TL* THE CONTACT OWNS A 2004 SATURN VUE. THE CONTACT STATED THAT THE KEY RELEASED OUT OF THE IGNITION WHILE THE VEHICLE WAS IN MOTION ON SEVERAL OCCASIONS. THE CONTACT STATED THAT THE FAILURE WAS PROGRESSING. THE VEHICLE WAS NOT DIAGNOSED. THE CONTACT WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 14V490000 (ELECTRICAL SYSTEM). TH…
Read full complaint
TL* THE CONTACT OWNS A 2004 SATURN VUE. THE CONTACT STATED THAT THE KEY RELEASED OUT OF THE IGNITION WHILE THE VEHICLE WAS IN MOTION ON SEVERAL OCCASIONS. THE CONTACT STATED THAT THE FAILURE WAS PROGRESSING. THE VEHICLE WAS NOT DIAGNOSED. THE CONTACT WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 14V490000 (ELECTRICAL SYSTEM). THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 75,000.
NHTSA ODI #10672454
75,000 miles · Jan 14, 2015
Electrical System
THE KEY CAN BE REMOVED WITH THE VEHICLE RUNNING. WENT ON RECALL WEBSITE AND SEEN SIMILAR PROBLEMS HAVE BEEN REPORTED. VEHICLES OF THIS SAME YEAR HAVE A RECALL ON THEM BUT USING THE VIN NUMBER IT SAYS THIS VEHICLE HAS NO RECALL. *TR
NHTSA ODI #10672444
Mileage unknown · Jan 6, 2015
Electrical System
TL* THE CONTACT OWNS A 2004 SATURN VUE. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V490000 (ELECTRICAL SYSTEM) HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE.…
Read full complaint
TL* THE CONTACT OWNS A 2004 SATURN VUE. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V490000 (ELECTRICAL SYSTEM) HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. THE VIN WAS NOT AVAILABLE.
NHTSA ODI #10670445
100,000 miles · Dec 9, 2014
Electrical System
TL* THE CONTACT OWNS A 2004 SATURN VUE. THE CONTACT STATED THAT THE VEHICLE WAS IN THE ON POSITION WHEN THE IGNITION KEY BECAME DISENGAGED WITHOUT WARNING. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE CONTACT STATED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V490…
Read full complaint
TL* THE CONTACT OWNS A 2004 SATURN VUE. THE CONTACT STATED THAT THE VEHICLE WAS IN THE ON POSITION WHEN THE IGNITION KEY BECAME DISENGAGED WITHOUT WARNING. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE CONTACT STATED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V490000 (ELECTRICAL SYSTEM). THE FAILURE MILEAGE WAS 100,000.
NHTSA ODI #10663127
105,000 miles · Dec 5, 2014
Electrical System
I VISITED THE DEALER ON THAT DATE BECAUSE MY CAR HAS FAULTY IGNITION SWITCH (SOMETIMES KEY DON'T TURN AND THE KEY CAN GO OUT EASILY IN ANY POSITION) AND I HEAR THE NEWS FOR THE RECALL FOR THIS VEHICLE WITH DATE 8/7/2014. THE DEALER WAS UNABLE TO FIND THE RECALL IN GM WEB PAGE, EXACTLY HAPPEN TO ME EVERY TIME I CHECK FOR THIS REC…
Read full complaint
I VISITED THE DEALER ON THAT DATE BECAUSE MY CAR HAS FAULTY IGNITION SWITCH (SOMETIMES KEY DON'T TURN AND THE KEY CAN GO OUT EASILY IN ANY POSITION) AND I HEAR THE NEWS FOR THE RECALL FOR THIS VEHICLE WITH DATE 8/7/2014. THE DEALER WAS UNABLE TO FIND THE RECALL IN GM WEB PAGE, EXACTLY HAPPEN TO ME EVERY TIME I CHECK FOR THIS RECALL AT GM WEB PAGE. I'M WORRY AN ACCIDENT WITH THE FAULTY IGNITION SWITCH WILL OCCUR AT ANY TIME. I HAVE THE PRINTED COPY FROM THE DEALER AT THAT TIME. *TR
NHTSA ODI #10662483
96,000 miles · Dec 4, 2014
Electrical System
KEY CAN BE REMOVED FROM IGNITION IRRESPECTIVE OF IGNITION POSITION. (INCLUDING WHILE IN "RUN" POSITION). VEHICLE IS NOT COVERED UNDER THE RECALL YET MY CONDITION EXISTS AND I AM PRIMARILY CONCERNED THAT AIRBAGS WILL DEPLOY PROPERLY IN A CRASH. FIRST INCIDENT APPROXIMATELY SIX YEARS AGO. THANK YOU. *TR
