Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 38 of 227 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Engine And Engine Cooling. Review the 38 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 31 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Seat Belts. Review the 25 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
29 crash reports9 fire reports23 injury reports
What owners actually said
227 reports
Mileage unknown · Mar 31, 2006
Parking Brake
I HAVE A 1997 SATURN SL2. THE "BUTTON" ON MY PARKING BRAKE HANDLE POPPED OFF THE OTHER DAY (03/27/2006), RELEASING MY PARKING BRAKE. LUCKILY I WAS NOT ON A STEEP HILL AND THE TRANSMISSION WAS IN GEAR, OTHERWISE THE CAR WOULD HAVE ROLLED AWAY. ITS HARD TO BELIEVE THAT SUCH A TINY PIECE OF "PLASTIC" IS ALL THAT HOLDS THE PARKIN…
Read full complaint
I HAVE A 1997 SATURN SL2. THE "BUTTON" ON MY PARKING BRAKE HANDLE POPPED OFF THE OTHER DAY (03/27/2006), RELEASING MY PARKING BRAKE. LUCKILY I WAS NOT ON A STEEP HILL AND THE TRANSMISSION WAS IN GEAR, OTHERWISE THE CAR WOULD HAVE ROLLED AWAY. ITS HARD TO BELIEVE THAT SUCH A TINY PIECE OF "PLASTIC" IS ALL THAT HOLDS THE PARKING BRAKE IN PLACE. ONCE THE BUTTON IS BROKEN, THERE IS NO WAY TO ENGAGE THE PARKING BRAKE. I REALLY THINK THIS WARRANTS A RECALL. *JB
NHTSA ODI #10154263
71,393 miles · Feb 10, 2006
Air BagsInjury
DRIVER WENT OVER A SPEED BUMP WHILE TURNING INTO A PARKING SPACE AND HIT THE PARKING CURB JUST SLIGHTLY WHILE BRAKING. BOTH DRIVER & PASSENGER SIDE AIR BAGS DEPLOYED. *NM
NHTSA ODI #10150000
Mileage unknown · Jan 15, 2006
Engine And Engine Cooling
A EXTREME PROBLEM WITH OIL CONSUMPTION SINCE THE TIME OF OWNERSHIP OF THE VEHICLE AND THE PROBLEM IS GETTING WORSE WITH EVERY MILE DRIVEN. I AM AT THE POINT NOW OF PUTTING/ADDING 2-3 QUARTS OF OIL EVERY 300-400 MILES. ENGINE FREEZE IS NOW ON THE HORIZON DUE TO SLUDGE BUILD-UP. AND I'VE BEEN TOLD THIS IS WHAT SATURNS DO. CAN THIS…
Read full complaint
A EXTREME PROBLEM WITH OIL CONSUMPTION SINCE THE TIME OF OWNERSHIP OF THE VEHICLE AND THE PROBLEM IS GETTING WORSE WITH EVERY MILE DRIVEN. I AM AT THE POINT NOW OF PUTTING/ADDING 2-3 QUARTS OF OIL EVERY 300-400 MILES. ENGINE FREEZE IS NOW ON THE HORIZON DUE TO SLUDGE BUILD-UP. AND I'VE BEEN TOLD THIS IS WHAT SATURNS DO. CAN THIS BE RIGHT TO THE CONSUMER. *NM
NHTSA ODI #10147800
Mileage unknown · Jan 11, 2006
Electrical SystemFire
IGNITION SWITCH FAILED TO START CAR. AFTER A FEW TRIES, THE CAR FINALLY STARTED ONLY TO HAVE MOUNDS OF SMOKE ROLLING OUT FROM UNDER THE DASH. AFTER TURNING THE VEHICLE OFF, THE SWITCH WORKED INTERMITTENTLY. WE REMOVED DASH COVERS AND IGNITION CYLINDER LOCK, AND LOWERED THE STEERING WHEEL TO FIND THAT THE WIRING HARNESS LEADIN…
Read full complaint
IGNITION SWITCH FAILED TO START CAR. AFTER A FEW TRIES, THE CAR FINALLY STARTED ONLY TO HAVE MOUNDS OF SMOKE ROLLING OUT FROM UNDER THE DASH. AFTER TURNING THE VEHICLE OFF, THE SWITCH WORKED INTERMITTENTLY. WE REMOVED DASH COVERS AND IGNITION CYLINDER LOCK, AND LOWERED THE STEERING WHEEL TO FIND THAT THE WIRING HARNESS LEADING TO THE IGNITION SWITCH HAD WHAT WAS A BLACK WIRE THAT WAS MELTED BARE FOR A COUPLE INCHES, AND DISFIGURED THE ENTIRE WIRE, AND MELTED THE INSULATION TO OTHER WIRES WITHIN THE HARNESS. JUDGING BY THE DAMAGE OF DONE TO THE WIRE, IT APPEARS THAT THE MOST HEAT WAS IN AN AREA WHERE THE WIRE WAS CLOSEST TO THE STEERING COLUMN, LEADING ONE TO BELIEVE THAT IT WORE THROUGH AND GROUNDED ITSELF TO THE STEERING COLUMN, WHICH LED TO THE OVERHEATING OF THE WIRE AND SUBSEQUENT SMOKE/FIRE. *JB
