IllustrationThe ignition (key) has stopped working again after being recalled a few years ago, and being replaced. The key will not turn and start the car.
2004 Saturn Vue
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2004 Saturn Vue do not stand out strongly from the model-year median of 276.
About this comparison →How this year compares
Owner complaints by model year
Compare all Vue years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
440–25K
3225–50K
3250–75K
4675–100K
52100–150K
31150K+
237 reports with mileage · 39 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Power Train. Review the 93 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 78 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Suspension. Review the 33 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
23 crash reports5 fire reports15 injury reports
Unknown Or Other complaints
17 reportsRUSTED FRONT SUBFRAME/ ENGINE CRADLE I CARRIED MY SATURN VUE TO HAVE THE CATALYTIC CONVERTERS REPLACED AND MY MASTER-MECHANIC DISCOVERED THE RUSTED SUBFRAME AND BROUGHT IT TO MY ATTENTION. HE SHOWED IT TO ME AND EXPLAINED THE THE DANGER IN OPERATING THIS VEHICLE.
THE IGNITION BROKE AFTER MANY OF TIMES THE KEY COMING OUT.
THERE WAS A RECALL BACK IN OCTOBER 20TH, 2014 REGARDING AN ISSUE WITH THE IGNITION. WHERE YOU CAN PULL THE KEY OUT WHILE ITS RUNNING. I'VE NEVER GOTTEN A CALL FROM NHTSA REGARDING THE ISSUE. MAY I HAVE IT DONE FREE OF CHARGE. THE VEHICLE WAS STATIONARY
TAMARA RECALL I GOT A RECALL IN THE MAIL FOR MY 2004 SATURN VUE FOR THE IGNITION I'VE CALLED THE DEALERSHIP WHERE I GOT IT AND THEY SAID THEY KNEW ABOUT IT BUT DID NOT TELL ME WHEN I BOUGHT IT. AND SAID I HAVE TO TAKE CAR OF IT MYSELF.
I JUST BOUT MY 2004 STAURN VUE FROM A PRIVATE OWNER AND HAVE TO REPLACE MY IGNITION FOR THE 2ND TIME IN LESS THEN A MONTH. I LOOKED ONLINE AND SEEN THAT THE 2004 SATURN VUE HAVE HAD A RECALL ON THIS SAME PROBLEM. I AM NOT ABLE TO LOCATE MY VEHICLE IN THE REGISTRATION OF THE RECALL SYSTEM. MY IGNITION LOCKS TO WHERE I CAN START T…
Read full complaint
I JUST BOUT MY 2004 STAURN VUE FROM A PRIVATE OWNER AND HAVE TO REPLACE MY IGNITION FOR THE 2ND TIME IN LESS THEN A MONTH. I LOOKED ONLINE AND SEEN THAT THE 2004 SATURN VUE HAVE HAD A RECALL ON THIS SAME PROBLEM. I AM NOT ABLE TO LOCATE MY VEHICLE IN THE REGISTRATION OF THE RECALL SYSTEM. MY IGNITION LOCKS TO WHERE I CAN START THE CAR AND KEY GET STUCK.
STOPPED AT A RED LIGHT... WHEN IT GREEN AND TIME TO DRIVE THE GAS MOVED BY THE CAR WAS A COMPLETE STOP AND IT WONT NOT MOVE FOWARD OR BACKWARDS... LEAVING ME AND MY 2 TODDLERS STUCK INTO ON COMING TRAFFIC
THE KEY FALLS OUT WHILE DRIVING AND THE CAR WON'T START SOMETIMES
THE IGNITION LOCKS AND CAN NOT TURN KEY WITH OUT JERKING AND BEATING THE STERRING WHEEL. YOU CAN'T PUT THE INGITION IN THE OFF POSITION. KEY CAN BE REMOVED WHILE ENGINE IS RUNNING. MY VIN # WAS NOT LISTED ON THE RECALL LIST BUT OTHER SAME MAKE AND MODEL VEHICLES WERE IN WITH THIS RECALL. I NEED THIS FIXED PLEASE. I HAVE HAD TH…
Read full complaint
THE IGNITION LOCKS AND CAN NOT TURN KEY WITH OUT JERKING AND BEATING THE STERRING WHEEL. YOU CAN'T PUT THE INGITION IN THE OFF POSITION. KEY CAN BE REMOVED WHILE ENGINE IS RUNNING. MY VIN # WAS NOT LISTED ON THE RECALL LIST BUT OTHER SAME MAKE AND MODEL VEHICLES WERE IN WITH THIS RECALL. I NEED THIS FIXED PLEASE. I HAVE HAD THIS VEHICLE FOR 2 YEARS.
