IllustrationVEHICLE WAS RECALLED, AND THERE WILL BE 45-60 DAYS BEFORE THE PART WILL BE AVAILABLE, THEY WILL SEND CONSUMER A LETTER. MANUFACTURER STATED TO CONSUMER THEY DID NOT HAVE TO DO RECALL REPAIRS ON THE . REAR SUSPENSION SEAL. THEY WERE NOT FORCED TO DO THIS, AND THEY WOULD NOT DO IT ON THEIR OWN.*AK
2004 Saturn Vue
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2004 Saturn Vue do not stand out strongly from the model-year median of 276.
About this comparison →How this year compares
Owner complaints by model year
Compare all Vue years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
440–25K
3225–50K
3250–75K
4675–100K
52100–150K
31150K+
237 reports with mileage · 39 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Power Train. Review the 93 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 78 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Suspension. Review the 33 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
23 crash reports5 fire reports15 injury reports
Suspension complaints
33 reportsMY SON WAS DRIVING MY 2004 SATURN VUE ON MONDAY, JULY 26, HE APPARENTLY HIT A PATCH OF GRAVEL WHICH CAUSED HIM TO LOSE CONTROL. WHEN HE ATTEMPTED TO REGAIN CONTROL OF THE VEHICLE IT WENT INTO THE DITCH ON THE OPPOSITE SIDE OF THE ROAD WHERE THE PASSENGER SIDE REAR WHEEL COLLAPSED AND THE VEHICLE OVERTURNED. THERE IS EXTENSIVE …
Read full complaint
MY SON WAS DRIVING MY 2004 SATURN VUE ON MONDAY, JULY 26, HE APPARENTLY HIT A PATCH OF GRAVEL WHICH CAUSED HIM TO LOSE CONTROL. WHEN HE ATTEMPTED TO REGAIN CONTROL OF THE VEHICLE IT WENT INTO THE DITCH ON THE OPPOSITE SIDE OF THE ROAD WHERE THE PASSENGER SIDE REAR WHEEL COLLAPSED AND THE VEHICLE OVERTURNED. THERE IS EXTENSIVE DAMAGE TO THE VEHICLE ON THE FRONT END AND PASSENGER SIDE, AS WELL AS TO THE SHIFT CASING INSIDE THE VUE FROM WHEN MY SON'S KNEE SLAMMED INTO IT. THE VEHICLE IS STILL BEING ESTIMATED FOR INSURANCE PURPOSES (EITHER TO TOTAL IT OR REPAIR IT).*AK
I WAS INVOLVED IN A CAR ACCIDENT ON JULY 14, 2004 WHILE IN MY 2004 SATURN VUE FRONT WHEEL DRIVE. I WAS HIT ON THE REAR PASSENGER TIRE AREA AND THE BACK TIRE BENT UNDER THE CAR AND MY SATURN WAS TIPPED OVER AND SPUN AROUND WITH THE DRIVERS SIDE DOWN ON THE PAVEMENT. THIS WAS NOT A HIGH SPEED ACCIDENT. I WAS PROBABLY ABOUT 20MILES…
Read full complaint
I WAS INVOLVED IN A CAR ACCIDENT ON JULY 14, 2004 WHILE IN MY 2004 SATURN VUE FRONT WHEEL DRIVE. I WAS HIT ON THE REAR PASSENGER TIRE AREA AND THE BACK TIRE BENT UNDER THE CAR AND MY SATURN WAS TIPPED OVER AND SPUN AROUND WITH THE DRIVERS SIDE DOWN ON THE PAVEMENT. THIS WAS NOT A HIGH SPEED ACCIDENT. I WAS PROBABLY ABOUT 20MILES PER HOUR AND THE PERSON THAT HIT WAS PROBABLY BETWEEN 25-35MPH. MY SATURN VUE SUSTAINED ABOUT $10,500 DAMAGE SOME OF WHICH WAS THE REAR SUSPENSION. I DO NOT YET KNOW OF THE FINAL OUTCOME WITH THE INSURANCE WHETHER IT WILL BE REPAIRED OR TOTALLED. I JUST HAPPENED TO READ THE KANSAS CITY STAR TODAY 7-27-04 ABIYT TGE GOVERNMENT SAFETY AGENCY INVESTIGATING THE SATURN VUE AND THIS FIT THE DESCRIPTION COMPLETELY.*AK
Official recalls
214V490000 · Electrical System:ignition
Aug 8, 2014
General Motors LLC (GM) is recalling certain model year 2002-2004 Saturn Vue vehicles manufactured September 11, 2001, to April 6, 2004. In the affected vehicles, it may be possible for the key to be removed from the ignition when the ignition is not in the "Off" position.