NHTSA ODI #10662162
105,000 miles · Nov 25, 2014
Electrical System
TL* THE CONTACT OWNS A 2004 SATURN VUE. THE CONTACT STATED THAT THE KEY COULD BE REMOVED OUT OF THE IGNITION SWITCH WITHOUT IT BEING IN THE OFF POSITION. THE CONTACT WAS MADE AWARE OF RECALL NHTSA CAMPAIGN NUMBER: 14V490000 (ELECTRICAL SYSTEM) AND BELIEVED THAT IT WAS DIRECTLY RELATED TO THE FAILURE. THE DEALER WAS CONTACTED AND…
Read full complaint
TL* THE CONTACT OWNS A 2004 SATURN VUE. THE CONTACT STATED THAT THE KEY COULD BE REMOVED OUT OF THE IGNITION SWITCH WITHOUT IT BEING IN THE OFF POSITION. THE CONTACT WAS MADE AWARE OF RECALL NHTSA CAMPAIGN NUMBER: 14V490000 (ELECTRICAL SYSTEM) AND BELIEVED THAT IT WAS DIRECTLY RELATED TO THE FAILURE. THE DEALER WAS CONTACTED AND MADE AWARE OF THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 105,000. UPDATED 12/22/14*LJ THE CONSUMER INFORMED HIS VEHICLE WAS NOT INCLUDED IN THE RECALL, EVEN THOUGH HE EXPERIENCED THE SAME SYMPTOMS. UPDATED 01/07/15
NHTSA ODI #10660934
200,000 miles · Nov 17, 2014
Electrical System
TL* THE CONTACT OWNS A 2004 SATURN VUE. WHILE DRIVING APPROXIMATELY 60 MPH, THE KEY RELEASED FROM THE IGNITION SWITCH AND THE VEHICLE STALLED. THE CONTACT WAS ABLE TO RESTART THE VEHICLE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE APPROXIM…
Read full complaint
TL* THE CONTACT OWNS A 2004 SATURN VUE. WHILE DRIVING APPROXIMATELY 60 MPH, THE KEY RELEASED FROM THE IGNITION SWITCH AND THE VEHICLE STALLED. THE CONTACT WAS ABLE TO RESTART THE VEHICLE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 200,000.
NHTSA ODI #10658627
Mileage unknown · Nov 5, 2014
Electrical System
TL* THE CONTACT OWNS A 2004 SATURN VUE. THE CONTACT STATED THAT THE KEY WAS NOT SECURED IN THE IGNITION AND WAS ABLE TO BE REMOVED WHILE IN THE ON POSITION. THE CONTACT REFERENCED RECALL NHTSA CAMPAIGN NUMBER: 14V490000 (ELECTRICAL SYSTEM). THE VIN WAS NOT INCLUDED UNDER THE RECALL. THE FAILURE RECURRED ON NUMEROUS OCCASIONS. TH…
Read full complaint
TL* THE CONTACT OWNS A 2004 SATURN VUE. THE CONTACT STATED THAT THE KEY WAS NOT SECURED IN THE IGNITION AND WAS ABLE TO BE REMOVED WHILE IN THE ON POSITION. THE CONTACT REFERENCED RECALL NHTSA CAMPAIGN NUMBER: 14V490000 (ELECTRICAL SYSTEM). THE VIN WAS NOT INCLUDED UNDER THE RECALL. THE FAILURE RECURRED ON NUMEROUS OCCASIONS. THE VEHICLE WAS NOT DIAGNOSED. THE FAILURE HAD NOT BEEN REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS UNKNOWN.
NHTSA ODI #10652867
150,000 miles · Oct 28, 2014
Electrical SystemPower Train
TL* THE CONTACT OWNS A 2004 SATURN VUE. THE CONTACT STATED THAT THE KEY WOULD EJECT FROM THE IGNITION WHILE THE VEHICLE WAS STARTED ON SEVERAL OCCASIONS. IN ADDITION, WHILE PARKED IN A DRIVEWAY, THE VEHICLE STARTED TO ROLL AWAY INDEPENDENTLY. THE CONTACT HAD TO APPLY THE EMERGENCY BRAKE TO STOP THE VEHICLE. THE VEHICLE WAS NOT D…
Read full complaint
TL* THE CONTACT OWNS A 2004 SATURN VUE. THE CONTACT STATED THAT THE KEY WOULD EJECT FROM THE IGNITION WHILE THE VEHICLE WAS STARTED ON SEVERAL OCCASIONS. IN ADDITION, WHILE PARKED IN A DRIVEWAY, THE VEHICLE STARTED TO ROLL AWAY INDEPENDENTLY. THE CONTACT HAD TO APPLY THE EMERGENCY BRAKE TO STOP THE VEHICLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 150,000.
