IllustrationTL* THE CONTACT OWNS A 2005 TOYOTA SCION TC. THE CONTACT STATED THAT WHILE DRIVING AT 65 MPH, THE SUN ROOF GLASS EXPLODED AND SHATTERED. THE CONTACT DID NOT SUSTAIN ANY INJURIES. THE VEHICLE WAS NOT TAKEN TO THE DEALER OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 160,500.
2005 Scion Tc
Owner reports · Recalls · Investigations
More warning signs than most Tc years
Owner complaints for the 2005 Scion Tc are substantially higher than the model-year median of 25.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Tc years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
420–25K
1925–50K
1350–75K
1675–100K
15100–150K
8150K+
113 reports with mileage · 42 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Visibility. Review the 47 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Structure. Review the 31 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 20 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
25 crash reports3 fire reports24 injury reports
Visibility complaints
47 reportsI WAS DRIVING ALONG GOVERNMENT ST, THE STREETS DOWNTOWN NEEDS MAJOR REPAIRS. BUT I DIDN'T HIT A BUMP IN THE ROAD OR NOTHING TO CAUSE MY GLASS TO BREAK. I DIDN'T EVEN HEAR ANYTHING HIT MY GLASS I HAD THE SUNROOF OPEN WITH MY LITTLE BROTHER AND DOG IN THE CAR WHEN GLASS BEGIN TO FALL ON US. *TR
WHEN I RETURNED TO MY CAR THAT HAD BEEN PARKED FOR APPROXIMATELY THREE HOURS, I FOUND THAT THE DEFLECTOR WAS RAISED AND THE SUNROOF WAS ENTIRELY SHATTERED. THE "LEGS" OF THE DEFLECTOR APPEARED TO HAVE BROKEN THROUGH THE GLASS, AS THE SUNROOF WAS SEVERELY CRACKED AND BROKEN ALONG EACH OF ITS FOUR EDGES. I HAD NOT USED THE SUNRO…
Read full complaint
WHEN I RETURNED TO MY CAR THAT HAD BEEN PARKED FOR APPROXIMATELY THREE HOURS, I FOUND THAT THE DEFLECTOR WAS RAISED AND THE SUNROOF WAS ENTIRELY SHATTERED. THE "LEGS" OF THE DEFLECTOR APPEARED TO HAVE BROKEN THROUGH THE GLASS, AS THE SUNROOF WAS SEVERELY CRACKED AND BROKEN ALONG EACH OF ITS FOUR EDGES. I HAD NOT USED THE SUNROOF PRIOR TO PARKING MY CAR THAT MORNING. UPON READING SIMILAR COMPLAINTS, I DO RECALL ALSO HAVING HEARD AN EXTREMELY LOUD POP WHILE DRIVING, BUT THE SUNROOF DID NOT SHATTER UNTIL SOME TIME AFTER WHILE THE CAR WAS PARKED. *TR
I LOVE MY SCION HOWEVER I BOUGHT BRAND NEW FROM EXPRESSWAY TOYOTA IN DORCHESTER MA IN 2005 AND WITH ALL THE RECALLS I SEE ON HERE I'VE ONLY DONE ONE, AND THAT THE GLASS WINDSHIELD. EVERY OTHER TIME I GO THE DEALER AND TELL THEM THAT THERE ARE RECALLS, THEY IGNORE ME AND SAY THAT THERE ISN'T . I HAVE SOME RATTLING NOISE GOING O…