Consequence & remedy
Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
Remedy: GM will notify owners, and dealers will inspect the vehicle to see if the key can be pulled out when the ignition is off. If it can, dealers will replace the ignition cylinder and keys, free of charge. The recall began in October 2014. Owners may contact Saturn customer service at 1-800-553-6000. GM's number for this recall is 14506. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.
03V519000 · Equipment:other:labels
Dec 19, 2003
CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH 3.5L V6 (L66) ENGINES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, "TIRE SELECTION AND RIMS FOR VEHICLES OTHER THAN PASSENGER CARS." THE FRONT AND REAR WHEEL RIM SIZE SPECIFICATIONS ON THE TIRE/CERTIFICATION LABEL ARE NOT CORRECT. THE PRINTED WHEEL RIM DESIGNATION SPECIFIED A 16-INCH WHEEL WHEN A 17-INCH WHEEL DESIGNATION WAS REQUIRED.
Consequence & remedy
Consequence: IF THE WHEEL RIM SIZE IS INCORRECTLY PRINTED ON A TIRE/CERTIFICATION LABEL, A SERVICE TECHNICIAN WHO SOLELY USES THE TIRE/CERTIFICATION LABEL FOR SERVICE INFORMATION MAY ATTEMPT TO REPLACE A DAMAGED WHEEL WITH AN INCORRECT WHEEL.
Remedy: OWNERS WILL BE PROVIDED WITH A CORRECTED LABEL AND INSTALLATION INSTRUCTIONS. OWNER NOTIFICATION BEGAN ON DECEMBER 15, 2003. OWNERS SHOULD CONTACT SATURN AT 1-800-553-6000.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE04052 · Rear Suspension Toe Control Link
Opened Jul 22, 2004 · Closed Nov 1, 2004
Status: closed (inferred from source dates) · Suspension; Suspension:rear
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS PRELIMINARY EVALUATION TO INVESTIGATE ALLEGATIONS OF REAR SUSPENSION FAILURE IN THE SUBJECT VEHICLES DURING CERTAIN SEVERE DRIVING MANEUVERS.THE INVESTIGATION WAS PROMPTED BY NHTSA-CONDUCTED NCAP DYNAMIC ROLLOVER TEST INCIDENTS INVOLVING MY 2004 SATURN VUE VEHICLES AND ONE CONSUMER COMPLAINT THAT ALLEGED WHEN RECOVERING FROM A ROAD EDGE DEPARTURE, THE LEFT-REAR WHEEL OF A MY 2003 SATURN VUE ?BENT UNDERNEATH THE VEHICLE,? RESULTING IN A ROLLOVER CRASH.ODI ANALYSIS INDICATES THAT REAR SUSPENSION FAILURE DURING THE NCAP TESTS WAS THE RESULT OF WHEEL RIM-PAVEMENT CONTACT TRANSMITTING SIGNIFICANT COMPRESSIVE FORCES TO THE TOE CONTROL LINK, THUS CAUSING IT TO BUCKLE.THIS FAILURE OCCURRED AT LOW SPEED DURING A SEVERE TEST USED TO ASSESS ROLL STABILITY.THE FORCES GENERATED DURING THIS TYPE OF WHEEL-RIM PAVEMENT CONTACT ARE MORE THAN SIX TIMES THE GREATEST FORCES MEASURED DURING GM?S MOST SEVERE VEHICLE DEVELOPMENT AND VALIDATION TESTING.ODI INSPECTION AND ANALYSIS OF CONSUMER COMPLAINT VEHICLES SHOWED THAT DAMAGE TO THE TOE CONTROL LINK APPEARED TO BE THE RESULT OF VEHICLE CRASHES AND DID NOT PRECIPITATE THE CRASHES.TO DATE, ODI IS AWARE OF NO VEHICLE CRASHES OR ROLLOVER INCIDENTS RELATED TO THE ALLEGED DEFECT.ADDITIONALLY, THE MANUFACTURER HAS NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY CUSTOMER SATISFACTION SERVICE CAMPAIGN TO STRENGTHEN THE REAR SUSPENSION OF THE SUBJECT VEHICLES.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED. ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT ATTACHED FOR FURTHER DETAIL.