General Motors LLC (GM) is recalling certain model year 2002-2004 Saturn Vue vehicles manufactured September 11, 2001, to April 6, 2004. In the affected vehicles, it may be possible for the key to be removed from the ignition when the ignition is not in the "Off" position.
Consequence & remedy
Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
Remedy: GM will notify owners, and dealers will inspect the vehicle to see if the key can be pulled out when the ignition is off. If it can, dealers will replace the ignition cylinder and keys, free of charge. The recall began in October 2014. Owners may contact Saturn customer service at 1-800-553-6000. GM's number for this recall is 14506. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.
CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH 3.5L V6 (L66) ENGINES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, "TIRE SELECTION AND RIMS FOR VEHICLES OTHER THAN PASSENGER CARS." THE FRONT AND REAR WHEEL RIM SIZE SPECIFICATIONS ON THE TIRE/CERTIFICATION LABEL ARE NOT CORRECT. THE PRINTED WHEEL RIM DESIGNATION SPECIFIED A 16-INCH WHEEL WHEN A 17-INCH WHEEL DESIGNATION WAS REQUIRED.
Consequence & remedy
Consequence: IF THE WHEEL RIM SIZE IS INCORRECTLY PRINTED ON A TIRE/CERTIFICATION LABEL, A SERVICE TECHNICIAN WHO SOLELY USES THE TIRE/CERTIFICATION LABEL FOR SERVICE INFORMATION MAY ATTEMPT TO REPLACE A DAMAGED WHEEL WITH AN INCORRECT WHEEL.
Remedy: OWNERS WILL BE PROVIDED WITH A CORRECTED LABEL AND INSTALLATION INSTRUCTIONS. OWNER NOTIFICATION BEGAN ON DECEMBER 15, 2003. OWNERS SHOULD CONTACT SATURN AT 1-800-553-6000.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
PE04052 · Rear Suspension Toe Control Link
Opened Jul 22, 2004 · Closed Nov 1, 2004
Status: closed (inferred from source dates) · Suspension; Suspension:rear
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS PRELIMINARY EVALUATION TO INVESTIGATE ALLEGATIONS OF REAR SUSPENSION FAILURE IN THE SUBJECT VEHICLES DURING CERTAIN SEVERE DRIVING MANEUVERS.THE INVESTIGATION WAS PROMPTED BY NHTSA-CONDUCTED NCAP DYNAMIC ROLLOVER TEST INCIDENTS INVOLVING MY 2004 SATURN VUE VEHICLES AND ONE CONSUMER COMPLAINT THAT ALLEGED WHEN RECOVERING FROM A ROAD EDGE DEPARTURE, THE LEFT-REAR WHEEL OF A MY 2003 SATURN VUE ?BENT UNDERNEATH THE VEHICLE,? RESULTING IN A ROLLOVER CRASH.ODI ANALYSIS INDICATES THAT REAR SUSPENSION FAILURE DURING THE NCAP TESTS WAS THE RESULT OF WHEEL RIM-PAVEMENT CONTACT TRANSMITTING SIGNIFICANT COMPRESSIVE FORCES TO THE TOE CONTROL LINK, THUS CAUSING IT TO BUCKLE.THIS FAILURE OCCURRED AT LOW SPEED DURING A SEVERE TEST USED TO ASSESS ROLL STABILITY.THE FORCES GENERATED DURING THIS TYPE OF WHEEL-RIM PAVEMENT CONTACT ARE MORE THAN SIX TIMES THE GREATEST FORCES MEASURED DURING GM?S MOST SEVERE VEHICLE DEVELOPMENT AND VALIDATION TESTING.ODI INSPECTION AND ANALYSIS OF CONSUMER COMPLAINT VEHICLES SHOWED THAT DAMAGE TO THE TOE CONTROL LINK APPEARED TO BE THE RESULT OF VEHICLE CRASHES AND DID NOT PRECIPITATE THE CRASHES.TO DATE, ODI IS AWARE OF NO VEHICLE CRASHES OR ROLLOVER INCIDENTS RELATED TO THE ALLEGED DEFECT.ADDITIONALLY, THE MANUFACTURER HAS NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY CUSTOMER SATISFACTION SERVICE CAMPAIGN TO STRENGTHEN THE REAR SUSPENSION OF THE SUBJECT VEHICLES.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED. ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT ATTACHED FOR FURTHER DETAIL.