Read full complaint
I LOVE MY SCION HOWEVER I BOUGHT BRAND NEW FROM EXPRESSWAY TOYOTA IN DORCHESTER MA IN 2005 AND WITH ALL THE RECALLS I SEE ON HERE I'VE ONLY DONE ONE, AND THAT THE GLASS WINDSHIELD. EVERY OTHER TIME I GO THE DEALER AND TELL THEM THAT THERE ARE RECALLS, THEY IGNORE ME AND SAY THAT THERE ISN'T . I HAVE SOME RATTLING NOISE GOING ON UNDER MY CAR...I FIXED ONCE AT THE DEALER AND IT CAME BACK AGAIN BUT NOW THE DEALER WANTS ME TO PAY AGAIN TO FIX IT AND I THINK IT'S A SAFETY CONCERN IN THE CAR, THE TIRES ARE ALSO UNEVEN, I KEEP HAVING TO CHANGE TIRES TOO OFTEN, THE HATCH LIFT IN THE BACK KEEPS BREAKING...MAJOR FAILING AND CHEAP. IT FEELS LIKE IT WAS GLUED ON. I WOULD AN ANSWER FROM THE DEALER WHERE I BOUGHT THE CAR AS TO WHY THEY KEEP DENYING MY VISITS ON THE RECALLS AND WHY IN BEING CHARGE THE SAME SAFETY WORK THAT I'VE PAID ONCE TO GET FIX AND NOW THE SAME RATTLING NOISE KEEPS COMING. I NEVER GET ANY INFORMATION IN THE MAIL FROM MY DEALER EITHER INFORMING ME OF THESE RECALLS. I GUESS THEY ARE REFUSING TO FIX THEM. *TR
DRIVING DOWN THE HIGHWAY AT ~65 MPH IN 2005 SCION TC WITH SUNROOF OPEN AND WITHOUT WARNING THE FRONT AIR DEFLECTOR SHIELD SHATTERED THROWING GLASS INTO THE PASSENGER COMPARTMENT. NO OTHER TRAFFIC WAS AROUND THAT COULD HAVE CAUSED A THROWN STONE OR ANYTHING ELSE. *TR
2005 SCION TC, SUN ROOF EXPLODED WHILE DRIVING AT I-85 FREEWAY. ALL WINDOWS AND SUNROOF WERE CLOSED WHEN IT HAPPENED. THE SHATTERED SUNROOF HAVE A HUGE HOLE IN MIDDLE FRONT SECTION OF THE SUNROOF AND SHATTERED ALL FOUR SIDES. ON DAILY DRIVING, I NOTICED THAT THE CAR STRUCTURE FLEX TOO MUCH, ENOUGH TO PRODUCE POPPING SO…
Read full complaint
2005 SCION TC, SUN ROOF EXPLODED WHILE DRIVING AT I-85 FREEWAY. ALL WINDOWS AND SUNROOF WERE CLOSED WHEN IT HAPPENED. THE SHATTERED SUNROOF HAVE A HUGE HOLE IN MIDDLE FRONT SECTION OF THE SUNROOF AND SHATTERED ALL FOUR SIDES. ON DAILY DRIVING, I NOTICED THAT THE CAR STRUCTURE FLEX TOO MUCH, ENOUGH TO PRODUCE POPPING SOUND. TOYOTA DEALER INITIAL ASSESSMENT IS NOT PART OF WARRANTY OR RECALL AS OF THIS DATE 11/05/2010. *TR
1. DRIVER DOOR REQUIRED MORE FORCE TO CLOSE. LATER, I NOTICED THE DRIVER WINDOW WOULD NOT RAISE MORE THAN HALF WAY. 2. THE WINDOW REGULATOR ARM IS BENT, AND THE INTERNAL ATTACHMENT POINT IS BROKEN. THE WINDOW GETS PROGRESSIVELY WORSE OVER TIME, AND THE RAISED HEIGHT BECOMES LOWER. 3. THE DEALER STATED THEIR MUST HAVE BEEN PRE…
Read full complaint