NHTSA ODI #10147402
Mileage unknown · Dec 23, 2005
Engine And Engine Cooling
DT: THE CONTACT STATED WHILE DRIVING VEHICLE STALLED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT REPAIR SHOP. THEY FOUND THAT IT WAS THE CAM SHAFT SENSOR THAT WAS DEFECTIVE. NO REPAIRS WERE MADE.*AK
NHTSA ODI #10146009
Mileage unknown · Nov 29, 2005
Electrical SystemFire
WHEN TURNING THE SWITCH TO START THE ENGINE, THE STARTER MOTOR STOPPED AN SMOKE STARTED COMING FROM THE DASHBOARD. THE VEHICLE WAS TOWED TO THE DEALERSHIP WHERE IT DIAGNOSED THAT THE SWITCH HAD SHORTED OUT. ANOTHER COMPONENT FAILURE RESULTED FROM THE SHORTENING OF THE SWITCH. THE IGNITION CYLINDER SEEMS TO BE A PROBLEM; HOW…
Read full complaint
WHEN TURNING THE SWITCH TO START THE ENGINE, THE STARTER MOTOR STOPPED AN SMOKE STARTED COMING FROM THE DASHBOARD. THE VEHICLE WAS TOWED TO THE DEALERSHIP WHERE IT DIAGNOSED THAT THE SWITCH HAD SHORTED OUT. ANOTHER COMPONENT FAILURE RESULTED FROM THE SHORTENING OF THE SWITCH. THE IGNITION CYLINDER SEEMS TO BE A PROBLEM; HOWEVER, I CAN NOT FIND INFORMATION ON SAFEY RECALLS. WEB SITE HTTP://WWW.ALLDATA.COM/TSB/53/975307FC.HTML SHOWS WHAT APPEARS TO BE A SAFEY RECALL 97-C-02 APR 97, TSB TITLE IGNITION CYLINDER MALFUNCTION. *NM
NHTSA ODI #10143884
145,610 miles · Oct 16, 2005
Air BagsCrashInjury
MY CAR WAS BACKED INTO IN AN ACCIDENT WHICH PUSHED THE FROND END BACK INTO THE RADIATOR SUPPORT AND BUCKLED THE HOOD. THE CAR IN FRONT OF ME STOPPED AS WE WERE GOING DOWN THE STREET AT ABOUT 25 MPH, THEN REVERSED AT TOP SPEED INTO MY FRONT END. NEITHER AIRBAG DEPLOYED. *NM
NHTSA ODI #10139819
Mileage unknown · Jun 28, 2005
Child Seat
THE REAR ANCHOR ON THE CAR SEAT BASE SLIPPED OUT OF ITS POSITION. *JB THE CARRIER HAD GOTTEN STUCK AND WAS REMOVED. *SC 8JB
NHTSA ODI #10127906
54,000 miles · May 6, 2005
Seat Belts
THE CONSUMER COMPLAINED ABOUT THE FRONT SEAT BELT PROBLEM. THE DRIVER'S SIDE SEAT BELT WILL NOT RETRACT AFTER USE. THE PASSENGER'S SIDE SEAT BELT WILL NOT EXTEND OUT FOR USE. THE CONSUMER TOOK THE VEHICLE TO THE DEALER, AND WAS INFORMED THAT THE REPAIR WILL COST $900.00. *AK *SC
NHTSA ODI #10117825
68,000 miles · Apr 26, 2005
Engine And Engine Cooling
HEAD GASKET BLEW AT 68,00 MILES IN MY 1997 SATURN SL1. SATURN CUSTOMER SERVICE TOLD ME IT WAS NOT DUE TO ANY NEGLIGENCE ON MY PART, AND THEY WERE UNABLE TO EXPLAIN THE REASON FOR THIS DEFECT.*AK
VEHICLE DESCRIPTION: PASSSENGER VEHICLES. THESE VEHICLES WERE BUILT WITH SUSPECT COLD WELDS ON THE RIGHT SIDE IN THE TUNNEL AREA OF THE FLOOR PAN. THIS DOES NOT COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 210, "SEAT BELT ANCHORAGE."
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE SEAT OCCUPANT MAY NOT BE PROPERLY RESTRAINED INCREASING THE RISK OF PERSONAL INJURY.
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH MANUAL STEERING. THE PINION BEARING CAGE IN THE STEERING GEAR CAN SEPARATE UNDER HIGH STEERING SYSTEM LOAD CONDITIONS, SUCH AS PARKING LOT OR SIMILAR LOW SPEED MANEUVERS.
Consequence & remedy
Consequence: THIS COULD RESULT IN THE PINION GEAR DISENGAGING FROM THE RACK CAUSING A LOSS OF STEERING CONTROL.
Remedy: DEALERS WILL REPLACE THE MANUAL STEERING GEAR ASSEMBLY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
1997 Saturn Sl Problems, Complaints & Recalls | Skip That Year
Illustration