Additional source detail variants (2)
Suspension
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS PRELIMINARY EVALUATION TO INVESTIGATE ALLEGATIONS OF REAR SUSPENSION FAILURE IN THE SUBJECT VEHICLES DURING CERTAIN SEVERE DRIVING MANEUVERS.THE INVESTIGATION WAS PROMPTED BY NHTSA-CONDUCTED NCAP DYNAMIC ROLLOVER TEST INCIDENTS INVOLVING MY 2004 SATURN VUE VEHICLES AND ONE CONSUMER COMPLAINT THAT ALLEGED WHEN RECOVERING FROM A ROAD EDGE DEPARTURE, THE LEFT-REAR WHEEL OF A MY 2003 SATURN VUE ?BENT UNDERNEATH THE VEHICLE,? RESULTING IN A ROLLOVER CRASH.ODI ANALYSIS INDICATES THAT REAR SUSPENSION FAILURE DURING THE NCAP TESTS WAS THE RESULT OF WHEEL RIM-PAVEMENT CONTACT TRANSMITTING SIGNIFICANT COMPRESSIVE FORCES TO THE TOE CONTROL LINK, THUS CAUSING IT TO BUCKLE.THIS FAILURE OCCURRED AT LOW SPEED DURING A SEVERE TEST USED TO ASSESS ROLL STABILITY.THE FORCES GENERATED DURING THIS TYPE OF WHEEL-RIM PAVEMENT CONTACT ARE MORE THAN SIX TIMES THE GREATEST FORCES MEASURED DURING GM?S MOST SEVERE VEHICLE DEVELOPMENT AND VALIDATION TESTING.ODI INSPECTION AND ANALYSIS OF CONSUMER COMPLAINT VEHICLES SHOWED THAT DAMAGE TO THE TOE CONTROL LINK APPEARED TO BE THE RESULT OF VEHICLE CRASHES AND DID NOT PRECIPITATE THE CRASHES.TO DATE, ODI IS AWARE OF NO VEHICLE CRASHES OR ROLLOVER INCIDENTS RELATED TO THE ALLEGED DEFECT.ADDITIONALLY, THE MANUFACTURER HAS NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY CUSTOMER SATISFACTION SERVICE CAMPAIGN TO STRENGTHEN THE REAR SUSPENSION OF THE SUBJECT VEHICLES.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED. ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT ATTACHED FOR FURTHER DETAIL.
Suspension:rear
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS PRELIMINARY EVALUATION TO INVESTIGATE ALLEGATIONS OF REAR SUSPENSION FAILURE IN THE SUBJECT VEHICLES DURING CERTAIN SEVERE DRIVING MANEUVERS.THE INVESTIGATION WAS PROMPTED BY NHTSA-CONDUCTED NCAP DYNAMIC ROLLOVER TEST INCIDENTS INVOLVING MY 2004 SATURN VUE VEHICLES AND ONE CONSUMER COMPLAINT THAT ALLEGED WHEN RECOVERING FROM A ROAD EDGE DEPARTURE, THE LEFT-REAR WHEEL OF A MY 2003 SATURN VUE ?BENT UNDERNEATH THE VEHICLE,? RESULTING IN A ROLLOVER CRASH.ODI ANALYSIS INDICATES THAT REAR SUSPENSION FAILURE DURING THE NCAP TESTS WAS THE RESULT OF WHEEL RIM-PAVEMENT CONTACT TRANSMITTING SIGNIFICANT COMPRESSIVE FORCES TO THE TOE CONTROL LINK, THUS CAUSING IT TO BUCKLE.THIS FAILURE OCCURRED AT LOW SPEED DURING A SEVERE TEST USED TO ASSESS ROLL STABILITY.THE FORCES GENERATED DURING THIS TYPE OF WHEEL-RIM PAVEMENT CONTACT ARE MORE THAN SIX TIMES THE GREATEST FORCES MEASURED DURING GM?S MOST SEVERE VEHICLE DEVELOPMENT AND VALIDATION TESTING.ODI INSPECTION AND ANALYSIS OF CONSUMER COMPLAINT VEHICLES SHOWED THAT DAMAGE TO THE TOE CONTROL LINK APPEARED TO BE THE RESULT OF VEHICLE CRASHES AND DID NOT PRECIPITATE THE CRASHES.TO DATE, ODI IS AWARE OF NO VEHICLE CRASHES OR ROLLOVER INCIDENTS RELATED TO THE ALLEGED DEFECT.ADDITIONALLY, THE MANUFACTURER HAS NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY CUSTOMER SATISFACTION SERVICE CAMPAIGN TO STRENGTHEN THE REAR SUSPENSION OF THE SUBJECT VEHICLES.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED. ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT ATTACHED FOR FURTHER DETAIL.
2004 Saturn Vue Problems, Complaints & Recalls | Skip That Year
Illustration