1. DRIVER DOOR REQUIRED MORE FORCE TO CLOSE. LATER, I NOTICED THE DRIVER WINDOW WOULD NOT RAISE MORE THAN HALF WAY. 2. THE WINDOW REGULATOR ARM IS BENT, AND THE INTERNAL ATTACHMENT POINT IS BROKEN. THE WINDOW GETS PROGRESSIVELY WORSE OVER TIME, AND THE RAISED HEIGHT BECOMES LOWER. 3. THE DEALER STATED THEIR MUST HAVE BEEN PREVIOUS DAMAGE TO THE VEHICLE, AND THEY WERE UNABLE TO RESOLVE. MAACO SAID THEY WERE UNABLE TO RESOLVE. MORE THAN A YEAR LATER, TOOK IT BACK TO THE DEALER, AND THE NEW SERVICE PERSONNEL WERE ABLE TO REPLACE THE REGULATOR ARM, AND WELD IT TO THE DOOR IN MARCH 2010. IT'S NOW JUNE, AND THE WINDOW WILL NO LONGER GO PAST THE HALF WAY POINT WHEN ATTEMPTING TO CLOSE. EACH TIME I'VE ATTEMPTED TO GET A RESOLUTION, THE DEALER HAS INSISTED THE INTERNAL DOOR DAMAGE IS A RESULT OF A PREVIOUS ACCIDENT (CARFAX IS CLEAR) OR DUE TO THE PREVIOUS OWNER REPLACING THE DOOR MOUNTED AUDIO SPEAKER. NOW, I READ ANOTHER COMPLAINT WITH VERY SIMILAR DAMAGE THAT MAKES ME BELIEVE THIS IS AN INHERENT PROBLEM THAT THE DEALER SHOULD HAVE FIXED WHEN THE CAR WAS STILL UNDER WARRANTY. *TR
SUNVISOR ON DRIVER AND PASSENGER SIDE OF VEHICLE ARE DETACHED FROM INSIDE SHAFT AND NOW THEY JUST DONT GO UP. NOT FUNCTIONING PROPERLY. *TR
I WAS DRIVING UP I-25, WHEN THE VEHICLE IN FRONT OF ME KICKED UP A ROCK. THE ROCK HIT THE TOP OF THE SUNROOF, SHATTERING IT INTO PIECES. A LOT OF SHARP GLASS LANDED ON MYSELF THE DRIVER AND IN THE PASSENGER SEAT. THE VEHICLES BEHIND ME WERE SHOWERED IN GLASS. TO REPAIR THIS I HAD TO PURCHASE A COSTLY NEW SUNROOF PANEL AND I AM G…
Read full complaint
I WAS DRIVING UP I-25, WHEN THE VEHICLE IN FRONT OF ME KICKED UP A ROCK. THE ROCK HIT THE TOP OF THE SUNROOF, SHATTERING IT INTO PIECES. A LOT OF SHARP GLASS LANDED ON MYSELF THE DRIVER AND IN THE PASSENGER SEAT. THE VEHICLES BEHIND ME WERE SHOWERED IN GLASS. TO REPAIR THIS I HAD TO PURCHASE A COSTLY NEW SUNROOF PANEL AND I AM GOING TO HAVE IT CLEAR BRAND SO THAT IF IT HAPPENS AGAIN IT DOES NOT INJURE ANY ONE. I RECEIVED CUTS FROM THE BROKEN GLASS FALLING ON TO ME. *TR
I WAS DRIVING ON THE HIGHWAY AT ABOUT 45MPH WHEN I HEARD A LOUD EXPLOSION. I IMMEDIATELY PULLED OVER THINKING A TIRE HAD BLOWN AND FOUND THAT THE MOONROOF GLASS HAD SHATTERED. THE GLASS WAS BOWED UPWARD IN THE CENTER INDICATING IT HAD BROKEN DUE TO STRESS. THE WINDSHIELD AND THE WIND DEFLECTOR DID NOT BREAK AT ALL NOR RECEIVE AN…
Read full complaint
I WAS DRIVING ON THE HIGHWAY AT ABOUT 45MPH WHEN I HEARD A LOUD EXPLOSION. I IMMEDIATELY PULLED OVER THINKING A TIRE HAD BLOWN AND FOUND THAT THE MOONROOF GLASS HAD SHATTERED. THE GLASS WAS BOWED UPWARD IN THE CENTER INDICATING IT HAD BROKEN DUE TO STRESS. THE WINDSHIELD AND THE WIND DEFLECTOR DID NOT BREAK AT ALL NOR RECEIVE ANY DAMAGE. THE GLASS WAS NOT IMPACTED BY ANY FOREIGN OBJECT. *TR
