART AND CAUSE IT TO FAIL. MOST MODERN VEHICLES HAVE A TRUNK RELEASE BUTTON, OR KEYED ENTRY WHICH WOULD PREVENT THIS OBVIOUS AND COMMON FAILURE, ITS COMMON BECAUSE I HAVE SEEN SEVERAL SCION TC'S WITH THIS PART HANGIN FROM THE HATCHBACK AND BLOCKING VIEW OF THE VEHICLES LICENSE PLATE, WHICH IN MOST STATES IS AN OFFENSE AND A SAFETY VIOLATION.
NHTSA ODI #10425908
Mileage unknown · Aug 3, 2006
Unknown Or Other
PURCHASED NEW 2006 SCION TC IN OCTOBER OF 05. SINCE THAT TIME I HAVE NOTICED CHIPS, SCRATCHES AND PAINT GENERALLY COMING OFF THE CAR ALL OVER THE PLACE. I DRIVE ON PAVED STREETS AND IN A MODERATE CLIMATE AREA (SEATTLE). I FEEL CHEATED THAT A CAR LESS THAN ONE YEAR OLD IS HAVING PAINT FAILURE ISSUES. *JB
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
ON CERTAIN VEHICLES, THE SIDE IMPACT SEAT-BOLSTER AND CURTAIN SIDE AIRBAGS MAY INADVERTENTLY DEPLOY. THIS CONDITION CAN OCCUR IF THE DOOR FOR THAT SIDE OF THE VEHICLE IS CLOSED WITH A HIGH RATE OF FORCE WHILE THE VEHICLE'S IGNITION IS IN THE "ON" POSITION OR WITHIN 90 SECONDS OF TURNING THE IGNITION KEY FROM THE "ON" POSITION TO THE "OFF" POSITION.
Consequence & remedy
Consequence: IF THE SIDE IMPACT SEAT-BOLSTER AND CURTAIN SIDE AIRBAGS INADVERTENTLY DEPLOY, THEY COULD CAUSE PERSONAL INJURY IF AN OCCUPANT IS SEATED ON THE SAME SIDE OF THE VEHICLE AS THE DOOR THAT IS CLOSED WITH A HIGH RATE OF FORCE. UNTIL THE REPAIR HAS BEEN PERFORMED, IT IS RECOMMENDED THAT A MINIMAL FORCE/SPEED BE USED TO CLOSE THE DRIVER AND PASSENGER DOORS OR CLOSING THE DOORS AFTER 90 SECONDS HAVE ELAPSED FROM TURNING THE IGNITION KEY FROM THE "ON" TO THE "OFF" POSITION.
Remedy: DEALERS WILL REPLACE THE TWO SIDE IMPACT AIRBAG SENSORS AND INSTALL A URETHANE PAD IN THE FRONT DOORS, IF NECESSARY, FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 6, 2006. OWNERS MAY CONTACT TOYOTA AT 1-866-548-1851.
ON CERTAIN VEHICLES, DUE TO IMPROPER ASSEMBLY OF THE AIR BAG INFLATOR, WHICH IS USED IN THE SIDE AIR BAG, THE CURTAIN SHIELD AIR BAG, AND THE KNEE AIR BAG ASSEMBLY, SOME INFLATORS WERE PRODUCED WITH AN INSUFFICIENT AMOUNT OF THE HEATING AGENTS NECESSARY FOR PROPER AIR BAG DEPLOYMENT. IN THIS CONDITION, THE EXPANSION FORCE OF THE GAS MAY BE INSUFFICIENT TO PROPERLY INFLATE THE AIR BAG WHEN THE SRS SYSTEM IS ACTIVATED DURING A CRASH.
Consequence & remedy
Consequence: THIS MAY INCREASE THE RISK OF INJURY TO THE OCCUPANT IN THE INVOLVED SEATING POSITION IN THE EVENT OF A CRASH.
Remedy: DEALERS WILL REPLACE THE SPECIFIC SRS AIR BAG. THE RECALL BEGAN ON APRIL 6, 2006. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371, SCION AT 1-866-548-1851, OR LEXUS AT 1-800-255-3987.
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH A GLASS WIND DEFLECTOR, THE DEFLECTOR, IF IMPACTED BY A PROJECTILE, SUCH AS ROAD DEBRIS, WHILE DRIVING WITH THE WIND DEFLECTOR IN THE UPWARD-TILTED POSITION AT HIGHWAYS SPEEDS, MAY SHATTER AND SEPARATE FROM THE FRAME.
Consequence & remedy
Consequence: PIECES OF THE WIND DEFLECTOR GLASS MAY SEPARATE FROM THE FRAME AND FALL UPON THE VEHICLE OCCUPANTS CAUSING DRIVER DISTRACTION AND/OR INJURY.