Additional source detail variants (2)
Suspension
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS PRELIMINARY EVALUATION TO INVESTIGATE ALLEGATIONS OF REAR SUSPENSION FAILURE IN THE SUBJECT VEHICLES DURING CERTAIN SEVERE DRIVING MANEUVERS.THE INVESTIGATION WAS PROMPTED BY NHTSA-CONDUCTED NCAP DYNAMIC ROLLOVER TEST INCIDENTS INVOLVING MY 2004 SATURN VUE VEHICLES AND ONE CONSUMER COMPLAINT THAT ALLEGED WHEN RECOVERING FROM A ROAD EDGE DEPARTURE, THE LEFT-REAR WHEEL OF A MY 2003 SATURN VUE ?BENT UNDERNEATH THE VEHICLE,? RESULTING IN A ROLLOVER CRASH.ODI ANALYSIS INDICATES THAT REAR SUSPENSION FAILURE DURING THE NCAP TESTS WAS THE RESULT OF WHEEL RIM-PAVEMENT CONTACT TRANSMITTING SIGNIFICANT COMPRESSIVE FORCES TO THE TOE CONTROL LINK, THUS CAUSING IT TO BUCKLE.THIS FAILURE OCCURRED AT LOW SPEED DURING A SEVERE TEST USED TO ASSESS ROLL STABILITY.THE FORCES GENERATED DURING THIS TYPE OF WHEEL-RIM PAVEMENT CONTACT ARE MORE THAN SIX TIMES THE GREATEST FORCES MEASURED DURING GM?S MOST SEVERE VEHICLE DEVELOPMENT AND VALIDATION TESTING.ODI INSPECTION AND ANALYSIS OF CONSUMER COMPLAINT VEHICLES SHOWED THAT DAMAGE TO THE TOE CONTROL LINK APPEARED TO BE THE RESULT OF VEHICLE CRASHES AND DID NOT PRECIPITATE THE CRASHES.TO DATE, ODI IS AWARE OF NO VEHICLE CRASHES OR ROLLOVER INCIDENTS RELATED TO THE ALLEGED DEFECT.ADDITIONALLY, THE MANUFACTURER HAS NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY CUSTOMER SATISFACTION SERVICE CAMPAIGN TO STRENGTHEN THE REAR SUSPENSION OF THE SUBJECT VEHICLES.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED. ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT ATTACHED FOR FURTHER DETAIL.
Suspension:rear
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS PRELIMINARY EVALUATION TO INVESTIGATE ALLEGATIONS OF REAR SUSPENSION FAILURE IN THE SUBJECT VEHICLES DURING CERTAIN SEVERE DRIVING MANEUVERS.THE INVESTIGATION WAS PROMPTED BY NHTSA-CONDUCTED NCAP DYNAMIC ROLLOVER TEST INCIDENTS INVOLVING MY 2004 SATURN VUE VEHICLES AND ONE CONSUMER COMPLAINT THAT ALLEGED WHEN RECOVERING FROM A ROAD EDGE DEPARTURE, THE LEFT-REAR WHEEL OF A MY 2003 SATURN VUE ?BENT UNDERNEATH THE VEHICLE,? RESULTING IN A ROLLOVER CRASH.ODI ANALYSIS INDICATES THAT REAR SUSPENSION FAILURE DURING THE NCAP TESTS WAS THE RESULT OF WHEEL RIM-PAVEMENT CONTACT TRANSMITTING SIGNIFICANT COMPRESSIVE FORCES TO THE TOE CONTROL LINK, THUS CAUSING IT TO BUCKLE.THIS FAILURE OCCURRED AT LOW SPEED DURING A SEVERE TEST USED TO ASSESS ROLL STABILITY.THE FORCES GENERATED DURING THIS TYPE OF WHEEL-RIM PAVEMENT CONTACT ARE MORE THAN SIX TIMES THE GREATEST FORCES MEASURED DURING GM?S MOST SEVERE VEHICLE DEVELOPMENT AND VALIDATION TESTING.ODI INSPECTION AND ANALYSIS OF CONSUMER COMPLAINT VEHICLES SHOWED THAT DAMAGE TO THE TOE CONTROL LINK APPEARED TO BE THE RESULT OF VEHICLE CRASHES AND DID NOT PRECIPITATE THE CRASHES.TO DATE, ODI IS AWARE OF NO VEHICLE CRASHES OR ROLLOVER INCIDENTS RELATED TO THE ALLEGED DEFECT.ADDITIONALLY, THE MANUFACTURER HAS NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY CUSTOMER SATISFACTION SERVICE CAMPAIGN TO STRENGTHEN THE REAR SUSPENSION OF THE SUBJECT VEHICLES.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED. ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT ATTACHED FOR FURTHER DETAIL.