Official recalls
410V035000 · Equipment:other:labels
Feb 3, 2010
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
06V408000 · Air Bags:side/window
Oct 26, 2006
ON CERTAIN VEHICLES, THE SIDE IMPACT SEAT-BOLSTER AND CURTAIN SIDE AIRBAGS MAY INADVERTENTLY DEPLOY. THIS CONDITION CAN OCCUR IF THE DOOR FOR THAT SIDE OF THE VEHICLE IS CLOSED WITH A HIGH RATE OF FORCE WHILE THE VEHICLE'S IGNITION IS IN THE "ON" POSITION OR WITHIN 90 SECONDS OF TURNING THE IGNITION KEY FROM THE "ON" POSITION TO THE "OFF" POSITION.
Consequence & remedy
Consequence: IF THE SIDE IMPACT SEAT-BOLSTER AND CURTAIN SIDE AIRBAGS INADVERTENTLY DEPLOY, THEY COULD CAUSE PERSONAL INJURY IF AN OCCUPANT IS SEATED ON THE SAME SIDE OF THE VEHICLE AS THE DOOR THAT IS CLOSED WITH A HIGH RATE OF FORCE. UNTIL THE REPAIR HAS BEEN PERFORMED, IT IS RECOMMENDED THAT A MINIMAL FORCE/SPEED BE USED TO CLOSE THE DRIVER AND PASSENGER DOORS OR CLOSING THE DOORS AFTER 90 SECONDS HAVE ELAPSED FROM TURNING THE IGNITION KEY FROM THE "ON" TO THE "OFF" POSITION.
Remedy: DEALERS WILL REPLACE THE TWO SIDE IMPACT AIRBAG SENSORS AND INSTALL A URETHANE PAD IN THE FRONT DOORS, IF NECESSARY, FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 6, 2006. OWNERS MAY CONTACT TOYOTA AT 1-866-548-1851.
06V096000 · Air Bags
Apr 3, 2006
ON CERTAIN VEHICLES, DUE TO IMPROPER ASSEMBLY OF THE AIR BAG INFLATOR, WHICH IS USED IN THE SIDE AIR BAG, THE CURTAIN SHIELD AIR BAG, AND THE KNEE AIR BAG ASSEMBLY, SOME INFLATORS WERE PRODUCED WITH AN INSUFFICIENT AMOUNT OF THE HEATING AGENTS NECESSARY FOR PROPER AIR BAG DEPLOYMENT. IN THIS CONDITION, THE EXPANSION FORCE OF THE GAS MAY BE INSUFFICIENT TO PROPERLY INFLATE THE AIR BAG WHEN THE SRS SYSTEM IS ACTIVATED DURING A CRASH.
Consequence & remedy
Consequence: THIS MAY INCREASE THE RISK OF INJURY TO THE OCCUPANT IN THE INVOLVED SEATING POSITION IN THE EVENT OF A CRASH.
Remedy: DEALERS WILL REPLACE THE SPECIFIC SRS AIR BAG. THE RECALL BEGAN ON APRIL 6, 2006. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371, SCION AT 1-866-548-1851, OR LEXUS AT 1-800-255-3987.
05V483000 · Visibility:sun/moon Roof Assembly
Oct 18, 2005
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH A GLASS WIND DEFLECTOR, THE DEFLECTOR, IF IMPACTED BY A PROJECTILE, SUCH AS ROAD DEBRIS, WHILE DRIVING WITH THE WIND DEFLECTOR IN THE UPWARD-TILTED POSITION AT HIGHWAYS SPEEDS, MAY SHATTER AND SEPARATE FROM THE FRAME.