Remedy: DEALERS WILL INSTALL A PROTECTIVE LAMINATE TO THE WIND DEFLECTOR TO PREVENT PIECES OF GLASS FROM SEPARATING FROM THE WIND DEFLECTOR FRAME. THE RECALL BEGAN OCTOBER 27, 2005. OWNERS MAY CONTACT TOYOTA AT 1-866-707-2466.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
PE06024 · Glass Moonroof Shatters
Opened Jul 7, 2006 · Closed Dec 6, 2006
Status: closed (inferred from source dates) · Structure:body:roof And Pillars; Visibility:sun/moon Roof Assembly
ODI'S INVESTIGATION DISCLOSES THAT THE SUBJECT VEHICLES SUSTAIN MOONROOF SHATTERING AND/OR DAMAGE AT RATES COMPARABLE TO THOSE FOR MOST OTHER SIMILARLY EQUIPPED VEHICLES.THIS REVIEW ALSO DISCLOSES THAT SUCH INCIDENTS OCCUR IN MOST VEHICLES WITH MOONROOFS AND THAT WHILE TEMPERED GLASS PANELS COMMONLY USED IN MOONROOF FABRICATION ARE SHATTER-RESISTANT, SOME CATASTROPHIC FAILURES DO IN FACT OCCUR.IMPACT WITH SMALL STONES OR ROAD DEBRIS MAY RESULT IN IMMEDIATE OR DELAYED SHATTER INCIDENTS, DEPENDING ON THE EXTENT AND NATURE OF DAMAGE SUSTAINED BY THE GLASS MOONROOF PANEL.THE MANUFACTURER CONCLUDES THAT INCIDENTS OF MOONROOF SHATTER ARE RANDOM OCCURRENCES THAT RESULT PRIMARILY FROM IMPACT WITH SMALL STONES OR OTHER OBJECTS WHILE THE VEHICLE IS IN MOTION. A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AND THIS PE HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY DEFECT DOES NOT EXIST.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (2)
Structure:body:roof And Pillars
ODI'S INVESTIGATION DISCLOSES THAT THE SUBJECT VEHICLES SUSTAIN MOONROOF SHATTERING AND/OR DAMAGE AT RATES COMPARABLE TO THOSE FOR MOST OTHER SIMILARLY EQUIPPED VEHICLES.THIS REVIEW ALSO DISCLOSES THAT SUCH INCIDENTS OCCUR IN MOST VEHICLES WITH MOONROOFS AND THAT WHILE TEMPERED GLASS PANELS COMMONLY USED IN MOONROOF FABRICATION ARE SHATTER-RESISTANT, SOME CATASTROPHIC FAILURES DO IN FACT OCCUR.IMPACT WITH SMALL STONES OR ROAD DEBRIS MAY RESULT IN IMMEDIATE OR DELAYED SHATTER INCIDENTS, DEPENDING ON THE EXTENT AND NATURE OF DAMAGE SUSTAINED BY THE GLASS MOONROOF PANEL.THE MANUFACTURER CONCLUDES THAT INCIDENTS OF MOONROOF SHATTER ARE RANDOM OCCURRENCES THAT RESULT PRIMARILY FROM IMPACT WITH SMALL STONES OR OTHER OBJECTS WHILE THE VEHICLE IS IN MOTION. A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AND THIS PE HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY DEFECT DOES NOT EXIST.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Visibility:sun/moon Roof Assembly
ODI'S INVESTIGATION DISCLOSES THAT THE SUBJECT VEHICLES SUSTAIN MOONROOF SHATTERING AND/OR DAMAGE AT RATES COMPARABLE TO THOSE FOR MOST OTHER SIMILARLY EQUIPPED VEHICLES.THIS REVIEW ALSO DISCLOSES THAT SUCH INCIDENTS OCCUR IN MOST VEHICLES WITH MOONROOFS AND THAT WHILE TEMPERED GLASS PANELS COMMONLY USED IN MOONROOF FABRICATION ARE SHATTER-RESISTANT, SOME CATASTROPHIC FAILURES DO IN FACT OCCUR.IMPACT WITH SMALL STONES OR ROAD DEBRIS MAY RESULT IN IMMEDIATE OR DELAYED SHATTER INCIDENTS, DEPENDING ON THE EXTENT AND NATURE OF DAMAGE SUSTAINED BY THE GLASS MOONROOF PANEL.THE MANUFACTURER CONCLUDES THAT INCIDENTS OF MOONROOF SHATTER ARE RANDOM OCCURRENCES THAT RESULT PRIMARILY FROM IMPACT WITH SMALL STONES OR OTHER OBJECTS WHILE THE VEHICLE IS IN MOTION. A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AND THIS PE HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY DEFECT DOES NOT EXIST.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
2006 Scion Tc Problems, Complaints & Recalls | Skip That Year
Illustration