"TAKATA RECALL". MY MECHANIC FOUND A FAULTY TAKATA AIRBAG WHILE DIAGNOSING A HORN PROBLEM. MY VIN IS NOT ON THE AIRBAG RECALL LIST OR THE IGNITION SWITCH RECALL LIST. ALSO THE FAULTY IGNITION SWITCH IS CAUSING SECURITY SYSTEM ISSUES AND CAUSING MY HORN RELAY TO STAY PERMANENTLY IN THE ON POSITION WHICH IS DRAINING MY BATTERY TO …
Read full complaint
"TAKATA RECALL". MY MECHANIC FOUND A FAULTY TAKATA AIRBAG WHILE DIAGNOSING A HORN PROBLEM. MY VIN IS NOT ON THE AIRBAG RECALL LIST OR THE IGNITION SWITCH RECALL LIST. ALSO THE FAULTY IGNITION SWITCH IS CAUSING SECURITY SYSTEM ISSUES AND CAUSING MY HORN RELAY TO STAY PERMANENTLY IN THE ON POSITION WHICH IS DRAINING MY BATTERY TO NOTHING. HOW DO I GET MY VIN ADDED TO THESE LISTS SO THAT THESE PARTS CAN BE REPLACED UNDER THE RECALL?
Official recalls
214V490000 · Electrical System:ignition
Aug 8, 2014
General Motors LLC (GM) is recalling certain model year 2002-2004 Saturn Vue vehicles manufactured September 11, 2001, to April 6, 2004. In the affected vehicles, it may be possible for the key to be removed from the ignition when the ignition is not in the "Off" position.
Consequence & remedy
Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
Remedy: GM will notify owners, and dealers will inspect the vehicle to see if the key can be pulled out when the ignition is off. If it can, dealers will replace the ignition cylinder and keys, free of charge. The recall began in October 2014. Owners may contact Saturn customer service at 1-800-553-6000. GM's number for this recall is 14506. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.
03V519000 · Equipment:other:labels
Dec 19, 2003
CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH 3.5L V6 (L66) ENGINES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, "TIRE SELECTION AND RIMS FOR VEHICLES OTHER THAN PASSENGER CARS." THE FRONT AND REAR WHEEL RIM SIZE SPECIFICATIONS ON THE TIRE/CERTIFICATION LABEL ARE NOT CORRECT. THE PRINTED WHEEL RIM DESIGNATION SPECIFIED A 16-INCH WHEEL WHEN A 17-INCH WHEEL DESIGNATION WAS REQUIRED.
Consequence & remedy
Consequence: IF THE WHEEL RIM SIZE IS INCORRECTLY PRINTED ON A TIRE/CERTIFICATION LABEL, A SERVICE TECHNICIAN WHO SOLELY USES THE TIRE/CERTIFICATION LABEL FOR SERVICE INFORMATION MAY ATTEMPT TO REPLACE A DAMAGED WHEEL WITH AN INCORRECT WHEEL.
Remedy: OWNERS WILL BE PROVIDED WITH A CORRECTED LABEL AND INSTALLATION INSTRUCTIONS. OWNER NOTIFICATION BEGAN ON DECEMBER 15, 2003. OWNERS SHOULD CONTACT SATURN AT 1-800-553-6000.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE04052 · Rear Suspension Toe Control Link
Opened Jul 22, 2004 · Closed Nov 1, 2004
Status: closed (inferred from source dates) · Suspension; Suspension:rear
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS PRELIMINARY EVALUATION TO INVESTIGATE ALLEGATIONS OF REAR SUSPENSION FAILURE IN THE SUBJECT VEHICLES DURING CERTAIN SEVERE DRIVING MANEUVERS.THE INVESTIGATION WAS PROMPTED BY NHTSA-CONDUCTED NCAP DYNAMIC ROLLOVER TEST INCIDENTS INVOLVING MY 2004 SATURN VUE VEHICLES AND ONE CONSUMER COMPLAINT THAT ALLEGED WHEN RECOVERING FROM A ROAD EDGE DEPARTURE, THE LEFT-REAR WHEEL OF A MY 2003 SATURN VUE ?BENT UNDERNEATH THE VEHICLE,? RESULTING IN A ROLLOVER CRASH.ODI ANALYSIS INDICATES THAT REAR SUSPENSION FAILURE DURING THE NCAP TESTS WAS THE RESULT OF WHEEL RIM-PAVEMENT CONTACT TRANSMITTING SIGNIFICANT COMPRESSIVE FORCES TO THE TOE CONTROL LINK, THUS CAUSING IT TO BUCKLE.THIS FAILURE OCCURRED AT LOW SPEED DURING A SEVERE TEST USED TO ASSESS ROLL STABILITY.THE FORCES GENERATED DURING THIS TYPE OF WHEEL-RIM PAVEMENT CONTACT ARE MORE THAN SIX TIMES THE GREATEST FORCES MEASURED DURING GM?S MOST SEVERE VEHICLE DEVELOPMENT AND VALIDATION TESTING.ODI INSPECTION AND ANALYSIS OF CONSUMER COMPLAINT VEHICLES SHOWED THAT DAMAGE TO THE TOE CONTROL LINK APPEARED TO BE THE RESULT OF VEHICLE CRASHES AND DID NOT PRECIPITATE THE CRASHES.TO DATE, ODI IS AWARE OF NO VEHICLE CRASHES OR ROLLOVER INCIDENTS RELATED TO THE ALLEGED DEFECT.ADDITIONALLY, THE MANUFACTURER HAS NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY CUSTOMER SATISFACTION SERVICE CAMPAIGN TO STRENGTHEN THE REAR SUSPENSION OF THE SUBJECT VEHICLES.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED. ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT ATTACHED FOR FURTHER DETAIL.