Consequence & remedy
Consequence: PIECES OF THE WIND DEFLECTOR GLASS MAY SEPARATE FROM THE FRAME AND FALL UPON THE VEHICLE OCCUPANTS CAUSING DRIVER DISTRACTION AND/OR INJURY.
Remedy: DEALERS WILL INSTALL A PROTECTIVE LAMINATE TO THE WIND DEFLECTOR TO PREVENT PIECES OF GLASS FROM SEPARATING FROM THE WIND DEFLECTOR FRAME. THE RECALL BEGAN OCTOBER 27, 2005. OWNERS MAY CONTACT TOYOTA AT 1-866-707-2466.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3PE06024 · Glass Moonroof Shatters
Opened Jul 7, 2006 · Closed Dec 6, 2006
Status: closed (inferred from source dates) · Structure:body:roof And Pillars; Visibility:sun/moon Roof Assembly
ODI'S INVESTIGATION DISCLOSES THAT THE SUBJECT VEHICLES SUSTAIN MOONROOF SHATTERING AND/OR DAMAGE AT RATES COMPARABLE TO THOSE FOR MOST OTHER SIMILARLY EQUIPPED VEHICLES.THIS REVIEW ALSO DISCLOSES THAT SUCH INCIDENTS OCCUR IN MOST VEHICLES WITH MOONROOFS AND THAT WHILE TEMPERED GLASS PANELS COMMONLY USED IN MOONROOF FABRICATION ARE SHATTER-RESISTANT, SOME CATASTROPHIC FAILURES DO IN FACT OCCUR.IMPACT WITH SMALL STONES OR ROAD DEBRIS MAY RESULT IN IMMEDIATE OR DELAYED SHATTER INCIDENTS, DEPENDING ON THE EXTENT AND NATURE OF DAMAGE SUSTAINED BY THE GLASS MOONROOF PANEL.THE MANUFACTURER CONCLUDES THAT INCIDENTS OF MOONROOF SHATTER ARE RANDOM OCCURRENCES THAT RESULT PRIMARILY FROM IMPACT WITH SMALL STONES OR OTHER OBJECTS WHILE THE VEHICLE IS IN MOTION. A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AND THIS PE HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY DEFECT DOES NOT EXIST.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (2)
Structure:body:roof And Pillars
ODI'S INVESTIGATION DISCLOSES THAT THE SUBJECT VEHICLES SUSTAIN MOONROOF SHATTERING AND/OR DAMAGE AT RATES COMPARABLE TO THOSE FOR MOST OTHER SIMILARLY EQUIPPED VEHICLES.THIS REVIEW ALSO DISCLOSES THAT SUCH INCIDENTS OCCUR IN MOST VEHICLES WITH MOONROOFS AND THAT WHILE TEMPERED GLASS PANELS COMMONLY USED IN MOONROOF FABRICATION ARE SHATTER-RESISTANT, SOME CATASTROPHIC FAILURES DO IN FACT OCCUR.IMPACT WITH SMALL STONES OR ROAD DEBRIS MAY RESULT IN IMMEDIATE OR DELAYED SHATTER INCIDENTS, DEPENDING ON THE EXTENT AND NATURE OF DAMAGE SUSTAINED BY THE GLASS MOONROOF PANEL.THE MANUFACTURER CONCLUDES THAT INCIDENTS OF MOONROOF SHATTER ARE RANDOM OCCURRENCES THAT RESULT PRIMARILY FROM IMPACT WITH SMALL STONES OR OTHER OBJECTS WHILE THE VEHICLE IS IN MOTION. A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AND THIS PE HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY DEFECT DOES NOT EXIST.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Visibility:sun/moon Roof Assembly
