ACTUAL PART A SMALL BUSHING CONNECTING THE SHIFTER (1-5) TO CLUTCH CABLE BROKE OFF WITH OUT ANY WARNING HAVING SPOKEN TO A NUMBER OF SATURN DEALERS THIS SEEMS TO BE A COMMON OCCURRENCE ON FURTHER INVESTIGATION I DISCOVERED SIMILAR RECALLS ON 1996 AND 97 MANY PEOPLE MIGHT NOT EVEN BEAWARE OF WHAT THE REAL PROBLEM WAS UNLESS THEY …
Read full complaint
ACTUAL PART A SMALL BUSHING CONNECTING THE SHIFTER (1-5) TO CLUTCH CABLE BROKE OFF WITH OUT ANY WARNING HAVING SPOKEN TO A NUMBER OF SATURN DEALERS THIS SEEMS TO BE A COMMON OCCURRENCE ON FURTHER INVESTIGATION I DISCOVERED SIMILAR RECALLS ON 1996 AND 97 MANY PEOPLE MIGHT NOT EVEN BEAWARE OF WHAT THE REAL PROBLEM WAS UNLESS THEY REMOVED THE CONSOLE LIKE I DID. SATURN CLAIMS IT IS THE SUPPLIERS FAULT AND THAT I HAVE TO AN ENTIRE TWO CABLE PACKAGED ASSEMBLY IN ORDER TO REPLACE THE CONNECTOR TOTAL COST $350-$400 DOLLARS I BELIEVE THE CONSUMER IS BEING PUT AT DELIBERATE RISK FOR THERE PROFITS.*AK
NHTSA ODI #754078
Mileage unknown · Sep 28, 1998
Suspension
STEERING WHEEL VIBRATION DURING NORMAL BRAKING AT 30-40 MPH AND SEVERE VIBRATION DURING EMERGENCY BRAKING AT HIGHWAY SPPEDS.
NHTSA ODI #541771
Mileage unknown · Dec 5, 1996
Service Brakes, HydraulicSuspension
WHEN APPLYING ABS BRAKES EXPERIENCES ERRACTIC OPERATION, VEHICLE PULLS TO LEFT, PEDAL PULSATES AND STEERING WHEEL VIBRATES. DEALER REALIGNED FRONT SUSPENSION TWICE, BRAKE ROTORS AND PADS WERE REPLACED THREE TIMES. *AK
NHTSA ODI #805953
Mileage unknown · Jul 18, 1995
Service Brakes, HydraulicSuspension
FRONT END VIBRATION. *AK
NHTSA ODI #484359
Mileage unknown · Mar 6, 1995
Suspension
VEHICLE CONTINUOUSLY PULLS TOWARD THE RIGHT. *SKD
NHTSA ODI #481378
Mileage unknown · Feb 26, 1995
Electrical SystemEngine And Engine CoolingSeat Belts
VEHICLE DESCRIPTION: PASSENGER VEHICLES. SOME FRONT SEAT BACK RECLINER GEAR TEETH MAY WEAR EXCESSIVELY THROUGH REPEATED USE, AND COULD CAUSE THE SEAT BACK TO SLIP PARTIALLY REARWARD WHEN FORCE IS APPLIED.
Consequence & remedy
Consequence: IF THIS HAPPENS WHILE THE VEHICLE IS BEING DRIVEN, IT COULD CAUSE A LOSS OF CONTROL, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE FRONT SEAT RECLINER MECHANISMS.
THE AUTOMATIC TRANSAXLE PARK LOCK CABLE ASSEMBLY WAS IMPROPERLY ADJUSTED MAKING IT POSSIBLE TO SHIFT FROM THE "PARK" POSITION WITH THE IGNITION KEY REMOVED, OR REMOVE THE IGNITION KEY WITH THE SHIFT LEVER IN A POSITION OTHER THAN "PARK." THIS DOES NOT MEET THE REQUIREMENTS OF FMVSS 114, "THEFT PROTECTION."
Consequence & remedy
Consequence: CONSEQUENCE OF NON-COMPLIANCE: UNINTENDED VEHICLE MOVEMENT CAN OCCUR WHICH COULD RESULT IN AN ACCIDENT.
Remedy: CONSUMERS ARE BEING ASKED TO INSPECT THE PARK LOCK CABLE. IF IT DOES NOT PERFORM CORRECTLY, DEALERS WILL MAKE THE NECESSARY ADJUSTMENTS.
THE STEERING GEAR PINION SHAFT WAS IMPROPERLY HEAT TREATED CAUSING THE SHAFT TO FRACTURE DURING VEHICLE OPERATION.
Consequence & remedy
Consequence: FRACTURE OF THE STEERING GEAR PINION SHAFT CAUSES COMPLETE LOSS OF STEERING CONTROL WHICH CAN RESULT IN AN ACCIDENT.
Remedy: DEALERS WILL REPLACE THE MANUAL STEERING ASSEMBLY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3
RQ00005 · Front Seat Back Can Recline Or Collapse
Opened Feb 16, 2000 · Closed Aug 19, 2000
Status: closed (inferred from source dates) · Seats:front Assembly:recliner
No summary supplied.
EA95003 · Cruise Control Failures
Opened Feb 24, 1995 · Closed May 31, 1996
Status: closed (inferred from source dates) · Equipment
THIS INVESTIGATION DOCUMENTED HTE FUNCTIONAL ABERATIONS THAT HAVE OCCURRED IN THE PERFORMANCE OF THE SUBJECT CRUISE CONTROL SYSTEM.MOST OF THE MALFUNCTIONS INVOLVED FAILURE OF THE SYSTEM TO PROPERLY REGULATE VEHICLE SPEED WHEN ENGAGED, FAILURE OF THE SYSTEM TO ENGAGE, OR SELF-DISENGAGEMENT OF THE SYSTEM. THESE PROBLEMS WERE INVESTIGATED AND STEPS TAKEN BY THE MANUFACTURER TO REMEDY THEIR OCCURRENCES.SERVICE PROCEDURES WERE ISSUED FOR VEHICLES IN USE, AND A DESIGN MODIFICATION MADE FOR NEW VEHICLES.NO CONFIRMED ALLEGATIONS OF FAILURE OF THE SYSTEM TO DISENGAGE UPON COMMAND WERE IDENTIFIED.IMPROVED QUALITY CONTROL PROCEDURES AND DESIGN MODIFICATIONSIN THE SYSTEM WERE UNDERTAKEN TO ENSURE A MORE CONSISTENT LEVEL OF SYSTEM PERFORMANCE.THE DETAILS OF THESE FINDINGS AND THE RESULTING CONCLUSIONS ARE CONTAINED INTHE SUBJECT ENGINEERING ANALYSIS CLOSING REPORT.A SAFETY-RELATED DEFECT TREND WAS NOT IDENTIFIED AT EHIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
PE94079 · Cruise Control Failure
Opened Nov 7, 1994 · Closed Feb 24, 1995
Status: closed (inferred from source dates) · Equipment
There is no summary currently available
1995 Saturn Sl Problems, Complaints & Recalls | Skip That Year
Illustration