Additional source detail variants (2)
Suspension
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS PRELIMINARY EVALUATION TO INVESTIGATE ALLEGATIONS OF REAR SUSPENSION FAILURE IN THE SUBJECT VEHICLES DURING CERTAIN SEVERE DRIVING MANEUVERS.THE INVESTIGATION WAS PROMPTED BY NHTSA-CONDUCTED NCAP DYNAMIC ROLLOVER TEST INCIDENTS INVOLVING MY 2004 SATURN VUE VEHICLES AND ONE CONSUMER COMPLAINT THAT ALLEGED WHEN RECOVERING FROM A ROAD EDGE DEPARTURE, THE LEFT-REAR WHEEL OF A MY 2003 SATURN VUE ?BENT UNDERNEATH THE VEHICLE,? RESULTING IN A ROLLOVER CRASH.ODI ANALYSIS INDICATES THAT REAR SUSPENSION FAILURE DURING THE NCAP TESTS WAS THE RESULT OF WHEEL RIM-PAVEMENT CONTACT TRANSMITTING SIGNIFICANT COMPRESSIVE FORCES TO THE TOE CONTROL LINK, THUS CAUSING IT TO BUCKLE.THIS FAILURE OCCURRED AT LOW SPEED DURING A SEVERE TEST USED TO ASSESS ROLL STABILITY.THE FORCES GENERATED DURING THIS TYPE OF WHEEL-RIM PAVEMENT CONTACT ARE MORE THAN SIX TIMES THE GREATEST FORCES MEASURED DURING GM?S MOST SEVERE VEHICLE DEVELOPMENT AND VALIDATION TESTING.ODI INSPECTION AND ANALYSIS OF CONSUMER COMPLAINT VEHICLES SHOWED THAT DAMAGE TO THE TOE CONTROL LINK APPEARED TO BE THE RESULT OF VEHICLE CRASHES AND DID NOT PRECIPITATE THE CRASHES.TO DATE, ODI IS AWARE OF NO VEHICLE CRASHES OR ROLLOVER INCIDENTS RELATED TO THE ALLEGED DEFECT.ADDITIONALLY, THE MANUFACTURER HAS NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY CUSTOMER SATISFACTION SERVICE CAMPAIGN TO STRENGTHEN THE REAR SUSPENSION OF THE SUBJECT VEHICLES.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED. ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT ATTACHED FOR FURTHER DETAIL.
Suspension:rear
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS PRELIMINARY EVALUATION TO INVESTIGATE ALLEGATIONS OF REAR SUSPENSION FAILURE IN THE SUBJECT VEHICLES DURING CERTAIN SEVERE DRIVING MANEUVERS.THE INVESTIGATION WAS PROMPTED BY NHTSA-CONDUCTED NCAP DYNAMIC ROLLOVER TEST INCIDENTS INVOLVING MY 2004 SATURN VUE VEHICLES AND ONE CONSUMER COMPLAINT THAT ALLEGED WHEN RECOVERING FROM A ROAD EDGE DEPARTURE, THE LEFT-REAR WHEEL OF A MY 2003 SATURN VUE ?BENT UNDERNEATH THE VEHICLE,? RESULTING IN A ROLLOVER CRASH.ODI ANALYSIS INDICATES THAT REAR SUSPENSION FAILURE DURING THE NCAP TESTS WAS THE RESULT OF WHEEL RIM-PAVEMENT CONTACT TRANSMITTING SIGNIFICANT COMPRESSIVE FORCES TO THE TOE CONTROL LINK, THUS CAUSING IT TO BUCKLE.THIS FAILURE OCCURRED AT LOW SPEED DURING A SEVERE TEST USED TO ASSESS ROLL STABILITY.THE FORCES GENERATED DURING THIS TYPE OF WHEEL-RIM PAVEMENT CONTACT ARE MORE THAN SIX TIMES THE GREATEST FORCES MEASURED DURING GM?S MOST SEVERE VEHICLE DEVELOPMENT AND VALIDATION TESTING.ODI INSPECTION AND ANALYSIS OF CONSUMER COMPLAINT VEHICLES SHOWED THAT DAMAGE TO THE TOE CONTROL LINK APPEARED TO BE THE RESULT OF VEHICLE CRASHES AND DID NOT PRECIPITATE THE CRASHES.TO DATE, ODI IS AWARE OF NO VEHICLE CRASHES OR ROLLOVER INCIDENTS RELATED TO THE ALLEGED DEFECT.ADDITIONALLY, THE MANUFACTURER HAS NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY CUSTOMER SATISFACTION SERVICE CAMPAIGN TO STRENGTHEN THE REAR SUSPENSION OF THE SUBJECT VEHICLES.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED. ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT ATTACHED FOR FURTHER DETAIL.