ODI'S INVESTIGATION DISCLOSES THAT THE SUBJECT VEHICLES SUSTAIN MOONROOF SHATTERING AND/OR DAMAGE AT RATES COMPARABLE TO THOSE FOR MOST OTHER SIMILARLY EQUIPPED VEHICLES.THIS REVIEW ALSO DISCLOSES THAT SUCH INCIDENTS OCCUR IN MOST VEHICLES WITH MOONROOFS AND THAT WHILE TEMPERED GLASS PANELS COMMONLY USED IN MOONROOF FABRICATION ARE SHATTER-RESISTANT, SOME CATASTROPHIC FAILURES DO IN FACT OCCUR.IMPACT WITH SMALL STONES OR ROAD DEBRIS MAY RESULT IN IMMEDIATE OR DELAYED SHATTER INCIDENTS, DEPENDING ON THE EXTENT AND NATURE OF DAMAGE SUSTAINED BY THE GLASS MOONROOF PANEL.THE MANUFACTURER CONCLUDES THAT INCIDENTS OF MOONROOF SHATTER ARE RANDOM OCCURRENCES THAT RESULT PRIMARILY FROM IMPACT WITH SMALL STONES OR OTHER OBJECTS WHILE THE VEHICLE IS IN MOTION. A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AND THIS PE HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY DEFECT DOES NOT EXIST.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
EA05013 · Sun/moon Roof Wind Deflector Breakage
Opened Aug 26, 2005 · Closed Oct 26, 2005
Status: closed (inferred from source dates) · Visibility:sun/moon Roof Assembly
THE MANUFACTURER NOTIFIED NHTSA BY LETTER DATED OCTOBER 17, 2005, THAT A SAFETY RECALL HAS BEEN INITIATED.NHTSA HAS ASSIGNED NO.05V-483 TO THE RECALL.THE CORRECTIVE ACTION WILL CONSIST OF INSTALLING A PLASTIC FILM TO THE INSIDE SURFACE OF THE WIND DEFLECTOR GLASS.THE CORRECTIVE ACTION WILL BE PERFORMED ON APPROXIMATELY 71,400 MY 2005 AND 2006 SCION TC VEHICLES MANUFACTURED DURING THE PERIOD OF MARCH 12, 2004 THROUGH JULY 21, 2005. BASED ON THIS ACTION, THE SUBJECT EA HAS BEEN CLOSED.
PE05021 · Sun/moon Roof Wind Deflector Breakage
Opened Apr 28, 2005 · Closed Aug 26, 2005
Status: closed (inferred from source dates) · Visibility:sun/moon Roof Assembly
THE MANUFACTURER STATES THAT THERE ARE NO INDICATIONS OF DEFICIENCIES IN THE DESIGN, MANUFACTURE, OR ASSEMBLY OF THE WIND DEFLECTOR THAT MAY ACCOUNT FOR THE INCIDENTS REPORTED.THE MANUFACTURER ALSO BELIEVES THAT IMPACT OF AIRBORNE ROAD DEBRIS WITH THE WIND DEFLECTOR IS THE PROBABLE CAUSE FOR THE INCIDENTS REPORTED.ODI'S ANALYSES OF THE WARRANTY DATA INDICATE THAT INCIDENTS OF WIND DEFLECTOR BREAKAGE WHILE DRIVING WILL CONTINUE TO OCCUR OVER TIME, AS THE POPULATION AND ON-ROAD EXPOSURE OF THE SUBJECT VEHICLES INCREASE.THE EVIDENCE INDICATES THAT REGARDLESS OF THE CAUSE FOR SUCH BREAKAGE, THE BROKEN GLASS PARTICLES AND FRAGMENTS MAY FALL DIRECTLY ONTO THE FRONT SEAT OCCUPANTS OF THESE VEHICLES.THESE OCCURRENCES MAY POSE A RISK OF DRIVER DISTRACTION AND PERSONAL INJURY.THIS PE HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA05-013) TO FURTHER ASSESS THIS MATTER.